Jgw8130dd* 16022514 revision 0 may 2004 gas wall oven this base manual covers general information refer to individual technical sheet for information on specific models this manual includes, but is not limited to the following: service this manual is to be used by qualified appliance technicians onl...
2 16022514 rev. 0 © 2004 maytag services important notices for servicers and consumers maytag will not be responsible for personal injury or property damage from improper service procedures. Pride and workmanship go into every product to provide our customers with quality products. It is possible, h...
© 2004 maytag services 16022514 rev. 0 3 table of contents important information .................................................... 2 safety information safety practices for servicer .................................... 5 servicing .....................................................................
4 16022514 rev. 0 © 2004 maytag services as with all appliances, there are certain rules to follow for safe operation. Verify everyone who operates the oven is familiar with the operations and with these precautions. Use appliance only for its intended purpose as described. Pay close attention to th...
© 2004 maytag services 16022514 rev. 0 5 safety information safety practices for servicer safe and satisfactory operation of gas wall ovens depends upon its design and proper installation. However, there is one more area of safety to be considered: servicing listed below are some general precautions...
6 16022514 rev. 0 © 2004 maytag services safety information oven 1. Use care when opening door—let hot air or steam escape before removing or replacing food. 2. Do not heat unopened food containers—build-up of pressure may cause container to burst and result in injury. 3. Keep oven vents ducts unobs...
© 2004 maytag services 16022514 rev. 0 7 safety information • only certain types of glass/ceramic, earthenware, or other glazed utensils are suitable for oven use. Unsuitable utensils may break due to sudden temperature change. • use care when opening oven door. Let hot air or steam escape before re...
8 16022514 rev. 0 © 2004 maytag services safety information electrical requirements 120-volt, 60 hertz, 15 amp, individual circuit which is properly grounded, polarized and protected by a circuit breaker or fuse. Extension cord due to possible pinching during installation, extension cords should not...
© 2004 maytag services 16022514 rev. 0 9 product safety devices safety devices and features have been engineered into the product to protect consumer and servicer. Safety devices must never be removed, bypassed, or altered in such a manner as to defeat the purpose for which they were intended. Liste...
General information 10 16022514 rev. 0 © 2004 maytag services cooking nomenclature j g w 8 1 3 0 d d w brand a amana c magic chief g graffer & sattler h hardwick j jenn-air m maytag n norge u universal y crosley product type a accessory/cartridge c cooktop updraft/countertop d downdraft cooktop or w...
General information © 2004 maytag services 16022514 rev. 0 11 rating label model numbers are recorded on the rating label. Rating label is located on the lower front right corner of the oven frame. It can be seen by opening the oven door. Before ordering parts, write down the correct model and seria...
General information 12 16022514 rev. 0 © 2004 maytag services specifications refer to individual technical sheet for information regarding specifications. Model identification complete registration card and promptly return. If registration card is missing: • for maytag product call 1-800-688-9900 or...
Troubleshooting procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. © 2004 maytag services 16022514 rev. 0 13 problem possible cause correction no oven operation in bake or broil. No voltage to c...
Troubleshooting procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. 14 16022514 rev. 0 © 2004 maytag services problem possible cause correction oven light does not operate. Failed oven lamp ........
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. © 2004 maytag services 16022514 rev. 0 15 illustration component test procedure results oven light socket test continuity of receptacle...
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. 16022514 rev. 0 © 2004 maytag services 16 illustration component test procedure results pressure regulator verify gas pressure (wcp). I...
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. © 2004 maytag services 16022514 rev. 0 17 illustration component test procedure results h1 controlled oven temperature adjustment press...
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. 16022514 rev. 0 © 2004 maytag services 18 jenn-air matrix control panel assembly continuity is indicated as follows: 1000 – 6600 Ω for ...
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. © 2004 maytag services 16022514 rev. 0 19 “quick test” mode for electronic range control follow procedure below to use the quick test m...
Testing procedures ! Warning to avoid risk of electrical shock, personal injury, or death, disconnect power to oven before servicing, unless testing requires power. 16022514 rev. 0 © 2004 maytag services 20 diagnostic code checking code description when checked debounce 3d11 sensor open cook or clea...
Warning ! Disassembly procedures © 2004 maytag services 16022514 rev. 0 21 to avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Caution ! To avoid risk of personal injury or property damage this unit requires a tw...
Warning ! To avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Disassembly procedures 22 16022514 rev. 0 © 2004 maytag services oven door latch 1. Remove control panel assembly, see “control panel assembly” proced...
Warning ! Disassembly procedures © 2004 maytag services 16022514 rev. 0 23 to avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Oven door hinge note: requires removal of unit from cutout opening. 1. Turn off power...
Warning ! To avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Disassembly procedures 24 16022514 rev. 0 © 2004 maytag services oven burner ignitor 1. Shut off electrical power and gas supply to oven. 2. Remove ov...
Warning ! Disassembly procedures © 2004 maytag services 16022514 rev. 0 25 to avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Door assembly.
Warning ! To avoid risk of electrical shock, personal injury, or death, disconnect electrical power and shut-off gas supply to unit before servicing. Disassembly procedures 26 16022514 rev. 0 © 2004 maytag services this page intentionally left blank.
© 2004 maytag services 16022514 rev. 0 a–1 appendix a.
A–2 16022514 rev. 0 © 2004 maytag services installation instructions pmb`f^i t^okfkd lkiv nr^ifcfba mboplkkbi pelria fkpq^ii lo pbosf`b qefp o^kdbk ob^a ¥p^cbqv fkpqor`qflkp³ fk rpb c `^ob _llh _bclob rpfkd o^kdbk fjmolmbo fkpq^ii^qflki ^agrpqjbkqi ^iqbo^qflki pbosf`bi j^fkqbk^k`b lo rpb lc lsbk `^k...
© 2004 maytag services 16022514 rev. 0 a–3 installation instructions ,qvwdoodwlrq a wiring diagram is enclosed in the envelope with this booklet; also there is a diagram glued to the unit, behind control panel. Check the oven model number plate to see if the oven is approved for installation in mobi...
A–4 16022514 rev. 0 © 2004 maytag services installation instructions ,qvwdoodwlrq afj ^w if cabinet doors are provided above the gas wall oven, a minimum spacing of 3-3/4² is required for 1/2 ² thick doors. Thicker doors required an additional 1² (inch) added to the 3-3/4² for each 1/4² additional t...
© 2004 maytag services 16022514 rev. 0 a–5 installation instructions &rqqhfwlqj wkh 2yhq b p the appliance, when installed, must be electrically grounded in accordance with local codes or, in the absence of local codes, with the national electrical code, ansi/nfpa 70. In canada the oven ...
A–6 16022514 rev. 0 © 2004 maytag services installation instructions 8qlw $gmxvwphqwv t~ l ^ bib`qof` fdkfqflk j _rokbop tfqe bib`qof` dilt _^o a. The bake burner is equipped with an electric control system as well as an electric oven burner ignitor. This control system requires no adj...
© 2004 maytag services 16022514 rev. 0 a–7 installation instructions *dv &rqyhuvlrq d~ all ovens are equipped with interchangeable orifices for natural gas and for lp/propane. To convert the unit will require changing of the orifice plug and hood plus an adjustment to the air shutter on the bur...
A–8 16022514 rev. 0 © 2004 maytag services installation instructions *dv &rqyhuvlrq `
j~ d~ m _rfiqjfk lsbkpw on built-in ovens, remove 1/8 inch pipe plug from side of gas pressure regulator, install 1/8 ² “b” valve, 1/8 inch piece of pipe, connect manometer, make sure main burn...
© 2004 maytag services 16022514 rev. 0 a–9 installation instructions %dnh dqg %urlo %xuqhu /33ursdqh *dv &rqyhuvlrqv `lksboq mobpprob obdri^qlo colj k^qro^i d^p ql imlmolm^kb d^p fjmloq^kqw save all natural gas orifices removed from the appliance for possible future conversion to natural gas. Remove...
A–10 16022514 rev. 0 © 2004 maytag services this page intentionally left blank.
© 2004 maytag services 16022514 rev. 0 b–1 appendix b.
B–2 16022514 rev. 0 © 2004 maytag services use and care information installer: please leave this guide with this appliance. Consumer: please read and keep this manual for future reference. Keep sales receipt and/or canceled check as proof of purchase. Model number __________________________________ ...
© 2004 maytag services 16022514 rev. 0 b–3 use and care information i mportant s afety i nstructions about your appliance caution never store items of interest to children in cabinets above an appliance. Children climbing on the appli- ance door to reach items could be seriously injured. Warning nev...
B–4 16022514 rev. 0 © 2004 maytag services use and care information save these instructions for future reference i mportant s afety i nstructions prepared food warning: follow food manufacturer’s instructions. If a plastic frozen food container and/or its cover distorts, warps, or is otherwise damag...
© 2004 maytag services 16022514 rev. 0 b–5 use and care information control panel o ven c ooking the control panel is designed for ease in programming. The display window on the control shows time of day, timer and oven functions. Control panel shown includes model specific features. (styling may va...
B–6 16022514 rev. 0 © 2004 maytag services use and care information to set the clock: 1. Press the clock pad. • the time of day flashes in the display. 2. Press the appropriate number pads to set the time of day. • colon flashes in the display. 3. Press the clock pad again or wait four seconds. • th...
© 2004 maytag services 16022514 rev. 0 b–7 use and care information o ven c ooking baking notes: • to change the oven temperature during cooking, press bake, then press the autoset 0 or appropriate number pads until the desired temperature is displayed. • to change the oven temperature during prehea...
B–8 16022514 rev. 0 © 2004 maytag services use and care information o ven c ooking delay cook & hold caution do not use delayed baking for highly perishable foods such as dairy products, pork, poultry, or seafood. When using delay, the oven begins to cook later in the day. Set the amount of time tha...
© 2004 maytag services 16022514 rev. 0 b–9 use and care information o ven c ooking broiling to set broil: 1. Press the broil pad. • broil flashes in the display. • set flashes. 2. Press the autoset 0 pad once to set hi broil or twice to set lo broil. • hi or lo will be displayed. Select hi broil (55...
B–10 16022514 rev. 0 © 2004 maytag services use and care information o ven c ooking automatic shut-off/sabbath mode the oven will automatically turn off after 12 hours if you accidentally leave it on. This safety feature can be turned off. To cancel the 12-hour shut-off and run the oven continuously...
© 2004 maytag services 16022514 rev. 0 b–11 use and care information o ven c ooking oven fans the cooling fan will automatically turn on during cleaning, broiling and some baking operations. It is used to help keep internal parts on the control panel cool. The fan will automati- cally turn off when ...
B–12 16022514 rev. 0 © 2004 maytag services use and care information o ven c ooking caution oven racks • do not attempt to change the rack position when the oven is hot. • do not use the oven for storing food or cookware. The oven has two racks. All racks are designed with a lock- stop edge. To remo...
© 2004 maytag services 16022514 rev. 0 b–13 use and care information * brand names for cleaning products are registered trademarks of the respective manufacturers. C are & c leaning self-clean oven caution • it is normal for parts of the oven to become hot during a self-clean cycle. • to prevent dam...
B–14 16022514 rev. 0 © 2004 maytag services use and care information c are & c leaning 5. Press the autoset 0 pad to scroll through the self-cleaning settings. “hvy” (heavy soil, 4 hours) “med” (medium soil, 3 hours) “lite” (light soil, 2 hours) choosing the soil level of the oven automatically prog...
© 2004 maytag services 16022514 rev. 0 b–15 use and care information c are & c leaning part procedure caution cleaning procedures • be sure appliance is off and all parts are cool before handling or cleaning. This is to avoid damage and possible burns. • to prevent staining or discoloration, clean a...
B–16 16022514 rev. 0 © 2004 maytag services use and care information m aintenance oven window to protect the oven door window: 1. Do not use abrasive cleaning agents such as steel wool scouring pads or powdered cleansers as they may scratch the glass. 2. Do not hit the glass with pots, pans, furnitu...
© 2004 maytag services 16022514 rev. 0 b–17 use and care information m aintenance removal of gas appliance gas appliance connectors used to connect this appliance to the gas supply are not designed for continuous movement. Once installed, do not repeatedly move this gas appliance for cleaning or to ...
B–18 16022514 rev. 0 © 2004 maytag services use and care information t roubleshooting for most concerns, try these first. • check if oven controls have been properly set. • check if oven is properly connected to electrical outlet. • check or re-set circuit breaker. Check or replace fuse. • check pow...
© 2004 maytag services 16022514 rev. 0 b–19 use and care information t roubleshooting problem solution oven door will not unlock. • oven may not have cooled to safe temperature after self-cleaning process. • the control and door may be locked. See page 5. Baking results are not as • check the oven t...
B–20 16022514 rev. 0 © 2004 maytag services if you need service what is not covered by these warranties: 1. Conditions and damages resulting from any of the following: a. Improper installation, delivery, or maintenance. B. Any repair, modification, alteration, or adjustment not authorized by the man...
© 2004 maytag services 16022514 rev. 0 c–1 appendix c.
C–2 16022514 rev. 0 © 2004 maytag services conversion instructions *dv &rqyhuvlrq d~ all ovens are equipped with interchangeable orifices for natural gas and for lp/propane. To convert the unit will require changing of the orifice plug and hood plus an adjustment to the air shutter on the burne...
© 2004 maytag services 16022514 rev. 0 c–3 conversion instructions %dnh dqg %urlo %xuqhu /33ursdqh *dv &rqyhuvlrqv `lksboq mobpprob obdri^qlo colj k^qro^i d^p ql imlmolm^kb d^p fjmloq^kqw save all natural gas orifices removed from the appliance for possible future conversion to natural gas. Remove t...
C–4 16022514 rev. 0 © 2004 maytag services conversion instructions 8qlw $gmxvwphqwv t~ l ^ bib`qof` fdkfqflk j _rokbop tfqe bib`qof` dilt _^o a. The bake burner is equipped with an electric control system as well as an electric oven burner ignitor. This control system requires no adjus...