Summary of 242609
Page 1
G18y07p-02.
Page 2: Table of Contents
Section one safety instructions………………………………… placement of the grill ……………………………. Section two side shelf & side burner assembly……………. Side shelf handle assembly & battery installation………………………………………… braking system operations & liquid propane cylinder retention system………………………. Slide-out tray locking...
Page 3: Safety Instructions
Safety instructions warning 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire resulting in death or serious injury could occur. Warning never attempt to use d...
Page 4: Safety Instructions
Safety instructions warning 1. Attach the coupling half (socket) to the gas supply line in accordance with nfpa54/ansi z223.1fuel gas code. 2. Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 11. After the leak test is completed, rinse the conne...
Page 5: Safety Instructions
Safety instructions warning do not attempt to light the grill if gas odor is present. Contact customer service at 1-800-554- 5799. When lighting, keep your face and body as far away from the burner as possible. Before lighting inspect the gas supply hose prior to turning on the gas. If there is evid...
Page 6: Safety Instructions
Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58 - 2007 latest standard and csa 1.6- 2007standard for outdoor cooking gas appliances. This grill is for outdoor use only. Chec...
Page 7: Safety Instructions
Safety instructions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place...
Page 8: Side Shelf Assembly
6 side shelf assembly estimated assembly time: approximately 10 minutes required tools: phillips screwdriver (not included) 1. Remove side shelf from inside grill cart. 2. The screws used to attach the side shelf are already screwed into the side of the grill cart. Remove the screws from the side pa...
Page 9: Side Shelf Handle Assembl
7 y screws from the side of the shelf. S in the side rews and tighten. . Insert the battery into the housing with the positive (+) terminal facing outward. . Replace the ignition button side shelf handle assembl estimated assembly time: approximately 5-7 minutes required tools: phillips screwdriver ...
Page 10: Braking System Operations
8 braking system operations 1. Push to the right to lock. 2. Push to the left to unlock. Liquid propane cylinder retention system 1. Set the liquid propane gas cylinder into the slide-out tray. Turn the retention screw clockwise to secure the gas cylinder. 2. Make sure tank is leveled with bottom pa...
Page 11: Propane Regulator Hook-Up
9 slide-out tray locking system 1. To lock the liquid propane gas cylinder tray, press the button located on the top of the slide-out tray (a). 2. To unlock, press the side button (b) as shown below. B a 1 00 200 300 40 0 500 60 0 7 00 800 a b propane regulator hook-up 1. Attach the regulator to the...
Page 12: Gas Hook-Up
Gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill h...
Page 13: Leak Testing
11 3. Detach the regulator assembly from the tank valve by turning the quick coupling nut counterclockwise. 4. Place the dust cap on the liquid propane cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap that is provided with the cylinder valve. The use of other ...
Page 14: Installer Final Check
12 the gas must be turned off at the supply cylinder when the unit is not in use. If the appliance is stored indoors, the cylinder must be disconnected and removed from the appliance. Cylinders must be stored outdoors in a well- ventilated area out of the reach of children. Warning cylinder must be ...
Page 15: Operating Instructions
Operating instructions general use of the grill and rotisserie each main burner is rated at 15,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter...
Page 16: Lighting Instructions
Note it is normal for the skewer to flex when larger cuts of meat are being cooked. If the meat scrapes on the cooking grids during any part of the rotation, the cooking grids must be removed. Test this clearance before lighting the grill as the cooking grids become hot when the grill is lit. 14 adj...
Page 17: Lighting Illustrations
15 lighting illustrations main burner lighting rotisserie burner & searing side burner lighting 1. Open the top cover or lid. 1. Push and turn rear burner slowly to “ingite / on” setting; you should hear a “clicking sound if the electronic ignition system is working properly. The burner should ignit...
Page 18: To Match Light The Grill
16 to match light the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. Main burner 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into...
Page 19
17 sear burner 1. If you have already attempted to light the searing side burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting rod. Ignite the match and insert through the cooking grid to the burner. 3. Press the control knob and rotate l...
Page 20
18 rotisserie burner note: remove the warming rack when using a match to light the rotisserie burner. 1. If you have already attempted to light the rotisserie burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting rod. Ignite the match and ...
Page 21: Grill Lights
19 grill lights light operation instruction 1. Make sure light’s power switch on the control panel is in the “off” position. 2. Connect power plug to properly grounded outlet. 3. Turn the light’s power switch to “on”. Warning keep any electrical supply cord away from any heated surface. Bulb replace...
Page 22
5. Use a screwdriver to loosen the two screws locking the bulb. Pull out the light bulb and replace with a new bulb. 6. Reverse the instruction from steps 5-1 for installation. Cleaning method follow steps 1-4 above for glass cover removal. Use a damp towel to clean the surface of glass cover. Make ...
Page 23: Using The Side Burner
Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. Warning when lighting, always keep your face and body as far away from the burner as possible. Lighting instru...
Page 24
Care & maintenance of the grill stainless steel grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. Grill rack the best time to clean the grill is immediately after cooking is comp...
Page 25: Troubleshooting
Troubleshooting when to look for spiders you should inspect the burners at least twice a year or immediately after any of the following conditions occur: 1. The smell of gas in conjunction with burner flames appearing yellow. 2. The grill does not reach temperature. 3. The grill heats unevenly. 4. T...
Page 26
Exploded view 720---0511 24 72 71 45 46 48 48 49 50 40 42 67 69 70 39 51 52 66 16 78 60 13 33 69 68 38 38 39 41 79 77 31 75 06 03 36 37 37 37 37 12 08 85 48 47 47 56 01 44 76 02 02 01 14 35 35 06 84 10 06 06 74 75 26 32 55 54 53 86 57 65 58 59 61 62 63 64 20 19 21 80 81 82 83 41 40 43 30 29 28 27 25...
Page 27
Parts list 720-0511 1 tank bolt 43 1 main lid handle seat, left 07 1 transformer box waterproof spacer 72 1 bottom panel, lp 36 1 transformer supporting box cover 71 2 swivel caster 35 1 cart frame , front 70 1 lamps fix bracket 34 2 door hinge bracket, top 69 1 tank heat shield 33 1 horizontal bar ...
Page 28
1 main lid handle tube 85 1 main burner igniter wire (b) 78 1 thermocouple bracket (rotisserie burner ) 84 1 main burner igniter wire (a) 77 1 warming rack 83 1 rear baffle 76 2 cooking grid with hole 82 2 lamps 75 3 flame tamer 81 1 transformer 74 3 main burner 80 1 transformer supporting box 73 qt...
Page 29: Grill Cooking Chart
This jenn-air grill has an infrared side burner – commonly referred to as a “searing” burner. This type of burner produces extreme heat that can be used to “sear” the outside of food thus locking the juices inside. This process is used at many upscale restaurants to improve the flavor of the food. T...
Page 30
French fries medium 15 to 30 minutes place in aluminum foil pan. Grill, stirring occasionally. Food weight or thickness flame size approximate time special instructions and tips meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not ...
Page 31
Poultry broiler/fryer 2 to 3 pounds low 1 to 1-1/2 hours place skin side up. Grill. Turn and brush frequently with melted butter, margarine, oil, or marinade. Food weight or thickness flame size approximate time special instructions and tips breasts well-done medium 30 to 45 minutes marinate with it...
Page 32: Grill Recipes
Bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill and c...
Page 33
Heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, and taco sauce. Beef and lamb kabobs serve 4 1/2 lb. Boneless sirloin or beef cut into 1...
Page 34: Limited Warranty
Limited warranty model #720-0511 stainless steel outdoor gas grill nexgrill industries, inc.,warrants to the original consumer-purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified belo...