Stainless steel natural gas grill model no.: 730-0337 item no: 27043 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. ® 800 700 600 500 400 300 200 100 for outdoor use only please contact 1-800-554-5799 for assistance do not return to pla...
Section one safety instructions placement of the grill section two side shelf & side burner assembly spice tray assembly side burner hose quick-connect side shelf handle & battery installation braking system operations & installation of natural gas regulator table of contents section five section th...
Safety instructions warning 1. The grill and its individual shut-off valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 1/2 psi. (3.5 kpa). 2. The grill must be isolated from the gas supply piping system by closing it...
Safety instructions warning 1. Attach the coupling half (socket) to the gas supply line in accordance with ansi z223.1/nfpa54/ fuel gas code. 2. Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 9. After the leak test is completed, rinse the conn...
Safety instructions warning do not attempt to light the grill if gas odor is present. Contact customer service at 1-800-554- 5799. When lighting, keep your face and body as far away from the burner as possible. Warning do not store or use gasoline or other flammable vapors and liquids in the vicinit...
Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58a • csa 1.6a-2006 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building c...
Safety instructions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place...
Side shelf assembly estimated assembly time: approximately 10 minutes. Required tools: phillips screwdriver (not included) 1. Open the grill lid and remove the side shelf from the fire box. 2. The screws used to attach the side shelf are already screwed into the side panels of the grill cart. Remove...
7 spice tray assembly mount the tabs on the spice tray into the holes on the left door of the grill. 800 700 600 500 400 300 200 100
8 side burner hose quick-connect estimated assembly time: approximately 5-7 minutes required tools: phillips screwdriver 1. Insert the side burner hose with female sleeve through side panel of cart (top drawing). 2. Push the sleeve of the female socket back and insert the male end of connector. Rele...
Side shelf handle assembly estimated assembly time: approximately 5-7 minutes required tools: phillips screwdriver (not included) 1. Remove the four side shelf handle screws from the side shelf. 2. Align the holes in the handle with the holes in the side shelf. 3. Insert the screws and tighten. 9 ba...
10 braking system operation 1. Push to the right to lock. 2. Push to the left to unlock. Installation of natural gas regulator 1. Connect the pvc natural gas hose to the house gas supply line using the quick-connect fitting as shown in figure a. Check all gas supply fittings for leaks before each us...
Gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. Total gas consumption (per hour) of the 730-0337 natural gas grill with all burners set on “hi”: main bu...
Installer final check
specified clearance maintained of 24 inches from combustible materials/construction.
all internal packaging has been removed.
the hose and regulator are properly connected.
the unit has been tested and is free of leaks.
the gas supply shut off valve has been located. ...
Operating instructions general use of the grill and rotisserie each main burner is rated at 13,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter...
Note it is normal for the skewer to flex when larger cuts of meat are being cooked. If the meat scrapes on the cooking grids during any part of the rotation, the cooking grids must be removed. Test this clearance before lighting the grill as the cooking grids become hot when the grill is lit. Adjust...
15 lighting illustrations rotisserie burner & searing side burner lighting main burner lighting 1. Open the top cover or lid . 1. Push and turn rear burner knob slowly to “ignite / on” setting, hold in until th burner is lit up, continue to press and hold for 15 seconds and release. You should hear ...
16 to match light the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, wait 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting...
17 grill lights light operation instruction 1. Make sure light’s power switch on the control panel is in the “off” position. 2. Connect power plug to properly grounded outlet. 3. Turn the light’s power switch to “on”. Warning keep any electrical supply cord away from any heated surface. Bulb replace...
5. Use a screwdriver to loosen the two screws locking the bulb. Pull out the light bulb and replace with a new bulb. 6. Reverse the instruction from steps 5-1 for installation. Cleaning method follow steps 1-4 above for glass cover removal. Use a damp towel to clean the surface of glass cover. Make ...
Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. Warning when lighting, always keep your face and body as far away from the burner as possible. Lighting instru...
Care & maintenance of side burner burner cleaning clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog the port. Stainless steel there are many stai...
Care & maintenance of the grill stainless steel grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. Grill rack the easiest way to clean the grill is immediately after cooking is co...
Troubleshooting when to look for spiders you should inspect the burners at least twice a year or immediately after any of the following conditions occur: 1. The smell of gas in conjunction with burner flames appearing yellow. 2. The grill does not reach temperature. 3. The grill heats unevenly. 4. T...
Exploded view model 730-0337 83 82 56 55 57 24 25 26 27 29 33 34 38 39 40 41 43 28 58 37 64 81 79 78 72 77 65 23 21 20 18 13 16 17 80 31 45 03 02 01 22 60 61 30 32 36 84 19 47 71 70 69 68 48 74 75 76 66 46 15 73 35 28 44 54 09 08 10 11 42( d) 07 67 12 62 63 04 05 04 05 04 04 06 42( a) 42( b) 42( c) ...
Parts list 24 m odel no. 730-0337 ref# description q’ty ref# description qty 01 main lid 1 37 front trim panel, right 1 02 temperature gauge 1 38 warming rack 1 03 logo 1 39 cooking grid with hole 3 04 temperature gauge heat insulating spacer 4 40 flame tamer 4 05 main lid handle heat insulating cov...
25 ref# description q’ty ref# description qty 73 side burner grease tray 1 79 wheel axle 1 74 side burner orifice brass connector 1 80 axletree base 2 75 side burner flex gas 1 81 wheel 2 76 side burner gas valve 1 82 lighting rod 1 77 side burner control panel 1 83 lighting rod cover 1 78 foot brak...
This jenn-air grill has an infrared side burner – commonly referred to as a “searing” burner. This type of burner produces extreme heat that can be used to “sear” the outside of food thus locking the juices inside. This process is used at many upscale restaurants to improve the flavor of the food. T...
Food weight or thickness flame size approximate time special instructions and tips meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not leave hamburgers unattended. A flare-up could occur quickly. Tenderloin, high 8 to 15 minutes p...
Food weight or thickness flame size approximate time special instructions and tips breasts well-done medium 30 to 45 minutes marinate with italian dressing fish and seafood steaks grill, turning once. Brush with halibut 3/4 to 1 inch medium to 8 to 15 minutes melted butter, margarine or oil salmon h...
29 bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill an...
30 pound flank steak to ¼ inch thickness or flatten chicken breasts. Mix oil, limejuice and seasonings in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 t...
Limited warranty model # 730-0337 stainless steel outdoor gas grill nexgrill industries, inc.Warrants to the original consumer-purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified belo...
