1. DL manuals
  2. Jayco
  3. Motorhomes
  4. JAY SPORT 2018
  5. Owner's Manual

Jayco JAY SPORT 2018 Owner's Manual

Manual is about: CAMPING TRAILERS

Summary of JAY SPORT 2018

  • Page 1

    Owner’s manual printed on recycled paper 0181064.2018 2018 camping trailers.

  • Page 3: Recycled

    2018 jayco camping trailers reva the jayco ecoadvantage is our company’s commitment to protecting the environment. Through jayco’s company-wide sustainability program, we’re creating better ways to build better rv’s using fewer natural resources. Already, our initiative has created significant impac...

  • Page 5: Table of Contents

    Table of contents section 1: warranty & service about this manual 5 warranty packet 6 safety alerts 6 reporting safety defects 7 customer responsibility 7 change of address/ownership 8 suggestions for obtaining service 8 obtaining service for separately warranted items 9 obtaining service at our cus...

  • Page 6: Table of Contents

    Table of contents spare tire carrier (if so equipped) 48 bracket mount travel position 48 hoist mount travel position 48 crank access port 48 setting up your recreation vehicle 49 bumper mount 49 caring for the tent 50 tent set up and tear down 52 canopy (if so equipped) 62 screen room 66 lifter sys...

  • Page 7: Table of Contents

    Table of contents potable water label 98 sanitizing/winterizing the plumbing system 98 gravity water fill 98 water heater drain plug location 102 water heater 103 anode rod replacement chart 104 outside shower (if so equipped) 106 faucets 107 bathroom tub / shower 107 toilet (if so equipped) 108 gre...

  • Page 8

    H table of contents maintenance record.

  • Page 9

    Section 1: warranty & service 1 warning: read all instructions in this manual and component manufacturer supplied information before using your rv. This manual has been provided by your recreational vehicle manufacturer for the sole purpose of providing instructions concerning the operation and main...

  • Page 10

    Section 1: warranty & service 2 table of contents maintenance record.

  • Page 11

    Section 1: warranty & service 3 congratulations! Thank you for selecting a jayco recreation vehicle. We are excited to welcome you to our growing rv family. We are committed to being the most respected name in rvs. We invite you to drop by our visitors center located in middlebury, indiana. To book ...

  • Page 12

    Section 1: warranty & service 4 customer name and current location. Phone number where you can be reached. 17-digit chassis vehicle identification number (vin) or 9-digit serial the current vehicle mileage (motor homes) your date of purchase. If applicable, the component description, serial number a...

  • Page 13: About This Manual

    Section 1: warranty & service 5 if your dealer is closed, check with the campground staff or telephone yellow pages for an rv repair facility. Have the item repaired and contact jayco customer service immediately the following business day. Failure to contact jayco customer service, unauthorized or ...

  • Page 14: Warranty Packet

    Section 1: warranty & service 6 warranty packet there are components that are excluded from the vehicle warranty, or are warranted separately by their own individual manufacturer’s limited warranty. The warranty packet contains these component manufacturer supplied manuals or information sheets, war...

  • Page 15: Reporting Safety Defects

    Section 1: warranty & service 7 reporting safety defects in the united states: if you believe that your recreation vehicle has an alleged defect which could cause a crash or cause injury or death, you should immediately inform the national highway traffic safety administration (nhtsa), in addition t...

  • Page 16: Change of Address/ownership

    Section 1: warranty & service 8 as technology advances, new improvements enter the rv industry every day, and each rv manufacturer has its own unique manufacturing process. Familiarize yourself with the limited warranty applicable to your recreation vehicle. There are components that are excluded or...

  • Page 17: Items

    Section 1: warranty & service 9 obtaining service for separately warranted items your selling dealer is responsible for servicing your recreational vehicle before delivery, and has an interest in your continued satisfaction. We recommend your dealer perform all inspection, warranty and maintenance s...

  • Page 18: Extended Limited Warranty

    Section 1: warranty & service 10 extended limited warranty camping trailers lifter system, frame, floor, roof, tent what and who is covered the jayco warranty provides extended limited warranties on the lifter system, frame, floor, roof, and tent of camping trailers as outlined below. Jayco warrants...

  • Page 19

    Section 1: warranty & service 11 functional defects in material or workmanship for a period of five (5) years. The warranty period shall begin on the date the vehicle is sold to the first retail purchaser only, or, if the dealer places the vehicle in service prior to retail sale, on the date the cam...

  • Page 20

    Section 1: warranty & service 12 to either an independent, authorized jayco dealer or jayco. Notice should contain the name and mailing address, proof of date of purchase, model, year and serial number of the unit, name and address of the selling dealer and a description of the defect. All costs inc...

  • Page 21: Towable Limited Warranty

    Section 1: warranty & service 13 towable limited warranty what and who is covered the jayco warranty covers this recreational vehicle (“rv”), when used only for its intended purpose of recreational travel and camping, for two (2) years. It covers rv’s that are sold in, and remain in, the united stat...

  • Page 22

    Section 1: warranty & service 14 survive any determination that this limited warranty or any implied warranty has failed of its essential purpose. Some states do not allow limitations on how long an implied warranty lasts, or the exclusion or limitation of incidental or consequential damages, so the...

  • Page 23

    Section 1: warranty & service 15 the structural components; normal wear, tear or usage, such as tears, punctures, soiling, mildew, fading, or discoloration of exterior plastic or fiberglass, or soft goods, such as upholstery, drapes, carpet, vinyl, screens, cushions, mattresses and fabrics; the effe...

  • Page 24

    Section 1: warranty & service 16 wholesale or by a non-authorized dealer, any defect in a separately manufactured component part, owner neglect or failure to provide routine maintenance (see owner’s manual), unauthorized alteration, off road use, collision or accident, whether or not foreseeable, in...

  • Page 25: Notice to Jayco Dealers

    Section 1: warranty & service 17 notice to jayco dealers this owner’s manual contains the towable limited warranty that applies to this rv. However, if the jayco dealer decides to use this rv for rental purposes, then the towable limited warranty will not apply to this rv. The towable limited rental...

  • Page 26

    Section 1: warranty & service 18 claimed defect does not modify any obligation placed on the dealer to contact jayco directly when attempting to pursue remedies under state or federal law. Limitations, exclusions and disclaimer of implied warranties: any implied warranty that is found to arise by wa...

  • Page 27

    Section 1: warranty & service 19 notify jayco directly, in writing, at the above address, of the unsuccessful repair(s) of the alleged defect(s) so that jayco can become directly involved in making sure that you are provided service pursuant to the terms of this limited warranty. What is not covered...

  • Page 28

    Section 1: warranty & service 20 events discharging jayco from obligation under warranty: certain things completely discharge jayco from any obligation under this warranty and void it. By way of example, the following shall discharge jayco from any express or implied warranty obligation to repair or...

  • Page 29: Section 2: Occupant Safety

    Section 2: occupant safety 21 secondary means of escape (exit window) the emergency egress window allows a quick exit from the recreation vehicle during an emergency if access to the main entrance door is not available. Make sure all occupants know how to open and operate the egress window before an...

  • Page 30: Section 2: Occupant Safety

    Section 2: occupant safety 22 fire extinguisher fire extinguishers are classified and rated by fire type, a, b and c. These classifications identify the kinds of fires or burning materials they are designed to fight. Class a - solid materials such as wood, paper, cloth, rubber and some plastics. Cla...

  • Page 31: Section 2: Occupant Safety

    Section 2: occupant safety 23 be aware the smoke alarm is not fool proof and cannot detect fires if smoke does not reach it. Anything preventing smoke from reaching the alarm may delay or prevent an alarm. Though the alarm horn in this detector meets or exceeds current ul standards, it may not be he...

  • Page 32: Section 2: Occupant Safety

    Section 2: occupant safety 24 combination carbon monoxide /propane alarm your recreation vehicle is equipped with a combination carbon monoxide (co) / propane alarm that is listed for use in recreation vehicles. The combination carbon monoxide/ propane alarm will only work if it is operational and m...

  • Page 33: Section 2: Occupant Safety

    Section 2: occupant safety 25 limited life of the alarm.Carbon monoxide (co) is an insidious poison. It is a colorless, odorless and tasteless gas. Many cases of reported carbon monoxide poisoning indicate while victims are aware they are not well, they become so disoriented they are unable to save ...

  • Page 34: Section 2: Occupant Safety

    Section 2: occupant safety 26 that motor vehicle(s) are not, and have not been, operating in an attached garage or adjacent to the recreation vehicle. If problems are identified during this inspection, have the alarm serviced immediately. Note any combustion equipment not inspected by the technician...

  • Page 35: Section 2: Occupant Safety

    Section 2: occupant safety 27 note: the carbon monoxide/propane alarm manufacturer strongly recommends replacement of the detector five years after the date of purchase. Formaldehyde some components in the recreation vehicle contain formaldehyde-based adhesives that may release formaldehyde fumes in...

  • Page 36: Section 2: Occupant Safety

    Section 2: occupant safety 28 condensation - tent models only when camping leave a small opening using each bunk zipper to permit air flow and allow the tent to “breathe”. This will help minimize moisture gathering above the bunk area on the vinyl. Bunk zipper shown open to allow air flow condensati...

  • Page 37: Tow Vehicle

    Section 3: pre-travel information 29 tow vehicle if you plan to tow your recreation vehicle with a tow vehicle you already own, or if you plan to purchase a new one, make sure the gross vehicle weight rating (gvwr) or your recreation vehicle does not exceed your tow vehicles towing rating. Ask your ...

  • Page 38

    Section 3: pre-travel information 30 occc label (occupant & cargo carrying capacity: the upper portion of this yellow label is federally required and includes the maximum occupant & cargo carrying capacity that may be placed in or on the trailer as it was manufactured and weighed before leaving the ...

  • Page 39

    Section 3: pre-travel information 31 loading your recreation vehicle store and secure all loose items inside the rv before traveling. Overlooked items can become dangerous projectiles during a sudden stop. Distribute cargo side-to-side so the weight on each tire does not exceed one-half of the gawr ...

  • Page 40: Rear Bumper

    Section 3: pre-travel information 32 rear bumper the rear bumper of your rv is not designed to carry cargo. Items that extend beyond the bumper or weigh over 100 lbs. (45kg) will place undo strain on the bumper. The 100 lb. Bumper capacity includes the weight of the spare tire (if so equipped). Do n...

  • Page 41

    Section 3: pre-travel information 33 note:camping trailers have a ceiling light circuit fed through a master shut-off switch that prevents 12-volt current from flowing to the ceiling lights with the roof lowered. Periodically test the light and switch to be sure the switch adjustment is correctadjus...

  • Page 42

    Section 3: pre-travel information 34 adjust the equalizing bars of the hitch assembly so that the tow vehicle and the trailer are essentially level. A high hitch will transfer weight behind the axles and cause the vehicle to fishtail. A low hitch will transfer additional weight to the hitch. Refer t...

  • Page 43

    Section 3: pre-travel information 35 suggestions for sway situations: slowly ease your foot off the accelerator. Turn the steering wheel as little as possible. Natural lag time reaction when counter- steering to correct sway could possibly make it worse. If the trailer is equipped with electric brak...

  • Page 44: Wire Harness/connector Plug

    Section 3: pre-travel information 36 wire harness/connector plug a 7-way wire harness/connector plug is wired into your trailer to connect electrical power from the tow vehicle for travel. This supplies power to the rv brakes, taillights, clearance lights, turn signals, brake lights, etc. Wiring to ...

  • Page 45: Towing

    Section 3: pre-travel information 37 your rv must be weighed fully loaded (with food, clothing, fuel, water, propane, supplies, etc). 1. Weigh the rv including the tongue weight, while detached from the tow vehicle. This actual overall weight must be less than or equal to the gvwr for safe operation...

  • Page 46

    Section 3: pre-travel information 38 rv. Slow down in advance of dips, bumps and railroad tracks to reduce the jolting to your tow vehicle/rv combination. Proceed slowly and let the trailer tires pass over them before accelerating. Adverse weather conditions and extremes in terrain may affect the pe...

  • Page 47

    Section 4: vehicle operation 39 when your rv is new, it is impossible to adjust the brake shoes precisely. It takes approximately 1,000 miles and/or 50 medium to heavy stops to “burnish” fit or “seat” the shoes to the brake drum. After the initial break-in period your brake shoes must be adjusted ac...

  • Page 48: Towing Behind Your Rv

    Section 4: vehicle operation 40 it is extremely important to keep the master cylinder full at all times. An empty cylinder invites moisture. Disc brakes (if so equipped) if your rv is equipped with disc brakes, see the manufacturer’s owner’s manual for detailed safety and maintenance information. To...

  • Page 49: Campsite Hook-Up

    Section 4: vehicle operation 41 make sure the entrance door is completely closed and locked when traveling. Locking the door helps prevent it from opening unintentionally and keeps intruders from your recreation vehicle. Note:locks on entrance and baggage doors need biannual lubri- cation using a li...

  • Page 50: Stabilizer Jacks

    Section 4: vehicle operation 42 stabilizer jacks the stabilizer jacks must be fully retracted before moving or towing the rv to prevent stabilizer jack damage. Each stabilizer jack can be individually adjusted to stabilize the rv for use. When setting up on soft ground, you may wish to place a wood ...

  • Page 51: Emergency Towing

    Section 4: vehicle operation 43 do not use the stabilizer jacks to level the rv. It is important to remember that the stabilizer jacks are to be used only for support while occupying and moving around the rv. They are not designed to support the weight of the rv. Emergency towing if your recreationa...

  • Page 52

    Section 4: vehicle operation 44 check and tighten wheel lug nuts regularly to make sure they did not loosen during travel. Wheel lug nuts must be applied and maintained at the proper torque levels to prevent loose wheels, broken studs and possible separation of the wheel(s) from your recreation vehi...

  • Page 53: Tires

    Section 4: vehicle operation 45 tires read and understand the following before taking your first trip in your rv. Routine maintenance on your motor home is important. To insure your tires are operating safely, regular inspection of the tires and checking tire pressures is absolutely mandatory. Align...

  • Page 54

    Section 4: vehicle operation 46 you must follow the manufacturer’s inflation guidelines for maximum load capacity; under-inflation is just as dangerous as over-inflation. Proper inflation should be monitored closely. Failure to do so could result in the overheating of a tire causing a blowout. Infla...

  • Page 55: Changing A Tire

    Section 4: vehicle operation 47 changing a tire if you experience a flat tire on your recreational vehicle while driving, gradually decrease your speed and move the recreational vehicle to a safe place on the side of the road. 1. Keep the recreational vehicle attached to the tow vehicle. Block the t...

  • Page 56

    Section 4: vehicle operation 48 spare tire carrier (if so equipped) if your recreational vehicle is equipped with a spare tire, it will either be mounted under the unit (hoist) or on the rear bumper. Hoist mount depending on your model, the spare tire may have (side or bottom) brackets or it will be...

  • Page 57

    Section 4: vehicle operation 49 bumper mount the spare tire bracket can be released and extended down to access a storage compartment at the rear of the trailer without removing the tire. To extend the tire down 1. Remove the cotter key from the pin holding the tire carrier in place. 2. Remove the p...

  • Page 58: Caring For The Tent

    Section 4: vehicle operation 50 caring for the tent seasoning the new tent use a garden hose and thoroughly soak the tent with a light spray of water (do not spray directly on the tent with a high pressure hose). After the tent dries, repeat the soaking process three additional times. If you note an...

  • Page 59

    Section 4: vehicle operation 51 do not use any cleaner which contains abrasives, solvents, citrus or chlorine bleach. Damage to the fabric will result. If the tent must be stored wet, open the trailer and allow the tent to dry thoroughly as soon as possible. Be aware that the canvas portion of the t...

  • Page 60: Tent Set Up and Tear Down

    Section 4: vehicle operation 52 tent set up and tear down bed slide maintenance lubricate the bed slides two times each year. Use only a silicone spray to avoid attracting dirt and soiling the bed mats. Do not permit the spray to me into contact with the tent. Tent set up if you have questions conce...

  • Page 61

    Section 4: vehicle operation 53 power lift system (if so equipped) the power cord should be plugged into provide power to operate the lift system. If your rv is equipped with a power (roof) lift system, you will have two controls available. One is a switch located on the motor (arrow), and the other...

  • Page 62

    Section 4: vehicle operation 54 hinged braces installed on the front of the rv. Pull out the front bed until it is fully extended. Install the (hinged) brace ends into the brackets (c) located under both beds (d). A second person lifting the bed will make it easier to insert brace into the bracket. ...

  • Page 63

    Section 4: vehicle operation 55 repeat the process on the rear bed using the shorter braces. Make sure the bed is fully extended. Step 6 - if your model is equipped with a slideout, make sure the seal on the interior makes contact with the bracket on the slideout (arrow). The slideout should already...

  • Page 64

    Section 4: vehicle operation 56 step 10b - (slide out-if so equipped) the window bow brace for the slideout is typically stored under the dinette table. Attach the “claw” to the curved window bow (3-a) between the screws. Attach the loop end to the bracket near the ceiling. Put the tab end of the br...

  • Page 65

    Section 4: vehicle operation 57 step 14a – lifter post covers velcro all fabric lifter post covers. Bottom edges are straight and top edges are tucked under the roof. Step 15 - tent set up is complete. Make any adjustments to the tent to assure optimum water run-off. Check to make sure there are no ...

  • Page 66

    Section 4: vehicle operation 58 step 4 - bottom of the door is in the channel, and the door frame is against the aluminum pieces on each side of the doorway. Clips turn to hold the door in place. It helps to have a second person outside to help guide the door into the channel so it is square in the ...

  • Page 67

    Section 4: vehicle operation 59 standard door removal step 1 - remove the standard entry door, by lifting the door off the hinges. The standard door should be removed if the full screen door has been installed. Step 2 - the standard door is stored underneath the rear sliding bed. The hinges slide on...

  • Page 68

    Section 4: vehicle operation 60 5. To avoid damaging the valance, when securing the bottom of the entrance door, insure the door valance is placed between the door and the ceiling. 6. If your unit is equipped with a kitchen flip-top, put it into the travel position before lowering the roof. Failure ...

  • Page 69

    Section 4: vehicle operation 61 step 5 - remove the bed bow braces from the bed bows on each bed and the ceiling brackets. Place the braces under the bed mattress. Place the sharp ends of the brace against the edge of the bed. If equipped with a slideout, remove the slideout bow brace and store it u...

  • Page 70: Canopy (If So Equipped)

    Section 4: vehicle operation 62 step 12 - turn out all lights in the camper. Camping trailers have an automatic ceiling light shut- off switch that prevents ceiling light and/or ceiling fan operation with the roof in the lowered position. Periodically test the automatic ceiling light shut-off switch...

  • Page 71

    Section 4: vehicle operation 63 maintenance it is important to keep the canopy clean. Wash down the canopy brushing lightly with a cloth or soft brush. Keep the underside of the canopy clean by brushing it with a clean household broom. Wash the underside in the same manner as the top. Hose your cano...

  • Page 72

    Section 4: vehicle operation 64 5. Pull out the telescoping side arms. Pull the canopy flaps over the front and side rails and at the corners. Note: tilting the vertical legs in slightly will make it easier to pull the flaps down at the corners. Secure the end of the side arm into the top holder on ...

  • Page 73

    Section 4: vehicle operation 65 always install tent stakes to avoid wind damage to the poles and fabric. Wind and rain damage are not covered by warranty . Note: this method cannot be used if you are using a screen room. 8. The roof of the unit can now be raised and tent installation completed. Alte...

  • Page 74: Screen Room

    Section 4: vehicle operation 66 screen room installing the screen room skirt: 1. Unfold the screen room skirt and lay out under the canopy area. A grassy area or clean floor is suggested. 2. Starting at one end, snap the screen room skirt to the side of the unit, until all snaps have been installed....

  • Page 75

    Section 4: vehicle operation 67 note: it may be easier to begin set up if the canopy leg is tilted inward. 2. Starting at one corner, start the side zipper ) and zip it up completely. Repeat on the other side. 3. Attach the velcro on the front corner. Continue attaching the velcro across the entire ...

  • Page 76: Lifter System

    Section 4: vehicle operation 68 guide to screen room care and usage: care should be taken when setting up and taking down screen room to avoid tears and cuts. When putting away the screen room, the curtains should be in the down position and secured to the bottom with their strings. 1. Wash off any ...

  • Page 77: Section 5: Slideout Systems

    Section 5: slideout systems 69 slideout system not applicable for this product table of contents maintenance record.

  • Page 78: Section 5: Slideout Systems

    Section 5: slideout systems 70 notes: table of contents maintenance record.

  • Page 79: Section 6: Electrical System

    Section 6: electrical system 71 the electrical system the rv electrical system is comprised of two independent electrical systems. One operates off of 12-volt dc power and the other off of 120-volt 60hz ac power. All installations have been made in compliance with industry standards applicable on th...

  • Page 80: Section 6: Electrical System

    Section 6: electrical system 72 command center panel command center panel w/switch modules gfci receptacle there is a ground fault current interrupter (gfci) engineered into the electrical system. It is designed to reduce the possible injury caused by electric shock. The gfci will not protect agains...

  • Page 81: Section 6: Electrical System

    Section 6: electrical system 73 testing the campsite power connection the campsite 120-volt power receptacle(s) should always be tested for proper functionality prior to plugging the recreation vehicle shore power cord into it. Do not hook up the power cord to any receptacle until you have verified ...

  • Page 82: Section 6: Electrical System

    Section 6: electrical system 74 campsite 120-volt power receptacles can be tested using a digital multimeter or a dedicated circuit analyzer. Dedicated circuit analyzers plug directly into the campsite power receptacle and minimally test for open neutral, open ground, and correct polarity. Polarity ...

  • Page 83: Section 6: Electrical System

    Section 6: electrical system 75 it is important that the fluid level of any connected batteries be checked on a regular basis. All batteries will “gas” and lose some fluid when continuously connected to any charging source (does not apply to “gel-cell” batteries). If your lights are dimming or flick...

  • Page 84: Section 6: Electrical System

    Section 6: electrical system 76 converter w/charge wizard (if so equipped) some converters may be equipped with a charge wizard there are (3) possible charging modes; normal, boost and storage. The charge wizard will automatically select the best mode to charge your battery. A green led next to the ...

  • Page 85: Section 6: Electrical System

    Section 6: electrical system 77 replacing a fuse before replacing a fuse, always turn off the electrical components protected by it. 1. Disconnect the shore power cord. 2. Turn “off” the inverter (if so equipped). 3. Disconnect the house or auxiliary batteries main negative battery cable. 4. Remove ...

  • Page 86: Section 6: Electrical System

    Section 6: electrical system 78 battery disconnect switches switch appearance may vary by model dry camping the auxiliary battery should be fully charged prior to dry camping. If the auxiliary battery is not being recharged and power is being drawn from it, it will eventually discharge. A battery wi...

  • Page 87: Section 6: Electrical System

    Section 6: electrical system 79 enclosed exterior compartment. The style of the disconnect switch may vary per model. This switch does not shut off all power, but only shuts off the 12vdc power to the main 12v fuse panel, and the interior of the vehicle. Batteries can still be trickle charged by the...

  • Page 88: Section 6: Electrical System

    Section 6: electrical system 80 replacement only replace circuit breakers with those of the same specified type, voltage, and current rating. Never replace a circuit breaker with one listed at a higher amperage rating. Please contact your dealer for repair assistance when replacing circuit breakers....

  • Page 89: Section 6: Electrical System

    Section 6: electrical system 81 step cover 10.0 amps tv plate/antenna booster 1.0 amp water heater 6.0 amps water pump 7.0 amps *momentary load 12 volts: labeled watts divided by 12 = power consumed in amps 120 volt system air cconditioner 18 amps coffee maker 6-12 amps converter (each) 8 amps dvd s...

  • Page 90: Section 6: Electrical System

    Section 6: electrical system 82 do not hook up the power cord to any receptacle until you have verified proper polarity and grounding. Polarity indicators can be purchased in most electrical and hardware stores. Do not use any cheater plug, adapter or extension cord to reconfigure incoming ac power ...

  • Page 91: Section 6: Electrical System

    Section 6: electrical system 83 replacing light bulbs before replacing a bulb, be sure the light is off. Do not touch the glass part of the new bulb with your bare fingers. The skin oil left on the glass will evaporate when the bulb gets hot, the vapor will condense on the reflector and it will dim ...

  • Page 92: Section 6: Electrical System

    Section 6: electrical system 84 notes: table of contents maintenance record.

  • Page 93: Exhaust Gas Fumes

    Section 7: fuel & propane system 85 exhaust gas fumes to avoid breathing exhaust gases, follow these precautions: always shut off the tow vehicle engine, generator engine (if applicable), etc., while refueling. Do not run the tow vehicle engine, generator engine (if applicable), etc., in confined ar...

  • Page 94

    Section 7: fuel & propane system 86 dot propane cylinders must be transported and stored in an upright position so the pressure relief device will function properly. Laying a dot propane cylinder on its side may potentially create a very dangerous situation. The pigtail hose must be installed to avo...

  • Page 95

    Section 7: fuel & propane system 87 opd and acme type 1 service valve are identified by the triangular service valve knob. Dot cylinders are typically marked with “top” or an arrow to indicate the correct orientation of the cylinder(s). Do not mount, store or transport any cylinder other than the in...

  • Page 96

    Section 7: fuel & propane system 88 when you have a new cylinder filled for the first time, make sure your propane supplier purges your new cylinder of trapped air. Otherwise, an improper mixture of gas and air will make it impossible to light your propane appliances. No one should be inside and onl...

  • Page 97

    Section 7: fuel & propane system 89 pressures exceeding those of the propane system. However, because environment and time can both contribute to the deterioration of these components, they must be inspected for wear at regular intervals. Be sure to inspect the hose before each season and when havin...

  • Page 98: Propane Use and Safety

    Section 7: fuel & propane system 90 propane use and safety propane is a colorless and odorless gas that, in the liquefied state, resembles water. An odorant (usually a sulfur compound) is added as a warning agent. If you smell propane within the vehicle, quickly and carefully perform the procedure l...

  • Page 99

    Section 7: fuel & propane system 91 if you have double cylinders on your recreation vehicle, use only one at a time. Otherwise, the propane supply will be drawn equally from both cylinders until the supply has been totally exhausted. Using one cylinder until it is empty, then using the second cylind...

  • Page 100

    Section 7: fuel & propane system 92 traveling with propane use care when fueling your motor fuel tanks and/or propane containers. Make certain your propane tank is properly fastened in place. This label should be kept permanently affixed to your recreation vehicle. Refueling warning label note:some ...

  • Page 101

    Section 7: fuel & propane system 93 double cylinder two propane cylinders 6. Secure the cylinder to the a-frame bracket using the bolts, nuts and washers provided. Double cylinder mounted on a-frame (if so equipped) when a second cylinder is installed, a tee check valve is used to replace the 90° el...

  • Page 102

    Section 7: fuel & propane system 94 notes: table of contents maintenance record.

  • Page 103: Section 8: Plumbing System

    Section 8: plumbing system 95 plumbing system there are two different water systems in your recreation vehicle: the fresh water system consists of the fresh water holding tank, faucets and connections, water pump, outside shower assembly (if so equipped), water heater, tub/shower, and water purifica...

  • Page 104: Section 8: Plumbing System

    Section 8: plumbing system 96 fresh water holding tank there may be several ways to fill the fresh water tank depending on the model. For details of each method, refer to the fresh water connections or the utility center (if so equipped) sections. There are plastic overflow tubes in the fresh water ...

  • Page 105: Section 8: Plumbing System

    Section 8: plumbing system 97 the water pump switch should be in the off position when the rv is left unattended for any amount of time. If something would happen to the water system, this may help limit water damage to a smaller area. Fresh water connections your recreation vehicle may be equipped ...

  • Page 106: Section 8: Plumbing System

    Section 8: plumbing system 98 to disconnect the city water fill 1. Shut off the water at the pressurized water source. 2. Disconnect the non-toxic drinking water hose and reinstall the connection cap. The connection cap should always be installed if the water fill is not in use. Using the gravity fi...

  • Page 107: Section 8: Plumbing System

    Section 8: plumbing system 99 water heater switches (if so equipped): the water heater switches are typically located on the monitor panel. Refer to the monitor panelsection for function details. When to sanitize when your rv is new. At the beginning and end of each season. When the water system bec...

  • Page 108: Section 8: Plumbing System

    Section 8: plumbing system 100 6. Finish filling the fresh water tank by pouring fresh water into the gravity fill inlet. A pressurized water source can be used, but the hose will not screw on to the gravity fill inlet, use a funnel or hold the hose up to the inlet. 7. When the water tank is full (c...

  • Page 109: Section 8: Plumbing System

    Section 8: plumbing system 101 if you chose to perform the winterization process yourself, read and understand the following information before starting. Contact customer service or your dealer for questions about this process. It may be easier to winterize the rv with another person to assist you. ...

  • Page 110: Section 8: Plumbing System

    Section 8: plumbing system 102 winterizing with antifreeze use only rv antifreeze in your fresh water system for freeze protection. No other product or commodity should be used. Antifreeze should never enter the water heater, rv water filter, refrigerator, refrigerator water filter, or fresh water t...

  • Page 111: Section 8: Plumbing System

    Section 8: plumbing system 103 if needed, contact your rv dealer for assistance. Note: in the spring when flushing antifreeze out of the water lines make sure to turn the fresh water tank shutoff valve back on. Water heater the water heater manufacturer has preset the sensing limit to maintain the w...

  • Page 112: Section 8: Plumbing System

    Section 8: plumbing system 104 anode rod replacement chart note: depending on your water heater manufacturer, your water heater may or may not have a replaceable anode rod. Check your water heater manufacturer documentation or contact your rv cus- tomer service department. Water heater-pilot light (...

  • Page 113: Section 8: Plumbing System

    Section 8: plumbing system 105 the water from the water heater tank whenever the rv is not being used. Avoid any extended time of non-use with water in the tank. To prevent a water leak when replacing the anode rod, a pipe thread sealant approved for potable water (such as teflon tape) must be appli...

  • Page 114: Section 8: Plumbing System

    Section 8: plumbing system 106 maintenance do not allow the burner to burn with a yellow flame, or continue to operate the water heater with an improper burner flame. Periodically, inspect the water heater vent for soot. Soot is a sign of incomplete combustion and must be corrected before operating ...

  • Page 115: Section 8: Plumbing System

    Section 8: plumbing system 107 note: the shower head may be removed from the hose so that it will drain faster. If you remove the shower head, be sure to reas- semble it prior to storage. Faucets the bathroom, kitchen and outside shower faucets operate much the same way as the faucets in your home. ...

  • Page 116: Section 8: Plumbing System

    Section 8: plumbing system 108 toilet (if so equipped) depending on your model it may be equipped with a portable (cassette) chemical toilet and shower combination. The toilet has two tanks joined together. The upper tank has clean water used for flushing; the lower tank is the waste tank. Never add...

  • Page 117: Furnace

    Section 9: heating and cooling 109 air conditioner prep (if so equipped) your camping trailer may have the wiring needed to install an air conditioner (customer supplied). We recommend that aftermarket parts installation be performed by qualified rv technician(s). The camping trailer roof weight lim...

  • Page 118

    Section 9: heating and cooling 110 the furnace should be inspected periodically (monthly during the heating season) for presence of soot on the vent. Soot is formed whenever combustion is incomplete. This is a visual warning that the furnace is operating in an unsafe manner. If soot is observed on t...

  • Page 119: Section 10: Appliances

    Section 10: appliances 111 cooking safety in case of a grease fire grease is flammable. Never allow grease to collect around top burners or on the cook top surface. Wipe up spills immediately. Refer to section 2 – safety precautions, for fire safety and fire extinguisher information. Cooking with pr...

  • Page 120: Section 10: Appliances

    Section 10: appliances 112 use care to avoid steam burns if a wet sponge or cloth is used to wipe spills on a hot surface. Some cleaners can produce noxious fumes if applied to a hot surface. To prevent staining or discoloration, clean appliance after each use. If a part is removed, be sure it is co...

  • Page 121: Section 10: Appliances

    Section 10: appliances 113 oven (if so equipped) the propane gas oven must have 12-volt power to operate. If you have any questions, contact your dealer or our customer service department . Do not use the oven as a storage area. Refer to the manufacturer’s user guide for detailed operation, cleaning...

  • Page 122: Section 10: Appliances

    Section 10: appliances 114 quick connect coupler gas grill & mounting bracket on support rail set the bbq grill on the mounting bar by inserting the (2) pegs on the bar into the grill side mounting brackets. Make sure the mounting bar and the grill are securely in place before proceeding with the pr...

  • Page 123: Section 10: Appliances

    Section 10: appliances 115 gas/electric models (if so equipped) residential models (if so equipped) 3-way refrigerators (if so equipped) depending on your model, you may have a 3 way refrigerator (12vdc, lp gas or 120vac). Contact your dealer or customer service for details on winterizing your refri...

  • Page 124: Section 10: Appliances

    Section 10: appliances 116 4. Leave an open box of baking soda in the refrigerator and freezer to help prevent odors. There is no need for routine condenser cleaning in normal operating environments. If the environment is particularly greasy or dusty, or if there is significant pet traffic, the cond...

  • Page 125: Section 12: Interior

    Section 12: interior 117 cleaning the interior to keep the value of your recreation vehicle, perform regular maintenance using the proper materials and procedures. Using the wrong cleaner may result in damage to the surfaces in your vehicle. Check with the manufacturer’s information for the recommen...

  • Page 126: Section 12: Interior

    Section 12: interior 118 use spot remover, household cleaners or detergents to remove soiled spots, as these may cause damage to fabric or loss of color from fading. Mini blinds: a simple dry rag may do the trick. If they are especially dirty, you can use cold or warm water to clean them; never use ...

  • Page 127: Section 12: Interior

    Section 12: interior 119 pantry or hutch (if so equipped) your recreation vehicle may have a pantry or hutch that you can use for storage. Make sure all items stored in the pantry or hutch are secured to prevent shifting during travel. This cabinetry has been designed to accommodate the normal campi...

  • Page 128: Section 12: Interior

    Section 12: interior 120 flooring always test a cleaning agent in an inconspicuous area for colorfastness. Carpet vacuum your carpet regularly. It is important to remove loose soil and debris while it is on the surface. Heavily traveled areas (i.E., walkways, areas in front of the furniture) may be ...

  • Page 129: Section 12: Interior

    Section 12: interior 121 ensure the heated bed mats are on the bed board so the label and connector point up. The cord should be at the head of the bed. Do not tuck in the wired area of the heated bed mats. Let the cord hang free. Do not route electrical cords between the heated bed mats and the bed...

  • Page 130: Section 12: Interior

    Section 12: interior 122 notes: table of contents maintenance record.

  • Page 131: Section 13: Exterior

    Section 13: exterior 123 cleaning the exterior to protect your recreation vehicle’s exterior finish, wash it often and thoroughly. For recreation vehicles with painted exterior graphics: if desired you may wash and wax your vehicle 60 days after purchase. The exterior paint does need time to cure be...

  • Page 132: Section 13: Exterior

    Section 13: exterior 124 do not use solvent based cleaners on bird droppings or tree sap as these are water based stains. They can be dissolved using ammonia based glass cleaner, warm soapy water and a little “elbow grease”. Once again, after removing stubborn stains immediately rinse with clean wat...

  • Page 133: Section 13: Exterior

    Section 13: exterior 125 polishing your recreation vehicle if painted surfaces have been severely damaged and have lost their original luster and color tone, polish the surface lightly with a fine polishing compound. Avoid limiting your polishing to the damaged surface only; polish a somewhat wider ...

  • Page 134: Section 13: Exterior

    Section 13: exterior 126 e-z lube or super-lube axle (if so equipped) the e-z lube or super-lube feature on your axles provides the ability for the bearings to be periodically lubricated without removing the hubs from the axle. This feature consists of axle spindles that have been specially drilled ...

  • Page 135: Section 13: Exterior

    Section 13: exterior 127 if you notice water inside the recreation vehicle, immediately have the dealer check for the source of the leak. Failure to correct the leak may result in serious damage to your recreation vehicle; this damage may not be warrantable. Although the following diagrams may not a...

  • Page 136: Section 13: Exterior

    Section 13: exterior 128 notes: table of contents maintenance record.

  • Page 137: Travel Checklist

    Section 14: additional information 129 travel checklist following is a preliminary list of items that need to be checked before leaving your home or campsite. This is a general list, which you may want to customize as you determine your own needs. Safety make sure you follow all safety precautions n...

  • Page 138: Rv Storage

    Section 14: additional information 130 leaks. If leaks are detected, find the cause and correct it immediately. Turn off propane tanks. Empty black and gray holding tanks, rinse as needed (if so equipped). Retract awning and secure in place for transport (if so equipped). Close roof vents. Close win...

  • Page 139

    Section 14: additional information 131 excessive snow, 8” or more, or ice, 2” or more, places excessive weight on the rv roof. Remove excessive snow or ice as needed. Care must be exercised to not damage the roof material when removing snow & ice. Excessive weight can damage the roof, seals, etc. Wa...

  • Page 140

    Section 14: additional information 132 notes: table of contents maintenance record.

  • Page 141

    Section 15: additional information 133 featured components quick reference chart your recreation vehicle may be equipped with some of the items listed below. This is a partial listing and it is not intended to cover all components. All information is the latest available at the time of publication. ...

  • Page 142

    Section 15: additional information 134 tv antenna winegard company king jack www.Winegard.Com www.Kingconnect.Com water heater, tank dsi atwood greenbrier www.Atwoodmobile.Com water heater, tankless girard systems truma aquago www.Greenrvproducts.Com www.Truma.Com water pump, 12v shurflo east www.Sh...

  • Page 143: Vehicle Maintenance Record

    Section 15: additional information 135 vehicle maintenance record make: model: model year: vehicle serial#: service date mileage work performed performed by notes table of contents maintenance record.

  • Page 144

    Section 15: additional information 136 notes: table of contents maintenance record.

  • Page 145

    Section 15: additional information 137 jayco ownership notification fax form to: (800) 825-7876 □ change of owner □ transfer of limited warranty (see limited warranty for details) model information: serial#: ______________________ chassis #: _______________________ odometer reading ______________ (m...