Gto3501 1 channel power amplifier service manual jbl consumer products 250 crossways park dr. Woodbury, new york 11797 rev0 11/2007 released 2007 discontinued xxxx.
- contents - specifications ………………………………………..1 packing……………………………………………..…....2 control/installation drawings………………3 control/installation instructions………....4 basic troubleshooting……………………………5 exploded view/parts list…….….….…………....6 amplifier block diagram…………………….……7 electrical parts list ..……….……...
2 gto3501.
9a 01 2 8 5 6 34 7 ab ab c d a c b 12-1/4" 310mm 10-3/8" 263mm 2-1/8" 53mm ±ÈÀý 1.000 8 1-5/8" 40mm 1" 25mm d 2x 2x 4x 1x 1x 1x 3 gto3501.
Installation warnings and tips: • disconnect the negative (–) lead from your vehicle’s battery. • at the installation sites, locate and make a note of all fuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. • ...
Amplifier troubleshooting guide 1. Status led on amplifier not lit - head unit (source) turned on verify: a. Remote turn-on wire from source to amplifier has proper voltage b. Power (b+) connections at amplifier, terminal blocks, and battery are secure c. Ground (gnd) connections at amplifier and ve...
Front plate standoff trans. Clamp trans. Clamp 1380-0003-00 rca cap (red) rca cap (wht) 6 gto3501 part number part number.
1 2 3 4 a b c d 4 3 2 1 d c b a op op op op op op 11 25 320 11 320 20hz~100hz amp speaker balanced input unit balanced input unit gain control bass boost variable 0db--12db/20hz~100hz model freq variable lp 11hz--320hz/12db main amp frontl 2ohm/4ohm aux out l aux out r + - battery +vcc -vcc +v -v po...
Gto3501 electrical parts list part number qty reference designator main pcb resistors 0702-34r7-02 resistor 1/2w 4.7Ω ±5% 3 r242 r37 r36 0702-4220-02 resistor 1w 22Ω ±5% 3 r142 r141 r140 0702-3101-02 resistor 1/2w 100Ω ±5% 2 r223 r222 0702-24r7-02 resistor 1/4w 4.7Ω ±5% 6 r231 r229 r228 r227 r226 r2...
Part number qty reference designator description main pcb 06d212266010 cap,electro 22uf/50v ±20% 5*11 105c 8 c4 c5 c7 c9 c10 c13 c14 c204 06d212274001 cap,electro 220uf/25v ±20% 8*16 105c 3 c1 c2 c207 06d341849400 met capacitor 184/63v ±5% 1 c3 06d346849400 met capacitor 684/63v ±5% 1 c47 06d3247372...
Part number qty reference designator description main pcb pl-l0002-000 sheet ground gnd-3 1 2100-0083-02 wire 2pin p=2.54mm 1007# 26awg l=85mm (a2501top-2)5mm 105c 1 tem switch pwm pcb resistors 0701-2221-03 smd resistor smd 220Ω 1/8w ±1% 0805 1 r17 0701-2101-03 smd resistor smd 100Ω 1/8w ±1% 0805 1...
11 gto3501.
12 gto3501.
Gto3501 13.
1 2 3 4 a b c d 4 3 2 1 d c b a + 1 - 2 fed 3 dt 4 c 5 r 6 gnd 7 op1 8 + 16 - 15 ref 14 con 13 vcc 12 op2 11 e2 10 e1 9 tl494cn u1 tl494 r27 11k r9 22k c26 102/m c27 100/25v q10 a1015 r53 15k c3 1u/50v pro r30 1k r31 1k r28 1k r29 1k q3 c1815 r17 220r c25 104 q2 c1815 r10 100 r11 4.7k r13 3k c2 10/2...
1 2 3 4 5 6 7 8 a b c d 8 7 6 5 4 3 2 1 d c b a dw gno: part no: part name: product mode: scale: 1:1 unit: mm size: a4 rev: mv drawn by: checked by: approved by: data: data: data: power jbl gto3501 junping.Li 2007.07.19 c100 cc104 c115 cc104 c114 cc104 c102 47u/16v c142 cl102 r142 22r/ 1/2w c144 330...
1 2 3 4 5 6 7 8 a b c d 8 7 6 5 4 3 2 1 d c b a q200 b647 q214 5401 r202 68r q207 s8050 q211 5551 q212 5551 q213 d669 q201 d669 q202 d669 q219 b817 r206 470k lin r207 220r r204 2k2 r205 4.7k c204 w22u/50v r242 4.7r/0.5w c211 cl104 c205 cc473 r214 6.8k r211 22r r208 22k r210 22r c201 cc56p/100v r217 ...
1 2 3 4 5 6 a b c d 6 5 4 3 2 1 d c b a dw gno: part no: part name: product mode: scale: 1:1 unit: mm size: a4 rev: mv drawn by: checked by: approved by: data: data: data: input jbl gto3501 junping.Li 2007.07.19 r5 47k r1 22k c1 np/220u/25v c19 cc101 r6 47k r3 47k input 1 2 ch1-input c4 w22u/50v c15...
