H0291800 rev d installation and op er a tion man u al jandy car tridge pool filters cl and cv versa-plumb ® series fil ters warning for your safety - this product must be installed and serviced by a contractor who is licensed and quali fi ed in pool equipment by the jurisdiction in which the product...
Page 3 cartridge pool filters - cl and cv series filters date of installation initial pressure gauge reading (with clean filter) pump model horsepower filter model serial number notes: equipment information record table of contents section 1. Safety information ............................. 4 1.1 im...
Page 4 cartridge pool filters - cl and cv series filters section 1. Safety information 1.1 important safety warning 1. Use equipment only in a pool or spa installation. 2. Before repositioning valve(s) and before beginning the assembly, disassembly, or adjustment of the clamp, or any other service o...
Page 5 cartridge pool filters - cl and cv series filters section 2. General information 2.1 introduction this manual contains information for the proper instal- lation and operation of the jandy cl and cv series cartridge filters. Procedures in this manual must be followed exactly. For technical ass...
Page 6 cartridge pool filters - cl and cv series filters section 3. Installation instructions 3.1 filter location 1. Select a well-drained area, one that does not fl ood when it rains. Damp, non-ventilated areas should be avoided. 2. Provide solid mounting for the fi lter and pump system. Install sy...
Page 7 cartridge pool filters - cl and cv series filters 4. To reduce pressure losses, 2" (minimum) piping is recommended for plumbing the system. 5. For best ef fi ciency use the fewest possible number of fi ttings. This will prevent a restriction in the water fl ow. 5.1 the cv model fi lter comes ...
Page 8 cartridge pool filters - cl and cv series filters figure 5. Cl cartridge filter plumbing for pool/spa combination jandy heater waterfall pool return spa make up spa return from pool skimmer from pool drain spa suction jandy pump jandy check valve from outlet port to inlet port jandy filter fi...
Page 9 figure 7. Sweep elbow note: do not overtighten. Lxi heater cv filter shp pump sweep elbow p/n seaql1001 sweep elbow p/n sefl1002 7½” minimum figure 8. Lxi heater, cv filter and shp pump sweep elbow installation cartridge pool filters - cl and cv series filters 6. Make all plumbing connections...
Page 10 cartridge pool filters - cl and cv series filters 3.5 clamp installation 1. Be certain the o-ring is in position in the lower tank half. Press the fi lter lid over the lower half sandwiching the o-ring between the two halves. 2. Holding the ends of the fi lter clamp apart, position the hinge...
Page 11 cartridge pool filters - cl and cv series filters 9. After the pressure gauge has stabilized, turn the bezel ring so that the arrow next to the word "clean" aligns with the needle of the gauge. As the fi lter cleans the water, and the cartridges begin to clog the pressure begins to increase....
Page 12 cartridge pool filters - cl and cv series filters 5. Product safety signs or labels should be periodically inspected and cleaned by the product user as necessary to maintain good legibility for safe viewing distance. 6. Product safety signs or labels should be replaced by the product user wh...
Page 13 cartridge pool filters - cl and cv series filters table 2. Troubleshooting guide fault symptom possible problems solutions water is not clear. Insufficient disinfectant level. Incorrect pool chemistry. Heavy bathing and/or dirt loads. Insufficient running times. Filter is dirty. Hole in filt...
Page 14 cartridge pool filters - cl and cv series filters key no. Description model no. Part no. 1 handle assembly w/ hardware (set of 2) all r0357100 2 handle hardware (set of 4) all r0359900 3 gauge/air release assembly all r0357200 4 pressure gauge all r0359600 5 tank adapter w/o-ring & union nut...
Page 15 cartridge pool filters - cl and cv series filters 19 26 21 21 20 21 15,21 15 21 18,21 14 19 22 20 22 22 15,22 14 23,25 16 16 22,18 ,21 ,22 23,25 26 6 ,6 ,6 6 8,9 8,9 11, 11, 11, 11, 9.2 jandy cl and cv filters exploded view cl filter cv filter.
Page 16 cartridge pool filters - cl and cv series filters section 10. Head loss curves 10.1 jandy cl and cv car tridge filter design head loss curves 0 2 4 6 8 10 12 14 16 18 20 22 24 26 28 0 30 60 90 120 150 flow rate (gpm) design head loss (ft head) 0 2 4 6 8 10 12 cl340 cv340 cl460 cv460 cl580 cv...
Page 17 notes cartridge pool filters - cl and cv series filters.
Page 18 notes cartridge pool filters - cl and cv series filters.
Page 19 notes *trademarks used herein are the property of their respective owners. Cartridge pool filters - cl and cv series filters.
Zodiac pool systems, inc. 6000 condor drive • moorpark ca usa 93021 • 800-822-7933 • fax: 877-327-1403 © 2010 zodiac pool systems, inc. All rights reserved. 1006 h0291800 rev d.
