1. DL manuals
  2. Jayco
  3. Motorhomes
  4. 2014 PINNACLE TOWABLES RV
  5. User Manual

Jayco 2014 PINNACLE TOWABLES RV User Manual

Manual is about: Motorhomes

Summary of 2014 PINNACLE TOWABLES RV

  • Page 1

    2014 pinnacle towables 0210677.2014 printed on recycled paper.

  • Page 3

    The jayco ecoadvantage is our company’s commitment to protecting the environment. In 2011, our company recycled 5,438 tons of wood, 1,332 tons of scrap metal and 793 tons of cardboard and paper. Through jayco’s company-wide sustainability program, we’re creating better ways to build better rvs using...

  • Page 5

    Pinnacle fifth wheel table of contents i warning: r ead all instructions in this manual and component manufacturer supplied information before using your rv. This manual has been provided by jayco, inc. For the sole purpose of providing instructions concerning the operation and maintenance of this v...

  • Page 6

    Table of contents pinnacle fifth wheel ii section 1: w arranty & s ervice about this manual .............................................................................................. 1-1 customer relations .............................................................................................

  • Page 7

    Pinnacle fifth wheel table of contents iii set up-fifth wheel ............................................................................................ 4-15 spare tire carrier (if so equipped) ..................................................................... 4-5 stabilizer jacks ................

  • Page 8

    Table of contents pinnacle fifth wheel iv fresh water connections ................................................................................... 8-2 fresh water holding tank .................................................................................. 8-2 fresh water system ..................

  • Page 9

    Pinnacle fifth wheel table of contents v s ection 13: e xterior bbq grill (if so equipped) ................................................................................ 13-1 bike rack./cargo tray (if so equipped) ............................................................ 13-8 cleaning the exter...

  • Page 10

    Table of contents pinnacle fifth wheel vi revision a – added water heater note (8-11) 6/20/13.

  • Page 11: Danger

    Jayco towable section 1 – warranty & service 1-1 congratulations! Thank you for selecting a jayco rv. We are excited to welcome you to our growing rv family. Jayco is the largest privately held manufacturer of recreation vehicles in the world. We are committed to being the most respected name in rvs...

  • Page 12: Caution

    Section 1 – warranty & service jayco towable 1-2 r eporting s afety d efects in the united states if you believe that your rv has an alleged defect that could cause a crash or cause injury or death, you should immediately inform the national highway traffic safety administration (nhtsa) and jayco. I...

  • Page 13

    Jayco towable section 1 – warranty & service 1-3 m anufacturing p rocess jayco recreation vehicles are manufactured for use as temporary living quarters for recreation, camping and travel uses, all as defined by the bylaws of the recreation vehicle industry association (rvia). This recreation vehicl...

  • Page 14

    Section 1 – warranty & service jayco towable 1-4 s uggestions f or o btaining s ervice the independent dealers authorized to sell jayco rvs are also there to provide service after the sale. We work closely with them in an effort to keep you satisfied. To help ensure your dealer provides the level of...

  • Page 15

    Jayco towable section 1 – warranty & service 1-5 mailing address shipping address jayco, inc. Jayco, inc. Customer service customer service p.O. Box 460 100 bontrager drive 903 s. Main street bldg 42 door 4220 middlebury in 46540 middlebury in 46540 phone (toll-free) (800) 283-8267 phone (local) (57...

  • Page 16

    Section 1 – warranty & service jayco towable 1-6 j ayco c ustomer f irst e mergency r oadside a ssistance jayco has teamed up with coach-net to offer 24/7 motorist assistance. We are offering this free of charge for the first year of ownership (certain restrictions apply*). You may continue your eme...

  • Page 17

    Jayco towable section 1 – warranty & service 1-7 obtaining weekend or after business hours repair assistance if an authorized jayco dealer is not located nearby, contact your selling dealer for assistance. If your dealer is closed, check with the campground staff or telephone yellow pages for an rv ...

  • Page 18

    Section 1 – warranty & service jayco towable 1-8 tt/fw towable limited warranty what and who is covered the jayco warranty covers this recreational vehicle (“rv”), when used only for its intended purpose of recreational travel and camping, for two (2) years. It covers rv’s that are sold in, and rema...

  • Page 19

    Jayco towable section 1 – warranty & service tt/fw 1-9 this exclusion of consequential and incidental damages shall be independent of any failure of the essential purpose of any warranty, and this exclusion shall survive any determination that this limited warranty or any implied warranty has failed...

  • Page 20

    Section 1 – warranty & service jayco towable 1-10 tt/fw any rv purchased from a dealer that is not an authorized dealer of jayco; normal wear, tear or usage, such as tears, punctures, soiling, mildew, fading, or discoloration of exterior plastic or fiberglass, or soft goods, such as upholstery, drap...

  • Page 21

    Jayco towable section 1 – warranty & service tt/fw 1-11 ratings, and tampering with any portion of the rv, or any use of the rv as a semi- permanent or permanent home. Legal remedies any action to enforce any portion of this limited warranty, or any implied warranty, shall be commenced within six (6...

  • Page 22

    Section 1 – warranty & service jayco towable 1-12 tt/fw if, on the other hand, the jayco dealer sells this rv to a retail customer then the rental warranty would not be applicable. The rental warranty does not apply to retail consumers. Jayco’s rental program is applicable to the following product l...

  • Page 23

    Jayco towable section 1 – warranty & service tt/fw 1-13 jayco towable rental limited warranty what and who is covered the jayco warranty covers this recreational vehicle (“rv”), when used only for recreational travel and camping, including recreational travel and camping by renters of the dealer, fo...

  • Page 24

    Section 1 – warranty & service jayco towable 1-14 tt/fw how to get service to obtain reimbursement of warranty service the owner must do all of the following: 1. Notify jayco of the substantial defect in material or workmanship attributable to jayco, within the warranty coverage period; 2. Provide t...

  • Page 25

    Jayco towable section 1 – warranty & service tt/fw 1-15 handling, braking, wheel balance, muffler, tires, tubes, batteries, gauges, generator, hydraulic jacks, inverter, converter, microwave, television, dvd/cd player, radio, speakers, television, refrigerator, range, hot water heater, water pump, s...

  • Page 26

    Section 1 – warranty & service jayco towable 1-16 tt/fw care and maintenance it is your responsibility to perform proper care and maintenance of the rv, and to assure correct load distribution. For details regarding this, please see your jayco owner’s manual and other component part manufacturers. T...

  • Page 27: Warning

    Jayco towable section 2 - occupant safety 2-1 f ire s afety if a fire does start, follow these basic safety rules: 1. Have everyone evacuate the rv immediately. 2. After everyone is clear and accounted for, check the fire to see if you can attempt to put it out. 3. If it is large, or the fire is fue...

  • Page 28: Warning

    Section 2 - occupant safety jayco towable 2-2 s moke a larm some of the most common fire safety issues are burning candles, smoking in bed, leaving children unattended and cleaning with flammable fluids. The smoke detector is intended to help reduce those risks. Your rv is equipped with a smoke alar...

  • Page 29: Warning

    Jayco towable section 2 - occupant safety 2-3 fig. 2.1 test smoke alarm maintenance gently vacuum off any dust on the cover of the smoke alarm with your vacuum’s soft brush attachment. Test the smoke alarm once you have vacuumed. Never use water, cleaners or solvents to clean the smoke alarm as they...

  • Page 30: Warning

    Section 2 - occupant safety jayco towable 2-4 c ombination c arbon m onoxide / p ropane a larm your rv is equipped with a combination carbon monoxide (co)/propane alarm that is listed for use in recreation vehicles. The combination carbon monoxide/ propane alarm will only work if it is operational a...

  • Page 31: Warning

    Jayco towable section 2 - occupant safety 2-5 what you should do if the alarm sounds 1. Operate the reset/silence button. 2. Call your emergency services (fire department or 911). 3. Immediately move to fresh air (outdoors or by an open door or window) 4. Do not re-enter the premises or move away fr...

  • Page 32: Warning

    Section 2 - occupant safety jayco towable 2-6 alarm malfunction/low battery: the gas led will remain off and the operational/co led will alternate re/green and the alarm will sound once every 15 seconds. End of life alarm: the led will flash red/red, green/green and the alarm will “beep every 25-30 ...

  • Page 33: Caution

    Jayco towable section 2 - occupant safety 2-7 f ormaldehyde some components in the rv contain formaldehyde-based adhesives that may release formaldehyde fumes into the air for an unknown period of time. Individuals who are allergic to formaldehyde gas fumes may experience irritation to eyes, ears, n...

  • Page 34: Warning

    Section 2 - occupant safety jayco towable 2-8 c ondensation condensation is a natural phenomenon. The amount of condensation will vary with climate conditions, particularly the relative humidity. To reduce condensation proper ventilation and, if needed, the use of a dehumidifier (customer supplied) ...

  • Page 35

    Jayco towable section 2 - occupant safety tt/fw/suv 2-9 s econdary m eans of e scape (e xit w indow ) the emergency egress window is designed to allow quick exit from the rv during an emergency if access to the main entrance door is not available.  make sure all occupants know how to open and opera...

  • Page 36

    Section 2 - occupant safety jayco towable 2-10 tt/fw/suv t his p age i s i ntentionally b lank.

  • Page 37: Warning

    Jayco towable section 3 - pre-travel information 3-1 t ow v ehicle if you plan to tow your rv with a tow vehicle you already own, contact your automotive dealer to find out your vehicle towing capacity. If you plan to purchase a new tow vehicle, be certain to tell your automotive dealer the gvwr, si...

  • Page 38: Warning

    Section 3 - pre-travel information jayco towable 3-2 2. Move the lever on the side of the actuator downward from the “towing position” along the curved slot in the actuator frame to the “backup position.” the slot has a notch at the bottom of its travel. Push the lever down to engage the locking not...

  • Page 39: Warning

    Jayco towable section 3 - pre-travel information 3-3 fig 3.3 trailer weight information label you may question the total weight capacity of the tires on your rv being less than the gvwr; this is correct. In order to calculate the actual weight on the rv tires, it is necessary to include the tongue w...

  • Page 40: Warning

    Section 3 - pre-travel information jayco towable 3-4 store and secure all loose items inside the rv before traveling. Overlooked items such as canned goods, or small appliances on the countertop, cooking pans on the range or free-standing furniture items can become dangerous projectiles during a sud...

  • Page 41: Warning

    Jayco towable section 3 - pre-travel information 3-5 read through all the weighing instructions before you begin. If you have further questions, consult with your dealer or the scale operator. Your rv must be weighed fully loaded (that is with food, clothing, fuel, water, propane, supplies, etc). 1....

  • Page 42: Caution

    Section 3 - pre-travel information jayco towable 3-6 fw f ifth w heel p in b ox (c ustomer s upplied ) hitch selection is important because it affects the towing and handling characteristics of your rv. There are many kinds of hitches available for various uses and assuring that you have the correct...

  • Page 43: Warning

    Jayco towable section 4 - towing & set-up 4-1 fig. 4.1 7-way trailer plug - car end, rear view driving safety and protection against injury cannot be fully ensured. However, we recommend you pay special attention to the following: keep the tires inflated to the specified levels. Replace the tires be...

  • Page 44

    Section 4 towing & set-up jayco towable 4-2 you cannot cut back into the traffic lane as quickly due to the longer length of your tow vehicle/rv combination. Drive with caution to avoid situations that might require quick momentum changes. Even though your rv is equipped with brakes designed for gvw...

  • Page 45: Warning

    Jayco towable section 4 - towing & set-up 4-3 when you determine the site conditions are satisfactory, maneuver the rv into position for backing up into the site space. Back the rv up slowly using your tow vehicle mirrors as a guide. Have another person outside the rv assist you until the rv is park...

  • Page 46: Danger

    Section 4 towing & set-up jayco towable 4-4 c hanging a t ire 1. Keep the rv attached to the tow vehicle. Block the tire on the opposite side of the rv from the tire you are changing. 2. Loosen the wheel lug on the tire you are changing before jacking up the rv. Do not remove the lug nuts; only loos...

  • Page 47: Warning

    Jayco towable section 4 - towing & set-up 4-5 if you have questions regarding your tires, contact the tire manufacturer or jayco customer service. S pare t ire c arrier (i f s o e quipped ) if your rv is equipped with a spare tire, it will either be mounted under the unit (hoist) or on the rear bump...

  • Page 48

    Section 4 towing & set-up jayco towable 4-6 bumper mounted the spare tire bracket can be released and extended down to access a storage compartment at the rear of the trailer without removing the tire. To extend the tire down 1. Remove the cotter key from the pin holding the tire carrier in place. 2...

  • Page 49: Warning

    Jayco towable section 4 - towing & set-up 4-7 warning check and tighten wheel lug nuts regularly to make sure they did not loosen during travel. Wheel lug nuts must be applied and maintained at the proper torque levels to prevent loose wheels, broken studs and possible separation of the wheel(s) fro...

  • Page 50: Warning

    Section 4 towing & set-up jayco towable 4-8 e mergency s topping always carry road flares or reflective warning signs to display if necessary. Pull off the roadway as far as possible for emergency stopping or tire changing. Turn on your rv hazard warning flashers. If traveling at night, use three re...

  • Page 51: Warning

    Jayco towable section 4 - towing & set-up 4-9 electric stabilizer jacks (if so equipped) control switches for the stabilizer jacks are located on the (door) side of the unit above the stabilizer jack(s). To lower each jack, press the control switch until each leg contacts the ground and stabilizes t...

  • Page 52

    Section 4 towing & set-up jayco towable 4-10 electric powered keyless entry system: to prevent unauthorized access to your rv unique authority and access codes must be programmed into the keyless entry keypad. Failure to do so allows access by those with knowledge of the default code settings. Defin...

  • Page 53

    Jayco towable section 4 - towing & set-up 4-11 2. Enter the 5 digit authority code assigned in process “a” above. Once input the keypad will emit a long beep. 3. You can define up to 5 different keypad access codes. The next button pressed and released determines which access code you are programmin...

  • Page 54

    Section 4 towing & set-up jayco towable 4-12 system fault logic: action response ready to accept new code three short beeps new code entered four short beeps wrong code entered one long beep dead bolt locks two short beeps dead bolt unlocks two short beeps dead bolt fails to lock one long beep dead ...

  • Page 55

    Jayco towable section 4 - towing & set-up 4-13 trouble shooting after installation the touch pad does not work batteries are dead batteries are not installed properly plug not engaged properly dead bolt not engaging into door frame obstruction in door frame code not working remove batteries for 10 s...

  • Page 56: Warning

    Section 4 towing & set-up jayco towable 4-14 pncfw f ifth w heel l anding g ear the fifth wheel landing gear can be operated manually. The fifth wheel landing gear must be fully retracted before moving or towing the rv to prevent damage. F ifth w heel h itching p rocedure hooking up a fifth wheel wi...

  • Page 57

    Jayco towable section 4 - towing & set-up pncfw 4-15 f ifth w heel s et u p 1. Pull into the site, and park the rv where you want it. 2. Block the wheels securely to prevent the rv from moving. 3. Drop the landing gear (important!) refer to the operator’s manual for proper operation. 4. Disconnect t...

  • Page 58

    Section 4 towing & set-up jayco towable 4-16 pncfw t his p age i s i ntentionally b lank.

  • Page 59: Warning

    Jayco towable section 5 - slideout system 5-1 the slideout room system is designed for additional floor space and comfort. The mechanical components are gear driven. Electric powered slideout room systems have a manual override to allow you to extend or retract the slideout room(s) in case of a powe...

  • Page 60: Warning

    Section 5 - slideout system jayco towable 5-2 retracting slideout room press the in section of the slideout control switch and hold it until the motor stops. Operating the switch after the room is fully retracted will damage the switch and motor. Maintenance your slideout system has been designed to...

  • Page 61: Caution

    Jayco towable section 5 - slideout system e/pnc/whk 5-3 lippert slideout system (flush floor) for optimum performance, the slide-out system requires full battery current and voltage. Although the system is designed to be almost maintenance free, actuate the room once or twice a month to keep the sea...

  • Page 62: Caution

    Section 5 - slideout system jayco towable 5-4 e/pnc/whk manual operation - in fram fig 5.5 hex head crank extension fig 5.6 ratchet schwintek inwall slideout system the schwintek system comes with an “electronic” manual override. In event the slide out does not extend or retract follow these steps t...

  • Page 63: Warning

    Jayco towable section 6 - electricalsystem 6-1 the rv electrical system is comprised of two independent electrical systems. One operates off of 12-volt dc power and the other off of 120-volt 60hz ac power. All installations have been made in compliance with industry standards applicable on the date ...

  • Page 64: Caution

    Section 6 - electricalsystem jayco towable 6-2 120- volt c ircuit b reakers the 120-volt ac circuit breakers located inside the main load center protect all 120-volt wiring and components in the rv from circuit overloads and short circuits. Should a circuit overload or short circuit occur the circui...

  • Page 65

    Jayco towable section 6 - electricalsystem 6-3 gfci r eceptacle o utlet grounding is your personal protection from electrical shock. Each rv has a ground fault current interrupter (gfci) engineered into the electrical system. This device has been designed to reduce the possible injury caused by elec...

  • Page 66

    Section 6 - electricalsystem jayco towable 6-4 when voltage drops below those levels, permanent damage may occur. Typically, a deep cycle battery has an amp-hour rating of 75-100 amps. If you run the furnace and refrigerator simultaneously, you will be using approximately (12.0 + 3.0) 15.0 amps per ...

  • Page 67: Warning

    Jayco towable section 6 - electricalsystem 6-5 5. Insert a new fuse of the same specified voltage, amperage rating and type in the original location. Never use a higher rated replacement fuse. The fuse panel label should be kept permanently affixed to your rv. The fuses will not offer complete prote...

  • Page 68: Warning

    Section 6 - electricalsystem jayco towable 6-6 50 50 amp s ystem your rv may be equipped with a 50 amp 120-volt 60hz ac electrical system. The entire system is designed to operate on 2 legs of 120-volt power at a maximum current flow of 50 amperes per leg. Exposure to voltages higher or lower than a...

  • Page 69: Warning

    Jayco towable section 6 - electricalsystem 50 6-7 connecting the power cord always test the external power source (i.E., the campsite power receptacle or electrical box) with a ground monitor before connecting your power cord to it. If the ground monitor indicates 'reverse polarity' or an 'open grou...

  • Page 70: Warning

    Section 6 - electricalsystem jayco towable 6-8 50 be mindful of the fact that each operating appliance collectively places an added load on your 120-volt electrical system. An unintentional “trip” of a circuit breaker may occur if you overload the rv’s and/or campgrounds electrical system. The amper...

  • Page 71

    Jayco towable section 6 - electricalsystem 50 6-9 *momentary load 12 volts: labeled watts divided by 12 = power consumed in amps 12 volt system aisle lights 1.0 amp baggage compartment lights 1.4 amps decorative wall lights 1.5 amps dinette light 4.5 amps exterior entertainment center 5-7 amps fanta...

  • Page 72

    Section 6 - electricalsystem jayco towable 6-10 50 t his p age i s i ntentionally b lank.

  • Page 73: Warning

    Jayco towable section 7 - fuelsystems 7-1 p ropane g as s ystem propane or lp(liquefied petroleum) gas is a clean and efficient form of energy when proper handling and safety precautions are observed. The propane system in your rv furnishes the fuel for cooking, heating and hot water. Propane can al...

  • Page 74

    Section 7 – fuelsystems jayco towable 7-2 p ropane s afety p rocedure propane is a colorless and odorless gas that, in the liquefied state, resembles water. An odorant (mercaptan that is described, by many people, as having an odor similar to “rotten eggs”) is added as a warning agent. If you smell ...

  • Page 75: Warning

    Jayco towable section 7 - fuelsystems 7-3 the capacity of asme tanks is expressed in gallons. Asme tanks are filled while the tank is tank is attached to the motor home by a qualified propane facility. Asme tanks are equipped with an automatic stop fill valve designed to reduce the potential of over...

  • Page 76: Warning

    Section 7 – fuelsystems jayco towable 7-4 no one should be inside and only the qualified propane service technician should be near the rv while the propane tank is being filled. The new propane container must be carefully purged for best performance and must never be overfilled. The following label ...

  • Page 77: Warning

    Jayco towable section 7 - fuelsystems 7-5 refer to your warranty packet for more information on the lp gas system components. I nstalling p ropane c ylinder ( s ) single cylinder mounted on a-frame (if so equipped) fig. 7.5 single cylinder 1. Connect the 3/8" low pressure hose to the outlet of the t...

  • Page 78

    Section 7 – fuelsystems jayco towable 7-6 1. Place the second cylinder on the a-frame bracket so the cylinder valve is pointed to the roadside of the folding camping trailer. 2. Secure the second cylinder to the a-frame using the bolts, nuts and washers provided. 3. If a vinyl cylinder cover is used...

  • Page 79: Warning

    Jayco towable section 7 - fuelsystems 7-7 maintenance propane gas is normally non-corrosive - you need not worry about the inside of your container. However, the outside should be kept free from rust by a periodic coat of paint in a light reflective color. Rust, scratches and/or dents can affect the...

  • Page 80: Warning

    Section 7 – fuelsystems jayco towable 7-8 if the pressure is too high, it affects performance and safety; if the pressure is too low, your appliances will not operate correctly. If your rv is equipped with the “automatic” two-stage regulator, with both cylinders full of propane, turn the lever on th...

  • Page 81: Warning

    Jayco towable section 7 - fuelsystems 7-9 make sure that you read and fully understand all safety requirements for handling and operation of the propane system. The warranty packet contains operator’s manuals for the various appliances hooked to your propane system. The propane system provides added...

  • Page 82

    Section 7 – fuelsystems jayco towable 7-10 c alculating p ropane u sage it is important to remember that (if applicable) your furnace, refrigerator, water heater and range all may use propane to operate. Each has a different btu rating, and you will need to consider them to determine how long your p...

  • Page 83: Warning

    Jayco towable section 8 - plumbing systems 8-1 t here are two different water systems in your rv: the fresh water system and the waste water system. The fresh water system consists of the fresh water holding tank, fresh water connections, water pump, outside shower assembly (if so equipped), water h...

  • Page 84: Caution

    Section 8 - plumbing systems jayco towable 8-2 operation press only one “tact” switch at a time. As you push either the “fresh”, “black” or “grey1” switch, one or more led lights will illuminate indicating that holding tank content level. When pushing the “batt” switch, the highest led light illumin...

  • Page 85: Caution

    Jayco towable section 8 - plumbing systems 8-3 3. Turn on the water at the water source. Enter the rv and open the cold water supply faucets to bleed air from the water lines. When the water lines are nearly full, you may experience some "air pockets." allow them to escape before closing the cold wa...

  • Page 86: Warning

    Section 8 - plumbing systems jayco towable 8-4 the water pump will automatically re-start when pressure drops. Some cycling may occur, depending on the volume of water being released. The water pump has a built-in check valve to prevent water from back flowing. Periodically check the in-line water p...

  • Page 87: Warning

    Jayco towable section 8 - plumbing systems 8-5 read the safety and operating information provided in the manufacturer’s manual before attempting to activate the water heater. Make sure the water heater is filled with water before use; even momentary operation of the water heater without water in it ...

  • Page 88: Warning

    Section 8 - plumbing systems jayco towable 8-6 anode rod protection the tank in the water heater is protected by a magnesium or aluminum anode to prolong the life of the tank by absorbing the corrosive action of hot water. Under normal use, the anode rod will deteriorate and because of this, the wat...

  • Page 89: Warning

    Jayco towable section 8 - plumbing systems 8-7 pressure & temperature relief valve when cold water is heated in the water heater tank, the water pressure will rise. For this reason, a pressure and temperature (p&t) relief valve is required for safety in all water heaters. It is normal for the p&t re...

  • Page 90

    Section 8 - plumbing systems jayco towable 8-8 b athroom s hower o r t ub the shower faucet (if so equipped) requires a vacuum breaker when the shower hose and head are used. There are two purposes for this breaker: □ to prevent siphoning water through the hose from another fixture. □ to prevent wat...

  • Page 91

    Jayco towable section 8 - plumbing systems 8-9 each new rv is winterized with rv antifreeze before it is shipped to the dealer. To use the water purification system the clear plastic bypass hose must be removed and the water filter cartridge installed. Replacing the water filter cartridge replace th...

  • Page 92: Warning

    Section 8 - plumbing systems jayco towable 8-10 s anitizing the p lumbing s ystem when to sanitize when your rv is new. At the beginning and end of each season. When the water system becomes contaminated or every three months of use. How to sanitize with a water pump 1. Level the rv and drain the fr...

  • Page 93

    Jayco towable section 8 - plumbing systems 8-11 preparing your rv for colder weather or storage is very important for most states and canada. Failure to prepare your rv may cause water supply lines and the water heater to freeze. No commodity or product should be added to the fresh water system to e...

  • Page 94: Warning

    Section 8 - plumbing systems jayco towable 8-12 the weight of the holding tank contents is not calculated into the rv cargo carrying capacity (this extra weight would reduce your available cargo capacity). Traveling with full holding tank(s) could possibly cause you to exceed the individual tire rat...

  • Page 95

    Jayco towable section 8 - plumbing systems 8-13 a label has been placed near the location of the waste valve that reads as follows: remove waterless trap before using mechanical drain-cleaning devices. Vents another important part of this system is the vent pipes and vents that release air from the ...

  • Page 96: Warning

    Section 8 - plumbing systems jayco towable 8-14 t oilet the toilet is efficient and easy to operate. Generally, more water is required only when flushing solids. Prior to using the sanitation system, it is strongly recommended to flush the toilet several times to release sufficient water into the ho...

  • Page 97: Warning

    Jayco towable section 9 – heating & cooling 9-1 d ucting & r eturn a ir all heat discharges, registers and return air grills must be free and clear of obstructions. This includes all closeable registers that are intended to reduce airflow, not shut it off completely. A ttic f an the 12-volt dc attic...

  • Page 98: Warning

    Section 9 – heating & cooling jayco towable 9-2 the furnace installed in your rv is controlled by a thermostat. The furnace requires both 12-volt power and propane gas for full operation. Make sure you have sufficient power available before operating your furnace. If you have any questions contact y...

  • Page 99: Warning

    Jayco towable section 10 – appliances 10-1 r efrigerator the refrigerator is not intended for quick freezing or cooling. We recommend stocking it with pre-frozen or pre-cooled food when possible. The shelves should not be covered with paper or plastic and the food items should be arranged so air can...

  • Page 100: Warning

    Section 10 – appliances jayco towable 10-2 oven (if so equipped) the propane gas oven must have 12-volt power to operate. If you have any questions contact your dealer or our customer service department. Do not use the oven as a storage area. For additional information refer to the manufacturer’s ow...

  • Page 101: Warning

    Jayco towable section 10 – appliances 10-3 warning do not pick up flammable or combustible liquids such as gasoline, or use in areas where they may be present. Rv damage, personal injury, or death may result from vacuuming up flammable or combustible material. Warning do not pick up anything that is...

  • Page 102

    Section 10 – appliances jayco towable 10-4 t his p age i s i ntentionally b lank.

  • Page 103: Caution

    Jayco towable section 11 – electronics 11-1 t elevision p ower s upply for good station reception, the tv power supply must be turned on to view local television stations. Turning the tv power supply on sends 12-volt dc through the cable to the tv roof antenna. The voltage energizes the transistors ...

  • Page 104: Caution

    Section 11 – electronics jayco towable 11-2 lowering the antenna rotate the antenna until the pointer on the directional handle aligns with the pointer on the ceiling plate. Turn the elevating crank counterclockwise in the down direction until resistance is noted. The antenna is now locked in the tr...

  • Page 105

    Jayco towable section 12 - interior 12-1 c leaning t he i nterior to keep the value of your rv, perform regular maintenance using the proper materials and procedures. Using the wrong cleaner may result in damage to the surfaces in your rv. Check with the manufacturer’s information for the recommende...

  • Page 106

    Section 12 - interior jayco towable 12-2 c abinetry & t ables to keep hardwood doors, cabinet fronts and hardwood tables looking like new regularly dust with a soft cloth dampened with a cleaning polish or mild detergent solution. Avoid using ammonia based products or silicone oils as they may cause...

  • Page 107

    Jayco towable section 12 - interior 12-3 have tough and deep stains professionally steam cleaned. Use spot removers for minor spills. Always test the carpet for color fastness in an inconspicuous area before using any product. Vinyl flooring (if so equipped) periodically vacuum or sweep to remove di...

  • Page 108

    Section 12 - interior jayco towable 12-4 j-s teel s ofa (i f s o e quipped ) the j-steel sofa functions much the same as a residential futon. To make the j- steel sofa in to a bed, lift up on the bottom seat cushion and pull it towards you. The sofa back will drop down to provide a sleeping surface....

  • Page 109

    Jayco towable section 12 - interior pncfw 12-5 r ecliner c hair (i f s o e quipped ) like a residential recliner, the recliner has side controls allowing you to recline the chair. To revert the recliner chair back to the upright position, depress the side control and gently apply pressure to the rec...

  • Page 110

    Section 12 - interior jayco towable 12-6 pncfw t his p age i s i ntentionally b lank.

  • Page 111: Warning

    Jayco towable section 13 - exterior 13-1 bbq g rill (i f s o e quipped ) the bbq grill is for use outside of the rv. Never use this grill inside a compartment or the rv. Before operating the bbq grill, make sure that it is securely placed on the support bracket. The bbq grill must be completely cool...

  • Page 112

    Section 13 - exterior jayco towable 13-2 fig. 13.1 quick connect coupler c leaning t he e xterior to protect your rv's exterior finish, wash it often and thoroughly. Regular cleaning and waxing will help protect the exterior. If chalking occurs, wash and try to wax a small area to see if the luster ...

  • Page 113

    Jayco towable section 13 - exterior 13-3 washing chemicals contained in dirt and dust picked up from the road surface can cause damage if left on the rv for a long time. Frequent washing and waxing is the best way to protect your rv from this damage. Frequent washings also protect your rv from envir...

  • Page 114: Caution

    Section 13 - exterior jayco towable 13-4 polishing your rv if painted surfaces have been severely damaged and have lost their original luster and color tone, polish the surface lightly with a fine polishing compound. Avoid limiting your polishing to the damaged surface only; polish a somewhat wider ...

  • Page 115: Caution

    Jayco towable section 13 - exterior 13-5 e xterior r oof & s idewall v ents while you are cleaning the exterior roof, also inspect the roof vents (including sealants) for cracks and keep them clean. Inspect the refrigerator and holding tank vents for blockages from bird nests, spider webs, leaves, e...

  • Page 116: Caution

    Section 13 - exterior jayco towable 13-6 s ealants sealants perform a very important function and should be inspected closely and regularly maintained. We incorporate many different types of sealants, including butyl/putty, black butyl-encapsulated foam, silicone (clear and colored), roof sealant an...

  • Page 117: Caution

    Jayco towable section 13 - exterior pncfw 13-7 fifth wheels w indows any ventilating window may permit water inside, especially during heavy rainstorms. Condensation will also cause water to accumulate on windows and in the tracks. The window “glass” can normally be cleaned with a sponge and water. ...

  • Page 118: Caution

    Section 13 - exterior jayco towable 13-8 pncfw b ike r ack /c argo t ray (i f s o e quipped ) if your rv was ordered with the optional bike rack, do not use the rear bike rack hitch for any other purpose (doing so will void the towable limited warranty). The optional rear bike rack hitch is not desi...

  • Page 119

    Jayco towable section 14 - travel/camping/storage checklists 14-1 rv s tart -u p the following checklist will help ensure a trouble-free camping season: inspect and work all interior and exterior latches and locks (lube if necessary). Make sure the batteries are fully charged and installed correctly...

  • Page 120

    Section 14 - travel/camping/storage checklists jayco towable 14-2 interior close roof vents. Close windows & latch blinds. Counter items put away or tied down. Furnace turned off. Latch drawers, cabinets & doors. Turn off the interior lights and appliances. Disconnect any cable tv or phone hookups a...

  • Page 121

    Jayco towable section 14 - travel/camping/storage checklists 14-3 when storing your rv, it is recommended that the auxiliary battery (customer supplied) be disconnected to avoid battery discharge. Prior to storage if storing for the winter, be sure the rv is winterized (refer to sec. 8 plumbing syst...

  • Page 122: Caution

    Section 14 - travel/camping/storage checklists jayco towable 14-4 m aintenance c hecklist this list is a quick reference sheet for suggested areas of regular maintenance. Review all manufacturer’s operators manuals supplied with your rv to perform these listed maintenance items. Prior to first trip ...

  • Page 123

    Jayco towable section 15 - additional information 15-1 f eatured c omponents q uick r eference c hart your rv may be equipped with some of the items listed below. This is a partial listing and it is not intended to cover all components in your rv. All information is the latest available at the time ...

  • Page 124

    Section 15 - additional information jayco towable 15-2.