1. DL manuals
  2. JBL
  3. Amplifier
  4. GTO 24001
  5. Service Manual

JBL GTO 24001 Service Manual - A B

Manual is about: 1 CHANNEL POWER AMPLIFIER

Summary of GTO 24001

  • Page 1

    Gto 24001 1 channel power amplifier service manual jbl consumer products 250 crossways park dr. Woodbury, new york 11797 rev0 1 2/2008 released 2008 discontinued xxxx.

  • Page 2: -  Contents  -

    - contents - specifications ………………………………………..1 packing……………………………………………..…....2 control/installation instructions….……....3 control/installation drawings……….………4 basic troubleshooting……………………………5 exploded view/parts list…….….….…………....6 amplifier block diagram…………………….……7 electrical parts list ..………....

  • Page 3

    Gto24001 2.

  • Page 4

    Installation warnings and tips • disconnect the negative (–) lead from your vehicle’s battery. • at the installation sites, locate and make a note of all fuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. • c...

  • Page 5: A B

    9 a 0 2 8 5 6 3 4 7 a b ab c d a c b 24-13/16" 630mm 10-3/8" 263mm 2-1/8" 53mm 8 1-5/8" 40mm 1" 25mm d 1x 2x 4x 1x 1x 1x 1 4 gto24001.

  • Page 6

    Amplifier troubleshooting guide 1. Status led on amplifier not lit - head unit (source) turned on verify: a. Remote turn-on wire from source to amplifier has proper voltage b. Power (b+) connections at amplifier, terminal blocks, and battery are secure c. Ground (gnd) connections at amplifier and ve...

  • Page 7

    6 gto24001.

  • Page 8

    7 gto24001.

  • Page 9

    Gto24001 electrical parts list part number qty reference designator main pcb resistors res68001/8-f resistor metal film 1/8wf680 ohm 1 r3 res56001/8-f resistor metal film 1/8wf560 ohm 1 r4 res78701/8-f resistor metal film 1/8wf787 ohm 1 r48 res13011/8-f resistor metal film 1/8wf1.3k ohm 1 r44 res150...

  • Page 10

    Part number qty reference designator description main pcb gf063pb502k volume gf063pb502k 1 sv1 15s-3b500x2 boost pot v12l5(9x5)g(ph2d)n 15s-3b500x2 1 vr4 15s-3b20kx2 input level pot v12l5(9x5)g(ph2d)n 15s-3b20kx2 1 vr1 15c50kx2 lp freq. Pot v12l5(9x5)g(ph2d)n 15s-15c50kx2 1 vr2 15c200k+c2kx2 hp freq...

  • Page 11

    Part number qty reference designator description main pcb diode-6a60 diode rectifier6a60 2 d9,10 diode-mu36r silicon bridge fast recovery,to-3pfmu36r 2 d2,4 diode-mu36s silicon bridge fast recovery,to-3pfmu36s 2 d1,3 miscellanous crystal-2.56mg crystal ceramic resonator,2.56mhzzta2.56mg 1 x1 ret9401...

  • Page 12

    Part number qty reference designator description driver sub pcb (x 2) cap050105-0805 capacitor smd"0805"105pf 2(x2) c1,3 cap063105-m capacitor mylar 5% 63v "tl type"105 j 2(x2) c2,4 cap0501r0-e-1 capacitor electrolytic"se/sre", h=5m/m1uf/50v 1(x2) c11 cap025220-e-1 capacitor electrolytic"se/sre", h=...

  • Page 13

    Part number qty reference designator description pwm pcb cap016470-e-1 capacitor electrolytic "se/sre", h=5m/m47uf/16v 3 c8,15,21 cap016101-e-1 capacitor electrolytic "se/sre", h=5m/m100uf/16v 1 c14 semiconductors diode-ll4148 diode switching signal,mini melfll4148 3 d1,2,3 kds184 diode switching si...

  • Page 14

    1of4 2008.11.06 gto24001 gto24001 topview 3 . 3 k 13 gto24001.

  • Page 15

    2of4 2008.11.06 gto24001 gto24001 topview rev. A 14 gto24001.

  • Page 16

    Gto24001 topview gto24001 3of4 2008.11.06 15 gto24001.

  • Page 17

    Gto24001 topview gto24001 4of4 2008.11.06 16 gto24001.

  • Page 18

    17 gto24001.

  • Page 19

    18 gto24001.

  • Page 20

    19 gto24001.

  • Page 21

    20 gto24001.

  • Page 22: Lm161/lm361

    Lm161/lm361 high speed differential comparators general description the lm161/lm361 is a very high speed differential input, complementary ttl output voltage comparator with im- proved characteristics over the se529/ne529 for which it is a pin-for-pin replacement. The device has been optimized for g...

  • Page 23

    Motorola cmos logic data 1 mc14060b the mc14060b is a 14–stage binary ripple counter with an on–chip oscillator buffer. The oscillator configuration allows design of either rc or crystal oscillator circuits. Also included on the chip is a reset function which places all outputs into the zero state a...

  • Page 24

    23 gto24001.

  • Page 25

    24 gto24001.

  • Page 26

    1of4 gto24001 2008. 11. 06 gto24001 sch 3. 3k 1 25 gto24001.

  • Page 27

    2of4 gto24001 2008. 11. 06 gto24001 sch 26 gto24001.

  • Page 28

    3of4 gto24001 2008.11.06 gto24001 sch 27 gto24001 27.

  • Page 29

    4of4 gto24001 20 08 .11.06 gto24001 sch 28 gto24001.