1. DL manuals
  2. Jenn-Air
  3. Grill
  4. 720-0339
  5. User Manual

Jenn-Air 720-0339 User Manual

Manual is about: STAINLESS STEEL LP GAS GRILL

Summary of 720-0339

  • Page 1

    Stainless steel lp gas grill model no.: 720-0339 item no: 33459 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. ® 350 300 250 200 150 100 50 ¡ ã c ¡ ã f 700 600 500 400 300 200 100 for outdoor use only please contact 1-800-554-5799 for a...

  • Page 2: Table of Contents

    Section one safety instructions ………………………………….. Placement of the grill …………………………….... Section two pie cart assembly ………………………………….. Side burner hose quick-connect ………………... Battery assembly …………………………………... Liquid propane cylinder retention system ……… slide-out tray locking system & propane regulat...

  • Page 3: Safety Instructions

    Safety instructions warning 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire resulting in death or serious injury could occur. Warning never attempt to use d...

  • Page 4: Safety Instructions

    Safety instructions warning 1. Attach the coupling half (socket) to the gas supply line in accordance with ansi z223.1/nfpa54 fuel gas code. 2. Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 13. After the leak test is completed, rinse the conn...

  • Page 5: Safety Instructions

    Safety instructions warning do not attempt to light the grill if gas odor is present. Contact customer service at 1-800-554- 5799. When lighting, keep your face and body as far away from the burner as possible. Before lighting inspect the gas supply hoses prior to turning on the gas. If there is evi...

  • Page 6: Safety Instructions

    Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58a • csa 1.6a-2006 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building c...

  • Page 7: Safety Instructions

    Safety instructions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place...

  • Page 8: Pie Cart Assembly

    Pie cart assembly estimated assembly time: 20 minutes required tools: phillips screwdriver (not included) 1 00 200 3 00 400 500 600 7 00 8 00 fig. 2 800 700 600 500 400 300 200 100 fig. 3 step 2: loosen the side panel top two screws a quarter of the way out. Remove the two screws from the bottom of ...

  • Page 9

    Step 4: re-tighten the top screws. Apply the screws and the washers into the bottom part of the side panel. (fig. 4) 500 400 300 800 700 600 200 100 fig. 4 repeat steps 1-4 for the left side pie cart and serving cart. Then reattach both back panels to the pie carts. (fig. 6) step 5: attach the hose ...

  • Page 10

    8 1. To connect, push back sleeve of socket (fig.1). 2. Hold the plug and insert into the socket (fig.2), release sleeve. 3. Push plug until sleeve snaps forward locking plug in socket (fig.3). (this turns on gas automatically). 4. To disconnect, shut off the gas supply, push sleeve back and pull ou...

  • Page 11: Battery Assembly

    Battery assembly 1 . Unscrew the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed. 9.

  • Page 12

    10 liquid propane cylinder retention system 1. Set the liquid propane gas cylinder into the slide-out tray using the gas cylinder retention screw. Turn the retention screw clockwise to secure the gas cylinder. 2. Make sure tank is level with bottom panel for proper vapor withdrawal. Retention screw.

  • Page 13: Propane Regulator Hook-Up

    11 slide-out tray locking system 1. To lock and unlock the liquid propane gas cylinder tray, press the gas cylinder tray’s top button to lock (figure a). Press the side button to unlock (figure b). Propane regulator hook-up 1. Attach the regulator to the propane cylinder by turning the regulator han...

  • Page 14: Gas Hook-Up

    12 only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill has been p...

  • Page 15: Leak Testing

    2. Turn off the tank valve by turning the control knob clockwise until it stops. 4. Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may r...

  • Page 16: Installer Final Check

    Installer final check specified clearance maintained 24 inches from combustible materials/construction. All internal packaging has been removed. The hose and regulator are properly connected. The unit has been tested and is free of leaks. The gas supply shut off valve has been located. All burners a...

  • Page 17: Operating Instructions

    Operating instructions general use of the grill and rotisserie each main burner is rated at 13,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter...

  • Page 18: Lighting Instructions

    Before lighting… inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Refer to “leak testing” on page 13. Warning do not use the grill if the odor of gas is present. Contact customer service at 1-800-554-5799. Scr...

  • Page 19: Lighting Illustrations

    17 lighting illustrations main & side burner lighting rotisserie burner & sear burner lighting 1. Open the top cover or lid. 1. Push and turn rear burner knob slowly to “ignite / on” setting, hold in until the burner is lit up, continue to press and hold for 15 seconds and release. You should hear a...

  • Page 20: To Match Light The Grill

    18 to match light the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lightin...

  • Page 21: Using The Side Burner

    Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. Warning when lighting, always keep your face and body as far away from the burner as possible. Lighting instru...

  • Page 22

    Care & maintenance of the grill stainless stee grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. Grill rack the easiest way to clean the grill is immediately after cooking is com...

  • Page 23: Troubleshooting

    Troubleshooting when to look for spiders you should inspect the burners at least twice a year or immediately after any of the following conditions occur: 1. The smell of gas in conjunction with burner flames appearing yellow. 2. The grill does not reach temperature. 3. The grill heats unevenly. 4. T...

  • Page 24

    Exploded view model 720-0339 56 68 08 99 95 11 24 28 27 26 25 23 39( c) 113 69 54 57 66 64 11 11 61 11 75 19 21 63 62 52 23 51 50 03 108 112 101 81 18 60 80 79 27 28 12 14 13 05 04 65 29 100 106 92 90 89( b) 55 96 109 110 78 45 26 25 24 22 98 97 93 07 06 02 01 85 86 87 88 91 105 102 103 09 15 16 20 ...

  • Page 25: Parts List

    Parts list model no. 720-0339 ref# description qty ref# description qty 01 ice box handle 2 38 sear igniter wire 1 02 ice box lid 1 39 main igniter wire (a. B. C.) 1 03 ice box 1 40 rotisserie burner 1 04 condiment container lid 4 41 rotisserie burner igniter wire 1 05 condiment container 4 42 rotis...

  • Page 26

    24 ref# description qty ref# description qty 75 rotisserie burner thermocouple 1 95 door hinge bracket, top (side burner cart) 1 76 rotisserie burner thermocouple bracket 1 96 tank tray slide bracket 2 77 main burner bowl assembly 1 97 side burner cart front door 1 78 rotisserie burner flex gas 1 98...

  • Page 27: Grill Cooking Chart

    This jenn-air grill has an infrared side burner – commonly referred to as a “searing” burner. This type of burner produces extreme heat that can be used to “sear” the outside of food thus locking the juices inside. This process is used at many upscale restaurants to improve the flavor of the food. T...

  • Page 28

    French fries medium 15 to 30 minutes place in aluminum foil pan. Grill, stirring occasionally. Food weight or thickness flame size approximate time special instructions and tips meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not ...

  • Page 29

    Poultry broiler/fryer 2 to 3 pounds low or 1 to 1-1/2 hours place skin side up. Grill, turning and brushing frequently with melted butter, margarine, oil or marinade. Food weight or thickness flame size approximate time special instructions and tips breasts well-done medium 30 to 45 minutes marinate...

  • Page 30: Grill Recipes

    28 bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill an...

  • Page 31

    29 heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, and taco sauce. Beef and lamb kabobs serve 4 ½ lb. Boneless sirloin or beef cut into ...

  • Page 32: Limited Warranty

    Limited warranty model # 720-0339 stainless steel outdoor gas grill nexgrill industries, inc.Warrants to the original consumer-purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified belo...