1. DL manuals
  2. Jayco
  3. Motorhomes
  4. Eagle Eagle Super Lite
  5. Owner's Manual

Jayco Eagle Eagle Super Lite Owner's Manual

Summary of Eagle Eagle Super Lite

  • Page 1

    Www.Jayco.Com travel trailer and fifth wheel owner’s manual model year 2009.

  • Page 2

    Warning: read all instructions in this manual and component i manufacturer supplied information before using your rv. This manual has been provided by jayco, inc. For the sole purpose of providing instructions concerning the operation and maintenance of this vehicle and its components. Nothing in th...

  • Page 3

    Table of contents i w arranty & s ervice a bout t his m anual .................................1 c hange of a ddress /o wnership f orm ..5 c ustomer r elations ..............................3 c ustomer r esponsibility ......................2 d ealer r esponsibility ...........................2 j ayc...

  • Page 4

    Table of contents ii p lumbing s ystem , c ont . T he f resh w ater s ystem ....................41 t oilet ....................................................50 w ater h eater ......................................43 w ater p ressure r egulator (c ustomer s upplied ) ........................43 w at...

  • Page 5

    Section 1 warranty & service 1 c ongratulations! Thank you for selecting a jayco rv. We are excited to welcome you to our growing rv family. Jayco is the largest privately held manufacturer of recreation vehicles in the world. We are committed to being the most respected name in rvs. We invite you t...

  • Page 6

    Section 1 warranty & service 2 or jayco. For additional information, please refer to the nhtsa website at www.Safercar.Gov. To contact nhtsa by phone: call the department of transportation (dot) vehicle safety hotline at 1-888- 327-4236 and a nhtsa representative will record your complaint informati...

  • Page 7

    Section 1 warranty & service 3 □ request that you read all warranty information and explain any provision not clearly understood. □ ensure you receive the goodie bag. Your dealer can assist you in completing the oem warranty cards or registrations, and locate any required component model or serial n...

  • Page 8

    Section 1 warranty & service 4 please provide the following information: □ your name, location and phone number. □ your rv 17-digit vehicle identification number (vin). □ your date of purchase. □ the name of your selling dealer. O if different from above, the contact information for the rv repair fa...

  • Page 9

    Section 1 warranty & service 5.

  • Page 10

    Section 1 warranty & service 6 j ayco c ustomer f irst e mergency r oadside a ssistance jayco has teamed up with coach-net to offer 24/7 motorist assistance. We are offering this free of charge for the first year of ownership (certain restrictions apply*). You may continue your emergency roadside as...

  • Page 11

    Section 1 warranty & service 7 o btaining s ervice f or s eparately w arranted i tems your selling dealer is responsible for servicing your rv before delivery, and has an interest in your continued satisfaction. We recommend your dealer perform all inspection, warranty and maintenance services. Some...

  • Page 12

    Section 1 warranty & service 8.

  • Page 13

    Section 1 warranty & service 9.

  • Page 14

    Section 1 warranty & service 10

  • Page 15

    Section 2 occupant safety 11 c amping is a great way to enjoy the outdoors with your family and friends. By following the proper precautions and planning, you can help insure a safe, enjoyable and trouble-free trip. We encourage you to develop a family safety plan in case of an emergency or severe w...

  • Page 16

    Section 2 occupant safety 12 be aware of the heat index if camping during hot weather. Keep yourself hydrated, and try to stay indoors in an air-conditioned area during a high heat index warning. E mergency e gress w indow the emergency egress window is designed to allow quick exit from the rv durin...

  • Page 17

    Section 2 occupant safety 13 rating intended use type a for use on fires involving combustible materials such as wood, cloth and paper. Type b for use on flammable liquid fires, including kitchen grease. Never use water on this type of fire! Type c for use in fires involving energized electrical equ...

  • Page 18

    Section 2 occupant safety 14 the smoke alarm and your rv. If the smoke alarm does not test properly, replace it immediately. Battery the smoke alarm will not function if the battery is missing, disconnected, dead, the wrong type of battery is used or the battery is installed incorrectly. When the ba...

  • Page 19

    Section 2 occupant safety 15 appliance technician to investigate for sources of carbon monoxide from fuel burning equipment and appliances, and inspect for proper operation of this equipment (if problems are identified during this inspection, have the co alarm replaced immediately). Note any combust...

  • Page 20

    Section 2 occupant safety 16 if the alarm sounds 1. Turn off all propane gas appliances (i.E., stove, water heater, furnace, etc.). 2. Open all windows and roof vents and execute your family safety plan. 3. Turn off the propane tank valve. 4. Do not touch any electrical switch or use any phone or ra...

  • Page 21

    Section 3 pre-travel information 17 t o help ensure your traveling enjoyment, call ahead for tourist information in each area that you will be visiting or traveling through. To help eliminate frustration, make sure you obtain the most current road maps. Research and make sure there are no federal, s...

  • Page 22

    Section 3 pre-travel information 18 w eight labels vehicle weight labels are posted on jayco manufactured rvs so you can make an informed decision before your purchase. Do not remove these labels from your rv. If the labels are missing, contact your dealer or jayco customer service for replacements....

  • Page 23

    Section 3 pre-travel information 19 weight carrying capacity (also known as the tongue weight on a travel trailer). Before selecting a hitch, you must know your gvwr and tongue weight or pin box rating. Maintain the proper tongue weight of the trailer. Stay within the target range of 10%- 15% of the...

  • Page 24

    Section 3 pre-travel information 20 w eight d istributing s ystem (c ustomer s upplied ) a weight distributing hitch system provides a more stable tow vehicle/rv combination. This system will spread the weight evenly to distribute it to the tow vehicle front and rear axles and the trailer axle. Cons...

  • Page 25

    Section 3 pre-travel information 21 w eighing y our t ow v ehicle & rv now that your rv is loaded you should have it weighed. The actual weight of the rv, passengers, all options, liquids, the hitch weight of your towed vehicle and your personal cargo is important for you to know so you do not excee...

  • Page 26

    Section 3 pre-travel information 22 the other side, components (tires, wheels, brakes, springs, etc.) on the heavier side could be overloaded, even though the total axle load is within the gawr. It is important to redistribute the load to avoid component failure, improve the handling characteristics...

  • Page 27

    Section 3 pre-travel information 23 the baggage compartments are closed and locked. Pull forward, clean the site (if applicable) and check for forgotten items. Secure and lock the entrance door. Pre-travel checklist in order to enjoy your travel, having all the right tools and supplies will help. A ...

  • Page 28

    Section 3 pre-travel information 24 rv _ check lights _ brake lights _ clearance lights _ turn signals _ check tire pressure (including spare tire) _ check tire wear (uneven wear pattern) _ check wheel lug torque _ proper tongue weight maintained (10-15% of gross weight – travel trailer and contents...

  • Page 29

    Section 4 towing & handling 25 d riving safety and protection against injury cannot be fully ensured. However, we recommend you pay special attention to the following: the use of daytime running lights can increase other motorists' awareness of the rv to all traffic. Keep the tires inflated to the s...

  • Page 30

    Section 4 towing & handling 26 rv d riving s chools & s eminars if you have any concerns about driving while towing a rv, consult an expert for specific rv driver education. There are private rv schools and some rv owner's organizations that offer driving seminars. The schedules and locations of the...

  • Page 31

    Section 4 towing & handling 27 w ire h arness /c onnector p lug a 7-way wire harness/connector plug is wired into your trailer to connect electrical power from the tow vehicle for travel. This supplies power to the rv brakes, tail lights, clearance lights, turn signals, brake lights, etc. Wiring to ...

  • Page 32

    Section 4 towing & handling 28 10. Walk around the rv to verify exterior lights are working correctly. 11. Attach the safety chains. 12. Plug in your wire harness/connector plug from the tow vehicle to the travel trailer. 13. Remove the trailer wheel blocks. If an atwood brake actuator is used with ...

  • Page 33

    Section 4 towing & handling 29 starting smoothly saves wear and tear on your tow vehicle/rv combination. Drive defensively, try to anticipate problems that may occur and prepare for them (even if they may never happen). Be aware of road surface conditions. Slow down well in advance of dips and bumps...

  • Page 34

    Section 4 towing & handling 30 truck stop or parking lot chose a well-lighted area. E mergency s topping always carry road flares or reflective warning signs to display if necessary. Pull off the roadway as far as possible for emergency stopping or tire changing. Turn on your rv hazard warning flash...

  • Page 35

    Section 5 rv tires 31 read and understand the following before taking your first trip in your rv! Proper care and maintenance of your tires is essential to ensure your safety, as well as the safety of others, as you travel. Taking time to become educated on the special qualities of rv tires and care...

  • Page 36

    Section 5 rv tires 32 2. Remove the pin and extend the tire carrier away from the trailer. 3. Always return the tire carrier to the upright position and lock it in place while traveling. To remove the tire from the tire carrier 1. Remove the lug nuts holding the tire in place. 2. Remove the support ...

  • Page 37

    Section 5 rv tires 33 1. Start all nuts by hand to prevent cross threading. 2. Tighten the nuts in the sequence shown. 3. Tighten the lug nuts equally in stages as indicated for your trailer's wheels (see wheel lug torque chart). Check and re-torque after the first 10, 25 and 50 miles (16, 40 and 80...

  • Page 38

    Section 5 rv tires 34 t his p age i s i ntentionally b lank.

  • Page 39

    Section 6 electrical system - 30 amp 35 y our rvcontains separate low voltage (12- volt dc) and high voltage (120-volt ac) electrical systems. All installations have been made in compliance with the safety requirements of ansi standard a.1192, national electric code and canadian standards associatio...

  • Page 40

    Section 6 electrical system – 30 amp 36 120- volt c ircuit b reakers the circuit breaker panel protects the 120-volt electrical system from overloads, shorts in the wiring and shorts in the connected components. When an overload or short occurs, the circuit breaker will open (or “trip”) preventing a...

  • Page 41

    Section 6 electrical system - 30 amp 37 when you are ready to leave, reverse the power cord connection process. Use care to prevent damaging the power cord electrical connection pins when connecting or disconnecting the shore line power cord. Grasp the plug to remove from the outlet; do not unplug b...

  • Page 42

    Section 6 electrical system – 30 amp 38 test all gfci receptacles monthly the 120-volt ac electrical system must be on in order to test the gfci. 1. Plug a 120-volt acelectrical device into the gfci receptacle outlet. 2. Push and release the reset button (the 120-voltac electrical device should oper...

  • Page 43

    Section 6 electrical system - 30 amp 39 furnace and refrigerator simultaneously, you will be using approximately (12.0 + 3.0) 15.0 amps per hour. This does not include any 12- volt lights, water pump or any other 12-volt component. If the furnace and refrigerator in the above example operated consta...

  • Page 44

    Section 6 electrical system – 30 amp 40 12- volt dc o utlet (i f s o e quipped ) there may be a 12-volt dc outlet (not applicable on all models) in your rv. When the 12-volt dc outlet socket is used as a power source for an electric appliance, make sure that the electric appliance operates at 12-vol...

  • Page 45

    Section 7 plumbing systems 41 t here are two different water systems in your rv: the fresh water system and the waste water system. The fresh water system consists of the fresh water holding tank, fresh water connections, water pump, outside shower assembly (if so equipped), water heater, faucets, s...

  • Page 46

    Section 7 plumbing systems 42 f resh w ater h olding t ank the fresh water tank can be filled by pressure filling through the fresh water inlet (called city water) or by gravity fill. There are plastic overflow tubes plumbed into the fresh water holding tank. They allow water to flow out of the wate...

  • Page 47

    Section 7 plumbing systems 43 end into the gravity fill. Turn on the clean (potable) water and when the fresh water tank is full, shut off the water pump and remove the non-toxic drinking water hose. W ater p ressure r egulator (c ustomer s upplied ) excessive pressure from water supply systems may ...

  • Page 48

    Section 7 plumbing systems 44 hot water system. If hydrogen is present, you probably will hear an unusual sound such as air escaping through the pipe as the water begins to flow. Hydrogen gas may be present even after water has been drained from the tank. Open the sink faucet at the sink and allow s...

  • Page 49

    Section 7 plumbing systems 45 for normal camping usage of the water heater, reverse these instructions. Water heater switch (optional) the "propane gas" water heater switch enables propane operation of the water heater. The "electric" water heater switch enables electric operation of the water heate...

  • Page 50

    Section 7 plumbing systems 46 1. Be sure the water heater is on and had sufficient time to heat the water. 2. If dry camping, be sure your 12-volt water pump is on. 3. Adjust the hot and cold faucets to the desired temperature before bathing. 4. To conserve water while showering, wet down and turn t...

  • Page 51

    Section 7 plumbing systems 47 at the lowest point of water lines. A label is placed on the outside of the travel trailer to indicate where the drains are located. The drains will typically need to be opened from inside the trailer. Once the label is found on the outside of the trailer, go inside to ...

  • Page 52

    Section 7 plumbing systems 48 2. Then, drain the fresh water system (see draining the fresh water system). If a chlorine taste lingers in the water, flush the water system with a solution consisting of one-quart vinegar to five gallons of clean water. Re-flush as necessary. W interizing t he p lumbi...

  • Page 53

    Section 7 plumbing systems 49 will flow into the sewage (or black water) holding tank. Drain pipes the drain pipes have a “p-trap” installed to help prevent odors from escaping into the rv. During travel, water from the p-traps may spill and permit odors into the rv. These odors come from food parti...

  • Page 54

    Section 7 plumbing systems 50 fig. 7.8 black & grey tank dump valves 1. To make drainage easier, level the rv. 2. Remove the sewer hose housing dust cap, and attach the sewer hose (customer supplied). 3. Place the end of the sewer hose into the approved dump station. 4. Open the black tank dump valv...

  • Page 55

    Section 7 plumbing systems 51 system, it is strongly recommended to flush the toilet several times to release sufficient water into the holding tank. If there is not a sufficient amount of water used during flushing, the waste materials may not evacuate properly from the drain line to the tank. Clog...

  • Page 56

    Section 7 plumbing systems 52 t his p age i s i ntentionally b lank.

  • Page 57

    Section 8 propane system 53 lp (liquefied petroleum) gas is a clean and efficient form of energy when proper handling and safety precautions are observed. It enables you to enjoy a comfortable lifestyle when other forms of energy are not easily accessible. Lp-gas includes propane, butane and/or a mi...

  • Page 58

    Section 8 propane system 54 h ow t o l eak t est the p ropane s ystem use an appropriate propane leak detector solution or create a soapy water solution. The propane leak detector solution can be purchased at most dealerships (if soapy water is used, make sure that the soap used does not contain amm...

  • Page 59

    Section 8 propane system 55 the following label should be kept permanently affixed to your rv. Fig. 8.3 “use propane only” label servicing or filling have the rv checked for leaks at the connections on the propane system soon after the purchase and the initial filling of each propane cylinder. When ...

  • Page 60

    Section 8 propane system 56 i nstalling p ropane c ylinder ( s ) located on the a-frame or front trunk the containers must be positioned in the tray with the valves pointing away from the trailer. The wing nut is placed on the threaded rod to hold the cross bar down and orient the containers. The re...

  • Page 61

    Section 8 propane system 57 2. Check that all connections are tested with a propane leak detector (or soapy water) solution. 3. Open the main valve slowly to avoid a fast rush of propane to the excess flow valve causing propane freeze up. If you experience a propane “freeze-up,” close the main valve...

  • Page 62

    Section 8 propane system 58 low operating pressure. The first stage reduces the container pressure to 10-13 lbs. The second stage reduces the 10-13 lbs. Of pressure further to an operating pressure of 11” w.C. (water column) or 6.35 oz. Of outlet pressure to your appliances. The second stage is adju...

  • Page 63

    Section 8 propane system 59 benefits to your camping enjoyment; however, it must be handled with care. If you have any questions or concerns, consult with your dealer and/or the specific oem. If you have double cylinders on your rv, use only one at a time. Otherwise, the propane supply will be drawn...

  • Page 64

    Section 8 propane system 60 t his p age i s i ntentionally b lank.

  • Page 65

    Section 9 slideout systems 61 the slideout room system is designed for additional floor space and comfort. The mechanical components are gear driven. Electric powered slideout room systems have a manual override to allow you to extend or retract the slideout room(s) in case of a power loss. Make sur...

  • Page 66

    Section 9 slideout systems 62 corners of the black rubber seal are set up correctly. The corners of this seal are cut at a 45° angle. The top of the seal must overlap the side of the seal to avoid the possibility of water penetration. Retracting slideout room press the in section of the slideout con...

  • Page 67

    Section 10 camping & operating 63 b y purchasing your rv you have entered into a lifestyle that encourages long-lasting friendships. People who camp next to one another for a few days are allowed the unique opportunity to cultivate new acquaintances and neighbors. Camping is a great way to relax and...

  • Page 68

    Section 10 camping & operating 64 c ondensation condensation is a natural phenomenon. The amount of condensation will vary with climate conditions, particularly the relative humidity. Condensation occurs because there is water vapor present in the air, which each of us adds to by breathing, bathing ...

  • Page 69

    Section 10 camping & operating 65 6. Gently put your truck into reverse (don’t give it any fuel/acceleration). This effectively moves the kingpin off the locking bar that will allow you to disengage it. 7. Step on brake and apply parking brake. 8. Disengage the locking bar and unhitch. 9. Drive away...

  • Page 70

    Section 10 camping & operating 66 dinette chairs should be fastened securely at the dinette table when you are traveling b ooth d inette (i f s o e quipped ) the dinette is designed to seat up to four adults. You can access the dinette bench storage by removing all the cushions and lifting the botto...

  • Page 71

    Section 10 camping & operating 67 on the round knob with both hands until it disengages from the ceiling plate. Rotate the knob for best picture. Lowering the antenna rotate the antenna until the pointer on the directional handle aligns with the pointer on the ceiling plate. Turn the elevating crank...

  • Page 72

    Section 10 camping & operating 68 k itchen s tove , r ange or o ven (i f s o e quipped ) to prevent damage, always use the oem recommended size flat bottom pan(s). Generally, the pan should be large enough to cover the burner, but not be more than one inch larger than the burner grate. Do not use a ...

  • Page 73

    Section 10 camping & operating 69 remember your rv’s load capacity is designed by weight, not volume, so you cannot necessarily use all available space. Bbq g rill (i f s o e quipped ) the bbq grill is for use outside of the rv. Never use this grill inside a compartment or the rv. Before operating t...

  • Page 74

    Section 10 camping & operating 70 t hermostat there are may be up to two 12-volt dc thermostats in your rv. Use the controls to set the temperature to your comfort setting. A ir c onditioner (i f s o e quipped ) your rv has a roof mounted air conditioning system that is controlled by a thermostat. C...

  • Page 75

    Section 10 camping & operating 71 location away from the safe. If you have questions, consult with your rv dealer. D eparting c amp c hecklist when the time arrives to return home, it is again critical that you complete the necessary procedures to ensure a safe trip. As you develop a routine, it is ...

  • Page 76

    Section 10 camping & operating 72 t his p age i s i ntentionally b lank.

  • Page 77

    Section 11 storage & maintenance 73 d epending upon your area and where your rv is stored, your vehicle may be a target for damage from rodents and insects. To protect your rv, never leave food inside and ensure that all surfaces are clean. Place rodent control products in the unit during periods of...

  • Page 78

    Section 11 storage & maintenance 74 f urniture u pholstery to retain the value of your rv, maintain the furniture upholstery carefully and keep the interior clean. Vacuum the furniture regularly using a soft brush attachment to remove any loose dirt or debris. Fabric (if so equipped) it is recommend...

  • Page 79

    Section 11 storage & maintenance 75 cause the vinyl to scratch and turn dull. Grease spots and stubborn dirt can be cleaned off with an all-purpose spray cleaner. Harsh cleaners and organic solvents can attack the printed vinyl; they are not recommended. C abinetry & t ables to keep hardwood doors, ...

  • Page 80

    Section 11 storage & maintenance 76 hot, the vapor will condense on the reflector and it will dim the surface. Replace a bulb only with a new bulb of the same rating and type. C leaning t he e xterior to protect your rv's exterior finish, wash it often and thoroughly. The exterior can be affected by...

  • Page 81

    Section 11 storage & maintenance 77 waxing your rv wax your rv once or twice a year, or when painted surfaces do not shed water well. Use a soft cloth to apply a small amount of wax to the painted surfaces. After the wax has dried, polish the rv with a dry, soft cloth. Do not wax your rv in direct s...

  • Page 82

    Section 11 storage & maintenance 78 refrigerator exterior doors need to be kept clean and free of obstructions (i.E., insect nests, mud daubers, etc.) while the appliances (if so equipped) are in use. W indows any ventilating window may permit water inside, especially during heavy rainstorms. Conden...

  • Page 83

    Section 11 storage & maintenance 79 r ear b umper the rear bumper of your rv is not designed to carry cargo. Items that extend beyond the bumper or weigh over 100 lbs. (45kg) will place undo strain on the bumper. The 100 lb. Bumper capacity includes the weight of the spare tire that may have been at...

  • Page 84

    Section 11 storage & maintenance 80 s ealants water is a rv’s worst enemy when it enters where it is not intended. Sealants perform a very important function; they must be inspected closely and be regularly maintained. We incorporate many different types of sealants, including butyl/putty, black but...

  • Page 85

    Section 11 storage & maintenance 81 always use the same type of sealant originally used to build your rv. Consult your dealer for assistance with the proper sealant(s) to use on the specific area(s) of your rv. If you notice water inside the rv, immediately have the dealer check for the source of th...

  • Page 86

    Section 11 storage & maintenance 82 m aintenance c hecklist this list is a quick reference sheet for suggested areas of regular maintenance. Review all oem operator’s manuals supplied with your rv to perform these listed maintenance items. Prior to first trip _ check propane lines for leaks. _ check...

  • Page 87

    Section 11 storage & maintenance 83 every six months or 6,000 miles _ check pipe connections for tightness. Tighten if necessary. Lubricate all moving parts on the entrance steps. _ clean and lubricate stabilizer jacks. _ clean drains with approved drain cleaners. _ _ have suspension system serviced...

  • Page 88

    Section 11 storage & maintenance 84 t his p age i s i ntentionally b lank.

  • Page 89

    Section 12 specifications & glossary 85 oem l ist the following chart provides information to contact some of the individual original equipment manufacturers (oem) of appliances/component parts that may be installed on your rv. The information listed in this chart is the latest available at the time...

  • Page 90

    Section 12 specifications & glossary 86 oem w heel l ug t orque c hart wheel lug nut diagrams: wheel torque instructions: * all torque wrenches mentioned below must have settings visible for auditing purposes. 1. Start lug nuts with fingers on studs to avoid cross threading. 2. Stage 1, torque: impa...

  • Page 91

    Section 12 specifications & glossary 87 dc f use p anel l ayout below is a typical wiring layout. Your individual trailer may be different. # size function 1 12.5 amp breaker bedroom slideout motor 2 15 amp fuse bathroom lights & vent 3 15 amp fuse monitor panel/holding tanks/water pump/water heater...

  • Page 92

    Section 12 specifications & glossary 88 a pproximate e lectrical l oad r atings air conditioner - coleman mach 13,500 btu (run) 13.50-16.25 amps air conditioner - coleman mach 13,500 btu (start up) 15.75-16.25 amps* air conditioner - coleman mach 15,000 btu (run) 17.00-20.50 amps air conditioner - c...

  • Page 93

    Section 12 specifications & glossary 89 g lossary o f t erms ac electricity – alternating current also known as shoreline power. For purposes of this manual, it refers to 120-volt ac (abbreviated 120 vac). Auxiliary battery – for purposes of this manual, the term refers to the 12-volt dc group 27 de...

  • Page 94

    Section 12 specifications & glossary 90 gray water – term associated with the waste water holding tank. Water from the sink drains, shower and washer/dryer (if so equipped) go into this tank. Gross axle weight rating (gawr) – the maximum allowable weight each axle assembly is designed to carry, as m...

  • Page 95

    Section 12 specifications & glossary 91 sleeping capacity weight rating (scwr) –the manufacturer’s designated number of sleeping positions multiplied by 154 pounds (70 kilograms). Tire ratings - the maximum load that a tire may carry is engraved on the sidewall, along with a corresponding cold infla...

  • Page 96

    Section 12 specifications & glossary 92 t his p age is i ntentionally b lank.