1. DL manuals
  2. Jenn-Air
  3. Grill
  4. 720-0336
  5. Instructions Manual

Jenn-Air 720-0336 Instructions Manual - Side Shelf Assembly

Manual is about: STAINLESS STEEL

Summary of 720-0336

  • Page 1

    Stainless steel lp gas grill model no.: 720-0336 item no: 242609 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. ® 100 200 300 400 500 600 700 800 for outdoor use only please contact 1-800-554-5799 for assistance do not return to place o...

  • Page 2: Table of Contents

    Table of contents section one safety instructions placement of the grill section two side shelf assembly side shelf handle assembly & battery installation braking system operations & liquid propane cylinder retention system propane regulator hook-up section three gas hook up leak testing installer f...

  • Page 3: Safety Instructions

    Safety instructions warning 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire resulting in death or serious injury could occur. Warning never attempt to use d...

  • Page 4: Safety Instructions

    Safety instructions warning 1. Attach the coupling half (socket) to the gas supply line in accordance with ansi z223.1/nfpa54 fuel gas code. 2. Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 11. After the leak test is completed, rinse the conn...

  • Page 5: Safety Instructions

    Safety instructions warning do not attempt to light the grill if gas odor is present. Contact customer service at 1-800-554- 5799. When lighting, keep your face and body as far away from the burner as possible. Before lighting inspect the gas supply hoses prior to turning on the gas. If there is evi...

  • Page 6: Safety Instructions

    Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58a • csa 1.6a-2006 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building c...

  • Page 7: Safety Instructions

    Safety instructions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place...

  • Page 8: Side Shelf Assembly

    6 side shelf assembly estimated assembly time: approximately 10 minutes required tools: phillips screwdriver (not included) 1. Remove side shelf from inside grill cart. 2. The screws used to attach the side shelf are already screwed into the side of the grill cart. Remove the screws from the side pa...

  • Page 9: Side Shelf Handle Assembl

    7 y screws from the side of the shelf. Rews and tighten. . Insert the b . Replace the ignition button housing after the battery has been installed. Side shelf handle assembl estimated assembly time: approximately 5-7 minutes required tools: phillips screwdriver 1. Remove the four side shelf handle 2...

  • Page 10: Braking System Operations

    8 braking system operations 1. Push to the right to lock. 2. Push to the left to unlock. Liquid propane cylinder retention system 1. Attach the liquid propane gas cylinder to the slide-out tray using the gas cylinder retention screw. Turn the retention screw clockwise to tighten the gas cylinder. 2....

  • Page 11: Propane Regulator Hook-Up

    9 propane regulator hook-up 1. Attach the regulator to the propane cylinder by turning the regulator handle clockwise. 2. If the outdoor cooking appliance is not in use, the gas must be turn off at the supply cylinder. C lo s e o p e n.

  • Page 12: Gas Hook-Up

    Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. Gas hook-up this is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill h...

  • Page 13: Leak Testing

    4. Place the dust cap on the liquid propane other caps or plugs may result in propane cylinder valve outlet when the cylinder is not in leakage. Use. Only install the type of dust cap that is provided with the cylinder valve. The use of leak testing general although gas connections on the grill are ...

  • Page 14: Installer Final Check

    … specified clearance maintained 24 inches from combustible materials/construction. … all internal packaging has been removed. … the hose and regulator are properly connected. … the gas supply shut off valve has been located. … all burners are factory installed. … keep the instruction manual with th...

  • Page 15: Operating Instructions

    Operating instructions general use of the grill and rotisserie each main burner is rated at 15,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter...

  • Page 16: Lighting Instructions

    Note it is normal for the skewer to flex when larger cuts of meat are being cooked. If the meat scrapes on the cooking grids during any part of the rotation, the cooking grids must be removed. Test this clearance before lighting the grill as the cooking grids become hot when the grill is lit. Adjust...

  • Page 18: Lighting Illustrations

    15 lighting illustrations main burner lighting 1. Push and turn rear burner knob slowly to “ignite / on” setting, hold in until the burner is lit up, continue to press and hold for 15 seconds and release. You should hear a “clicking” sound if the electronic ignition system is working properly. The b...

  • Page 19: To Match Light The Grill

    16 to match light the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lightin...

  • Page 20: Grill Lights

    17 grill lights light operation instruction 1. Make sure light’s power switch on the control panel is in the “off” position. 2. Connect power plug to properly grounded outlet. 3. Turn the light’s power switch to “on”. Warning keep any electrical supply cord away from any heated surface. Bulb replace...

  • Page 21

    5. Use a screwdriver to loosen the two screws locking the bulb. Pull out the light bulb and replace with a new bulb. 6. Reverse the instruction from steps 5-1 for installation. Cleaning method follow steps 1-4 above for glass cover removal. Use a damp towel to clean the surface of glass cover. Make ...

  • Page 22: Using The Side Burner

    Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. Warning when lighting, always keep your face and body as far away from the burner as possible. Lighting instru...

  • Page 23

    Care & maintenance of the grill stainless stee grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. Grill rack the easiest way to clean the grill is immediately after cooking is com...

  • Page 24: Troubleshooting

    Troubleshooting when to look for spiders you should inspect the burners at least twice a year or immediately after any of the following conditions occur: 1. The smell of gas in conjunction with burner flames appearing yellow. 2. The grill does not reach temperature. 3. The grill heats unevenly. 4. T...

  • Page 25: Exploded View

    Exploded view 81 80 74 56 55 64 15 58 46 41 61 60 58 59 57 63 44 43 79 38 37 37 36 35 16 34 43 04 05 04 04 05 04 52 32 51( b) 51( a) 13 62 07 51( c) 11 10 4 00 01 02 03 06 08 09 12 14 17 18 23 24 25 26 28 29 30 31 45 42 44 47 48 49 50 22 19 20 67 68 69 70 71 72 66 73 82 78 77 75 39 76 33 21 40 27 52...

  • Page 26: Parts List

    Parts list model no. 720-0336 ref# description qty ref# description qty 01 main lid 1 36 front door, left 1 02 temperature gauge 1 37 door handle 2 03 logo 1 38 front door, right 1 04 temperature gauge heat insulating spacer 4 39 bottom panel, lp 1 05 main lid handle heat insulating cover 2 40 swive...

  • Page 27

    Ref# description qty ref# description qty 71 side burner bowl assembly frame 1 77 axletree base 2 72 side burner grease tray 1 78 wheel 2 73 side panel, right 1 79 front trim panel, right 1 74 gas hose retention clamp 1 80 lighting rod 1 75 foot brake 1 81 lighting rod cover 1 76 wheel axle 1 82 har...

  • Page 28: Grill Cooking Chart

    This jenn-air grill has an infrared side burner – commonly referred to as a “searing” burner. This type of burner produces extreme heat that can be used to “sear” the outside of food thus locking the juices inside. This process is used at many upscale restaurants to improve the flavor of the food. T...

  • Page 29

    Food weight or thickness flame size approximate time special instructions and tips meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not leave hamburgers unattended. A flare-up could occur quickly. Tenderloin, high 8 to 15 minutes p...

  • Page 30

    Food weight or thickness flame size approximate time special instructions and tips breasts well-done medium 30 to 45 minutes marinate with italian dressing fish and seafood steaks grill, turning once. Brush with halibut 3/4 to 1 inch medium to 8 to 15 minutes melted butter, margarine or oil salmon h...

  • Page 31: Grill Recipes

    28 bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill an...

  • Page 32

    29 pound flank steak to ¼ inch thickness or flatten chicken breasts. Mix oil, limejuice and seasonings in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 t...

  • Page 33: Limited Warranty

    Limited warranty model #720-0336 stainless steel outdoor gas grill nexgrill industries, inc.Warrants to the original consumer-purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below...