1. DL manuals
  2. Jenn-Air
  3. Grill
  4. 720-0138-NG
  5. Instructions Manual

Jenn-Air 720-0138-NG Instructions Manual - Match Lighting The Grill

Summary of 720-0138-NG

  • Page 1

    Stainless steel built-in gas grill model #s: 720-0139-ng / 720-0142-lp lowe’s item #s: 168935/168934 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. For outdoor use only please contact 1-800-554-5799 for assistance do not return to place...

  • Page 2: Table of Contents

    Table of contents section one important warnings … … … …. ………… 1 safety instructions … … … ….................. 2-4 placement of the grill … … ……………… 4 section two model specifications… … … …………….. 5 island construction … … … ….................. 6 front view of opening … ………………… 7 rear view of openin...

  • Page 3: Important Warnings

    Important warnings for your safety if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open the top cover or lid. 4. If the odor continues, immediately call your gas supplier or local fire department. 5. Do not store or use gasoline or other flammable vapors and liq...

  • Page 4: Safety Instructions

    Safety instructions caution hazardous or unsafe practices that could result in personal injury. Warning hazardous or unsafe practices that could result in personal injury or death. Safety symbols common cautions and warnings insect warning spiders and insects can nest inside the burners of this and ...

  • Page 5: Safety Instructions

    Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58b latest standard and cga 1.6b-2002 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check you...

  • Page 6: Placement of The Grill

    When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place of potholders. Do n...

  • Page 7: Grill Specifications

    Grill specifications description 720-0139-ng and 720-0142-lp cutout width 37 1/2 in. (95.25 cm) cutout depth 23 1/4 in. (59.05 cm) cutout height 10 1/4 in.(26.04 cm) natural gas: standard residential 1/2 in. (1.3 cm) id gas service line. Natural gas hose/regulator assembly included with quick- conne...

  • Page 8: Grill Specifications

    Grill specifications description 720-0139-ng and 720-0142-lp cutout width 37 3/4 in. (95.89 cm) cutout depth 21 ½ in. (54.61 cm) cutout height 10 3/4 in.(27.31 cm) natural gas: standard residential 1/2 in. (1.3 cm) id gas service line. Natural gas hose/regulator assembly included with quick- connect...

  • Page 9: Island Construction

    Island construction 17 i n .(43.18cm) 10 3/4 in.(27.31cm) 21 1/ 2 in. (54 .61 cm ) 37 3 /4 in .(95 .89 cm ) a minimum of 3 in.(7.62cm) clearance from the back of the grill is required to non-combustible material. Warning do not install this unit into combustible enclosures. There should be a minimum...

  • Page 10

    Side view for built-in opening 1 0 1/4 in.(2 60.4mm) 22 5/ 8 in .( 574 .6 mm) 12 3/ 8 in. (314. 3mm ) 24 6/8 in.(628.6mm) 26 1/4 in.(666.7mm) 8 3/ 8 in. (212. 7mm) 9 in.( 229mm) a minimum of 3 in.(76.2mm) is required between the back of the grill and any non-combustible material. A minimum of 24 in....

  • Page 11: Battery Installation

    Battery installation 1. To install the battery, remove the ignition button housing. 2. Insert the battery into the housing with the positive pole of the battery facing outward. 3. Replace the ignition button housing after the battery has been installed (see the image below). 9.

  • Page 12: Lp Gas Hook-Up

    Lp gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply. Total gas cons...

  • Page 13

    10

  • Page 14: Propane Tank Assembly

    Propane tank assembly 1. Attach the regulator to the propane tank by turning the regulator handle clockwise. 2. Turn off the lp supply at the cylinder when the grill is not in use. O pe n clo se g 11.

  • Page 15

    Installation of natural gas regulator 1. The natural gas regulator has been factory installed. Attach the pvc gas hose to the regulator (see drawing below). 2. Adjust the brass elbow so that it is pointing down. 2. Connect the other end of the pvc gas hose to the house gas line using the quick-conne...

  • Page 16

    Natural gas hook-up xxxxxxxxxxxxxxxxxxxxxxxx only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. The installation of this appliance must conform with the local codes or...

  • Page 17

    General although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site. Periodically check the whole system for leaks following the procedures listed below. If the smell of gas is detected at anyti...

  • Page 18: Installer Final Check

    Caution burner adjustments should only be performed after the burners have cooled. Always tighten the locking nut before relighting the burner locking nut gas flow adjustments • if the flames have yellow tips, loosen the locking nut and move the bolt in a clockwise direction. • if the flames are mak...

  • Page 19: Operating Instructions

    General use of the grill and rotisserie each main burner is rated at 12,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter knobs are located on t...

  • Page 20

    Loading the rotisserie skewer 1. Screw the bushing into the skewer rod at the opposite end from the point. 2. Slide and tighten the counter balance apparatus onto the skewer rod approximately 2-4 in. From the bushing. 3. Slide the first meat fork onto the skewer rod prongs toward the food. 4. Center...

  • Page 21: Lighting Instructions

    18 lighting instructions before lighting… inspect the gas supply piping prior to turning the gas “on”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Warning do not use the grill if gas odor is present. Contact customer service at 1-800-554-5799. Leak check the pi...

  • Page 22: Easy Lighting Illustrations

    Easy lighting illustrations rotisserie burner lighting illustration main burner lighting illustration 1. Open the top cover or lid. 1. Press and turn the rotisserie knob to the “on” setting. 2. Press and turn one of the main burner knobs to the “hi” setting. 2. Press the electric igniter button for ...

  • Page 23: Match Lighting The Grill

    20 match lighting the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a lit extended match or ...

  • Page 24: Care & Maintenance

    Care & maintenance stainless steel the grill is made from non-rusting and non- magnetic stainless steel. There are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. To touch up noticeable scratches in the stai...

  • Page 25: Troubleshooting

    Troubleshooting before calling for service if the grill does not function properly, use the checklist below before contacting your dealer for service. You may save yourself the cost of a service call. Problems what to do grill will not light when the control knob is rotated. • check to see if house ...

  • Page 26

    Exploded view model 720-0139-ng 26 31 34 33 29 30 28 27 22 21 25 12 16 20 13 14 11 10 06 07 05 09 08 04 03 02 01 24 23 15 32 17 19 18 23.

  • Page 27: Parts List

    Parts list model 720-0139-ng ref# description q’ty ref# description qty 1 lid, front 1 18 90 degree brass 1 2 heat indicator 1 19 regulator, ng 1 3 name plate 1 20 gas valve, main burner 5 4 heat insulating spacer 2 21 smoke tray bracket 1 5 handle assembly, lid 1 22 electronic ignition 1 6 infrared...

  • Page 28

    Exploded view model 720-0142-lp 26 31 34 33 29 30 28 27 24 18 21 25 12 17 20 13 14 11 10 06 07 05 09 08 04 03 02 01 23 15 19 22 32 16 25.

  • Page 29: Parts List

    Parts list model 720-0142-lp ref# description q’ty ref# description qty 1 lid, front 1 18 regulator, lp 1 2 heat indicator 1 19 90 degree brass 1 3 name plate 1 20 gas valve, main burner 5 4 heat insulating spacer 2 21 smoke tray bracket 1 5 handle assembly, lid 1 22 gas pipe 1 6 infrared burner 1 2...

  • Page 30: Grilling Hints

    Grilling hints the preparation of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. The cooking time is affected by meat type, size, shape of the cut, the temperature of the meat when cooking begins, and the degree of preparation desired. It is reco...

  • Page 31

    Food weight or thickness flame size approximate time speical instructions and tips french fries medium 15 to 30 minutes place in aluminum foil pan. Grill, stirring occasionally. Meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not ...

  • Page 32

    Food weight or thickness flame size approximate time speical instructions and tips ribs medium 30 to 40 minutes grill, turning occasionally. During last few minutes brush with barbecue sauce, turn several times. Pork ham steaks (precooked) 1/2 inch slices high 4 to 8 minutes remove excess fat from e...

  • Page 33: Grill Recipes

    30 bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill an...

  • Page 34

    31 heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, and taco sauce. Beef and lamb kabobs serve 4 ½ lb. Boneless sirloin or beef cut into ...

  • Page 35: Limited Warranty

    Limited warranty model # 720-0139-ng/720-0142-lp stainless steel build-in outdoor gas grill nexgrill industries, inc.Warrants to the original consumer/purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for th...