1. DL manuals
  2. Jenn-Air
  3. Grill
  4. 730-0339
  5. Instruction Manual

Jenn-Air 730-0339 Instruction Manual

Manual is about: Stainless Steel Natural Gas Grill

Summary of 730-0339

  • Page 1

    Stainless steel natural gas grill model no.: 730-0339 item no: 127141 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. ® 350 300 250 200 150 100 50 ¡ ã c ¡ ã f 700 600 500 400 300 200 100 for outdoor use only please contact 1-800-554-5799...

  • Page 2: Table of Contents

    Section one safety instructions ………………………………….. Placement of the grill …………………………….... Section two pie cart assembly …………………………………. Side burner hose quick connect ……………….. Battery assembly …………………………………... Installation of natural gas regulator ……………. Section three table of contents section five gas ...

  • Page 3: Safety Instructions

    Safety instructions warning 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire resulting in death or serious injury could occur. Warning never attempt to use d...

  • Page 4: Safety Instructions

    Safety instructions warning 1. Attach the coupling half (socket) to the gas supply line in accordance with ansi z223.1/nfpa54 fuel gas code. 2. Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 11. After the leak test is completed, rinse the conn...

  • Page 5: Safety Instructions

    Safety instructions warning do not attempt to light the grill if gas odor is present. Contact customer service at 1-800-554- 5799. When lighting, keep your face and body as far away from the burner as possible. Warning do not store or use gasoline or other flammable vapors and liquids in the vicinit...

  • Page 6: Safety Instructions

    Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58a • csa 1.6a-2006 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building c...

  • Page 7: Safety Instructions

    Safety instructions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place...

  • Page 8: Pie Cart Assembly

    Pie cart assembly estimated assembly time: 20 minutes required tools: phillips screwdriver (not included) 800 700 600 500 400 300 200 100 step1: unscrew the back panel from the pie cart, and then remove the back panel. (fig.1) step 3: align the pie cart with the heads of the side panel top screws, a...

  • Page 9: Pie Cart Assembly

    Pie cart assembly step 5: attach the hose from main burner manifold thru the rubber hole on the main body’s side panel and side burner cart’s side panel and to the side burner’s manifold. 100 200 300 400 500 600 700 f ¡ ã c ¡ ã 50 100 150 200 25 0 300 3 50 repeat steps 1-4 for the left side pie cart...

  • Page 10

    8 1. To connect, push back sleeve of socket (fig.1). 2. Hold the plug and insert into the socket (fig.2), release sleeve. 3. Push plug until sleeve snaps forward locking plug in socket (fig.3). (this turns on gas automatically). 4. To disconnect, shut off the gas supply, push sleeve back and pull ou...

  • Page 11: Battery Assembly

    Battery assembly 1. Remove the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed. 9.

  • Page 12

    10 installation of natural gas regulator 1. Connect the pvc natural gas hose to the house gas supply line using the quick-connect fitting as shown in figure a. 2. Perform the leak test on page 11 before each use. Do not use the grill until all connections have been checked and do not leak. 3. The na...

  • Page 13: Gas Hook-Up

    Gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. Total gas consumption (per hour) of the 730-0339 natural gas grill with all burners set on “hi”: main bu...

  • Page 14: Installer Final Check

    Installer final check 1. Specified clearance maintained 24 inches from combustible materials/construction. 2. All internal packaging has been removed. 3. The hose and regulator are properly connected. 4. The unit has been tested and is free of leaks. 5. The gas supply shut off valve has been located...

  • Page 15: Operating Instructions

    Operating instructions general use of the grill and rotisserie each main burner is rated at 13,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter...

  • Page 16: Lighting Instructions

    14 adjust the counter balance weight to balance the heavier side of the meat and avoid lopsided rotation of the rotisserie motor. Caution when using the rotisserie burner, remove the warming rack. High heat from the burner may cause the warming rack to bend. Before lighting… inspect the gas supply h...

  • Page 17

    14.

  • Page 18: Lighting Illustrations

    15 lighting illustrations main & side burner lighting rotisserie burner, sear burner or side burner lighting 1. Push and turn rear burner knob slowly to “ignite / on” setting, hold in until the burner is lit up, continue to press and hold for 15 seconds. You should hear a “clicking” sound if the ele...

  • Page 19: To Match Light The Grill

    16 to match light the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lightin...

  • Page 20: Using The Side Burner

    Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present. Warning when lighting, always keep your face and body as far away from the burner as possible. Lighting instru...

  • Page 21

    Care & maintenance of the grill stainless steel grease specks can gather and bake onto the surfaces of the stainless steel, giving the appearance of rust. For removal, use an abrasive pad with a stainless steel cleaner. Grill rack the best time to clean the grill is immediately after cooking is comp...

  • Page 22

    19.

  • Page 23: Troubleshooting

    Troubleshooting when to look for spiders you should inspect the burners at least twice a year or immediately after any of the following conditions occur: 1. The smell of gas in conjunction with burner flames appearing yellow. 2. The grill does not reach temperature. 3. The grill heats unevenly. 4. T...

  • Page 24

    Exploded view model 730-0339 54 08 99 96 98 95 65 66 19 21 68 61 60 50 23 03 108 102 79 18 58 78 77 27 28 12 14 13 05 04 63 32 29 107 90 88 87( b) 53 109 110 59 76 45 26 25 24 22 94 93 91 07 06 02 01 83 84 85 86 89 105 103 104 09 15 16 17 20 37 80 75 71 70 69 43 44 46 48 49 51 57 36 35 32 30 11 97 6...

  • Page 25: Parts List

    Parts list model no. 730-0339 ref# description qty ref# description qty 01 ice box handle 2 37 sear burner 1 02 ice box lid 1 38 sear igniter wire 1 03 ice box 1 39 main igniter wire (a. B. C.) 1 04 condiment container lid 4 40 rotisserie burner 1 05 condiment container 4 41 rotisserie burner ignite...

  • Page 26

    Ref# description qty ref# description qty 73 rotisserie burner thermocouple 1 93 side burner cart front door 1 74 rotisserie burner thermocouple bracket 1 94 side burner cart door handle 1 75 main burner bowl assembly 1 95 ng brass connector 1 76 rotisserie burner flex gas 1 96 regulator, ng 1 77 ma...

  • Page 27: Grill Cooking Chart

    This jenn-air grill has an infrared side burner – commonly referred to as a “searing” burner. This type of burner produces extreme heat that can be used to “sear” the outside of food thus locking the juices inside. This process is used at many upscale restaurants to improve the flavor of the food. T...

  • Page 28

    French fries medium 15 to 30 minutes place in aluminum foil pan. Grill, stirring occasionally. Food weight or thickness flame size approximate time special instructions and tips meats beef hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not ...

  • Page 29

    Poultry broiler/fryer 2 to 3 pounds low or 1 to 1-1/2 hours place skin side up. Grill, turning and brushing frequently with melted butter, margarine, oil or marinade. Food weight or thickness flame size approximate time special instructions and tips breasts well-done medium 30 to 45 minutes marinate...

  • Page 30: Grill Recipes

    26 steaks bstitute catfish, halibut or cod aks over r s in th parsley. E, melted - to elled & divined s auce and next six ingredients. Pour over eafood. Toss to coat. Cover, frigerate 2 hours. S skewers on minutes, basting and round black pepper. Lly. Serve with mixed salad, ith ded cheddar cheese e...

  • Page 31

    27 r ile ce wing matoes, lamb cut into 1” d e. Ately thread water nd. Heat oo thick, add 1 tbs. E with kabobs. Ely chopped onion clove garlic, minced e 0 minutes. Remove from grill and cool d chop s. Style s or drumsticks rt the eat for 40 minutes nally with the remainder mixture. Serve with d lemon...

  • Page 32: Limited Warranty

    Limited warranty model # 730-0339 stainless steel outdoor gas grill nexgrill industries, inc.Warrants to the original consumer-purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified belo...