1. DL manuals
  2. JBL
  3. Car Amplifier
  4. GTO6000
  5. Technical Manual

JBL GTO6000 Technical Manual

Other manuals for GTO6000: Owner's Manual
Manual is about: 6 CHANNEL

Summary of GTO6000

  • Page 1

    6 channel power amplifier technical manual gto 6000 jbl consumer products 250 crossways park drive, woodbury, ny 11797 8500 balboa boulevard, northridge, ca91329 www.Jbl.Com 6/5/4/3 channel power amplifier gto 6000 -3 db -8 db -13 db -13 db -3 db -8 db 0 db +3 db +3 db 0 db -13 db -13 db.

  • Page 2

    Specifications specifications .........................................................1 features .................................................................2 test conditions and notes .......................................2 controls and connections ........................................3 t...

  • Page 3

    Test conditions and notes all tests to be done, unless otherwise specified, from 30hz to 320hz at 14.4v dc into 2 ohm loads and adjust the units gain so that with a .100 volt input signal the unit is at its maximum rated output. All measurements will be done using an audio precision system one and t...

  • Page 4

    Controls and connections 3 1 3 6 4 5 9 8 7 controls and connections 1. Low input (rca jack type) - commed to line of level output from the source umt 2. Power indicator 3. Input-sensitivity level coltrol 6. +6db(at45hz)bass boost,only sub channel 4. High pass filter which can be set at any freg betw...

  • Page 5

    Typical system configuration 4 vehicle battery chassis ground ignition switch cd player or changer cassette/cd tuner (head unit) power ground 60 amp (not included) main +12v amplifier power connection line level input remote on/off remote antenna power supply antenna motor ground remote on/off black...

  • Page 6

    Printed circuit board (top view) 5 6 channel power amplifier gto 6000

  • Page 7

    Printed circuit board (top view) 6 6 channel power amplifier gto 6000 d11 c001 d06 c002 c101 c102 r101 r102 r001 r002 r003 u02 d01 nht224gdx12 d12 u01 d14 d16 d15 d13 d02 d05 d04 d03 u01 u02 d03 r102 r101 c102 c101 c002 c001 d04 d05 d11 d02 d13 d15 d16 d14 d12 d01 nht224gdx12 r003 r002 r001 d06 wf01...

  • Page 8

    Printed circuit board (top view) 7 pas16901 f-rin f-lin gnd r-rin r-lin s-rin s-lin +15v -15v +15v(s) -15v(s) gnd red yellow con1 vr201 20kb r406 470 r413 2.7k r412 10k r410 4.3kf r313 2.7k r312 10k r306 470 d81 klg124-e r310 4.3kf 473p c523 r606 4.3kf r516 10k r573 680k r578 1k r506 4.3kf vr301 20k...

  • Page 9

    Gto6000 parts list 8 6 channel power amplifier ref. No ref. No main pcb, preamp, crossover, power supply and power amplifier part no. Part no. Description description q'ty q'ty f.E.T transistor diode resistor q43,44,45,46,47,53 fet-00-00023 fqp50n06 q02,25,27,111,112 ktc3198gr q121,122,221,222 q211,...

  • Page 10

    6 channel power amplifier ref. No ref. No part no. Part no. Description description q'ty q'ty capacitor c171,271,371,471 c571,671 c133,233,333,433 c533,633 c142,143,151,242 c243,251,342,343 c351,442,443,451 c542,543,551,642 c3,7,9,18,22,31 c215,415,425,615 c643,651 c32,33 c24,25,53,63 c145,146,225,3...

  • Page 11

    6 channel power amplifier ref. No ref. No part no. Part no. Description description q'ty q'ty ic u11 ico-00-00022 p.W.Mic tl494cn 1 u101,102,201,202,301ico-00-00112 dual op amp njm2068ld 8 u302,303,304 wire s - 6 (sub l-ch) 1015 awg#18 blue 340m/m 1 r- 4 (rear l-ch) 1015 awg#18 red 410m/m 1 s - 5 (s...

  • Page 12

    11 block diagram 6 channel power amplifier gto6000 block diagram volume volume input amp input amp switch switch full full lpf ( 32 ~ 320hz ) hpf ( 32 ~ 320hz ) output stage channels 1+2 / 3+4 output stage channels 5+6 front/rear sub bass boost( @45hz : +6db ) switch gto 6000

  • Page 13

    Packaging exploded view 12 6 channel power amplifier gto 6000 ¤Ñ ma- pb- 01- 6916- 0 ma- cb- 02- 6914- 0 dw#2, 685.0x240.0x368.0 sw#1, 670.0x343.0x110.0 vinyl, 400.0x750.0x0.1t 13 model gto6000 1 1 1 2 4 4 2 q'ty rubber,phi12.0xphi5.0x2.0t 1 1 1 2 1 1 1 q'ty sw#1, 338.0x105.0x95.0 gto6000 30a 2.5sq ...

  • Page 14

    13 integrated circuit diagrams u11 (tl494cn) p.W.M ic dead time control u101,102,201,202,301 u302,303,304 (njm2068d) -dual op amp 1 2 3 4 5 6 7 8 a b - - + + 6 channel power amplifier gto 6000

  • Page 15

    14 transistor diagrams c c b b e e * kta1023y * q1,113,124,213,224 q313,324,413,424 gg g dd d ss s *fqp50n06 q43,44,45,46,47 q53,54,55,56,57 c c b b e e * ktc1027y * q114,123,214,223,314 q323,414,423 c c b b e e c b e * ktc3198gr * q2,25,27,111,112,211,212 q311,312,411,412,511,512 q611,612 * kta1266...

  • Page 16

    Transistor diagrams 15 transistor diagrams c b e * ktd718 * q115,215,345,415 * tip35c * q545,615 c b e *ktb688 * q235,225,345,425 *tip36c * q546,625 e c b c b e c b e * ktc3198bl * q21 * ktc3200gr * q141,241,341,441 q541,641,130,230 q330,440,530,630 c b e * kta1268gr * q3 * yg225d2 * d3,4,9,10 d k k...

  • Page 17

    Power amplifier (sheet 1) 6 channel power amplifier 16 a 1 2 3 4 5 b c d gto6000

  • Page 18

    Power amplifier (sheet 2) 6 channel power amplifier 17 a b c d 1 2 3 4 5 gto6000

  • Page 19

    Power amplifier (sheet 3) 6 channel power amplifier 18 a b c d 1 2 3 4 5 gto6000

  • Page 20

    Power amplifier (sheet 4) 6 channel power amplifier 19 a b c d 1 2 3 4 5 gto6000

  • Page 21

    Power amplifier (sheet 5) 6 channel power amplifier 20 a b c d 1 2 3 4 5 gto6000 d02 d03 d04 d05 d06 d01 d12 d13 d14 d15 c101 d16 d11 r002 r102 c102 r103 c002 r003 c001 u01 r101 r001 nht224gd nht224gd nht224gd nht224gd nht224gd nht224gd nht224gd nht224gd nht224gd nht224gd 0.47/50v nht224gd kia6966s ...

  • Page 22

    Gto6000 mechanical exploded view 21 6 channel power amplifier gto6000 1.5 chung lam co.,ltd. 0.3 0.5 1000 code no. Issue exploded view mm 0.2 0.1 0.05 1~10 0.2 0.3 0.1 0.2 100 ~ 500 ~ 500 100 10 ~ draw 0.3 0.5 part's name a b dim grd no unit c angle third rela draw no ns appro check name 2002.05.14 ...