1. DL manuals
  2. Jenn-Air
  3. Grill
  4. 740-0141
  5. Manual

Jenn-Air 740-0141 Manual - Safety Instructions

Manual is about: STAINLESS STEEL BUILT-IN

Summary of 740-0141

  • Page 1

    Stainless steel built-in gas grill model #s: 750-0141 / 740-0141 lowe’s item #s: 168932 / 168931 jenn-air is a trademark of the maytag corporation and is used under license to lowe’s companies, incorporated. 800 700 600 500 400 300 200 100 for outdoor use only a22y07-3 please contact 1-800-554-5799 ...

  • Page 2: Safety Instructions

    Safety instructions warning 1. Do not store spare liquid propane cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire resulting in death or serious injury could occur. Warning never attempt to use d...

  • Page 3: Safety Instructions

    Safety instructions warning when lighting, keep your face and hands as far away from the grill as possible. Warning failure to properly place the burner over the orifice could cause a fire to occur behind and beneath the valve panel, thereby damaging the grill and making it unsafe to operate. Warnin...

  • Page 4: Safety Instructions

    Safety instructions warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58a csa1.6a-2006 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building code...

  • Page 5: Placement of The Grill

    Warning do not install this unit into combustible enclosures. There should be a minimum clearance of at least 24 inches from all sides to combustible materials. When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cau...

  • Page 6: Grill Specifications

    Grill specifications description 750-0141 and 740-0141 cutout width 33 in. (83.82 cm) cutout depth 21 in. (53.34 cm) cutout height 11 in .(27.94 cm) natural gas: standard residential 1/2 in. (1.3 cm) id gas service line. Natural gas hose/regulator assembly included with quick-connect fitting for att...

  • Page 7

    Island construction island cutout dimensions for jenn-air 4 burner lp and ng built-in grills: width 33 inches (83.82 cm) depth 21 inches (53.34cm) height 11 inches (27.94 cm) tank bolt dimension for jenn-air 4 burner lp tank bolt type: 1/2 inches-12unc (1.27 cm) tank bolt length: 9/20 inches (11.5 c...

  • Page 8

    Island construction 740-0141 measurements shown are for attaching the lp regulator to the island. Measurements shown are for attaching the ng regulator to the island. 7 750-0141 1 7/16 in.(3.65cm) 10 1 /8 in . (2 5.7 2cm ) 13/16 in.(2.06cm) 16 7/8 in. (42.86) 16 7/ 8 i n. (4 2. 86) 7 7/8 in.(20cm) 1...

  • Page 9

    Front view for built-in opening 32 in.(81.28cm) 6 in.(15.24cm) 8 in.(20.32cm) 10 7/8 in.(27 .62cm) 350 300 250 200 150 100 50 ° c ° f 700 600 500 400 300 200 100 3 in.(7.62cm) 9 in .(22.86cm) 1 7/8 in.(4.76cm) 2 in.(5.08cm) 2 in.(5.08cm) the following are minimum dimensions necessary to install the ...

  • Page 10

    Side view for built-in opening 23 1 /2 in.(59 .69 cm) 12 3/ 8 in.(31 .4 3c m) 24 3/4 in.(62.86cm) 26 1/8 in.(66.36cm) 10 7/8 in.(27 .6 2c m) 8 3/8 in.(21 .2 7c m) 9 in.( 22.86cm) a minimum of 24 in.(60.96cm)is required between the back of the grill and any combustible material. To ensure proper comb...

  • Page 11: Battery Installation

    Battery installation 1. Unscrew the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed. 800 700 600 500 400 300 200 100 10

  • Page 12: Lp Gas Hook-Up

    Lp gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply. Total gas cons...

  • Page 13: Propane Tank Assembly

    Propane tank assembly fig. 1 13 800 700 60 0 5 00 400 30 0 2 00 100 make sure the lp regulator is located under the island hole as shown in fig. 1. 800 700 600 500 400 300 200 100 fig. 2 use the 4 screws and clamp provided to attach the brass connector to the island as shown in fig. 2. The brass con...

  • Page 14

    Installation of natural gas regulator 1. The natural gas regulator has been factory installed. Attach the pvc gas hose to the regulator (see drawing below). 2. Adjust the brass elbow so that it is pointing down. 3. Connect the other end of the pvc gas hose to the house gas line using the quick-conne...

  • Page 15

    Natural gas hook-up xxxxxxxxxxxxxxxxxxxxxxxx only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. The installation of this appliance must conform with the local codes or...

  • Page 16

    General although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site. Periodically check the whole system for leaks following the procedures listed below. If the smell of gas is detected at anyti...

  • Page 17: Installer Final Check

    Installer final check … specified clearance maintained 24 inches from combustible materials/construction. All internal packaging has been removed. All the burners are factory installed. Model 750-0141 the hose and regulator are properly connected. The unit has been tested and is free of leaks. The g...

  • Page 18: Operating Instructions

    General use of the grill and rotisserie each main burner is rated at 12,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel flame tamers. The igniter knobs are located on t...

  • Page 19

    Loading the rotisserie skewer 1. Screw the bushing into the skewer rod at the opposite end from the point. 2. Slide and tighten the counter balance apparatus onto the skewer rod approximately 2-4 in. From the bushing. 3. Slide the first meat fork onto the skewer rod prongs toward the food. 4. Center...

  • Page 20: Lighting Instructions

    19 warning when lighting, keep your face and hands as far away from the grill as possible. Lighting instructions before lighting… inspect the gas supply piping prior to turning the gas “on”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Warning do not use the gri...

  • Page 21: Lighting Illustrations

    Lighting illustrations main burner lighting rotisserie burning lighting 4. Push and turn the rear burner knob to the “ignite/on” setting and hold in for 5 seconds while holding, push electronic ignition button, until burner is lit. Once lit, release electronic ignition button, and still hold in the ...

  • Page 22: Match Lighting The Grill

    Match lighting the grill if the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting r...

  • Page 23: Care & Maintenance

    Care & maintenance stainless steel warning failure to properly place the burner over the orifice could cause a fire to occur behind and beneath the valve panel, thereby damaging the grill and making it unsafe to operate. Grease specks can gather and bake onto the surfaces of the stainless steel, giv...

  • Page 24: Trouble Shooting

    Trouble shooting before calling for service if the grill does not function properly, use the checklist below before contacting your dealer for service. You may save yourself the cost of a service call. Problems what to do grill will not light when the control knob is rotated. • check to see if house...

  • Page 25

    Exploded view model 750-0141 01 03 02 05 14 41 40 39 38 11 12 08 28 27 24 13 10 09 37 17 18 34 36 22 15 16 26 25 20 21 31 30 29 33 19 42 35 23 32 80 0 70 0 600 500 40 0 300 2 00 1 00 04 04 04 04 24.

  • Page 26: Parts List

    Parts list model 750-0141 ref# description qty ref# description qty 1 main lid 1 22 grease tray 1 2 temperature gauge 1 23 lighting rod cover 1 3 logo 1 24 lighting rod 1 4 main lid handle heat insulating spacer 4 25 gas valve clamp 5 5 main lid handle 1 26 main manifold 1 6 rear baffle 1 27 rotisse...

  • Page 27

    Exploded view model 740-0141 01 03 02 05 14 38 37 36 35 11 12 08 30 29 28 27 24 13 10 09 34 17 18 04 04 31 33 22 15 16 26 25 20 21 19 42 39 23 32 41 8 00 7 00 600 500 4 00 300 200 100 40 04 04 26.

  • Page 28: Parts List

    Parts list model 740-0141 ref# description q’ty ref# description qty 1 main lid 1 22 grease tray 1 2 temperature gauge 1 23 lighting rod cover 1 3 logo 1 24 lighting rod 1 4 main lid handle heat insulating spacer 4 25 gas valve clamp 5 5 main lid handle 1 26 main manifold 1 6 rear baffle 1 27 rotiss...

  • Page 29: Grilling Hints

    Grilling hints the preparation of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. The cooking time is affected by meat type, size, shape of the cut, the temperature of the meat when cooking begins, and the degree of preparation desired. It is reco...

  • Page 30

    Food weight or thickness flame size approximate time speical instructions and tips french fries medium 15 to 30 minutes place in aluminum foil pan. Grill, stirring occasionally. Meats hamburgers 1/2 to 3/4 inch medium 10 to 18 minutes grill, turning once when juices rise to the surface. Do not leave...

  • Page 31

    Food weight or thickness flame size approximate time speical instructions and tips ribs medium 30 to 40 minutes grill, turning occasionally. During last few minutes brush with barbecue sauce, turn several times. Ham steaks (precooked) 1/2 inch slices high 4 to 8 minutes remove excess fat from edge. ...

  • Page 32: Grill Recipes

    Bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice sprig of parsley lemon wedges *you can substitute catfish, halibut or cod for salmon. Preheat the bbq brush the steaks with oil and season with salt and pepper. Place on bbq grill and c...

  • Page 33

    Heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, and taco sauce. Beef and lamb kabobs serve 4 ½ lb. Boneless sirloin or beef cut into 1” ...

  • Page 34: Limited Warranty

    Limited warranty model # 750-0141/740-0141 stainless steel build-in outdoor gas grill nexgrill industries, inc.Warrants to the original consumer/purchaser of each jenn-air outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the peri...

  • Page 35: Table of Contents

    Section one safety instructions placement of the grill section two model specifications island construction front view of opening side view of opening section three battery installation lp gas hook up propane tank assembly installation of ng regulator natural gas hook-up section four leak testing in...