- DL manuals
- Karcher
- Pressure Washer
- HD 4.0/36 P
- Operator's Manual
Karcher HD 4.0/36 P Operator's Manual
Summary of HD 4.0/36 P
Page 1
Hd 4.0 / 36 p 9.139-170 (03/05) english ....................... 2 español .................... 14 français ................... 26.
Page 2
2 high pressure washer operator manual overview ........................................................................ 3 precautions ................................................................... 4 assembly instructions .................................................. 5 operating instructio...
Page 3
3 model hd 4.0 / 36 p overview item description 1 handle 2 trigger gun 3 trigger gun safety lock 4 high pressure hose 5 gas tank 6 spray wand 7 dipstick 8 water inlet with garden hose connector 9 high pressure outlet 10 detergent filter 11 detergent suction tube 12 spark plug 13 hose reel 14 quick c...
Page 4
4 important precautions read first! Important safety instructions warning – when using this product basic precautions should always be followed, including the following: warning – risk of injection or injury – do not direct discharge stream at persons. • read all the instructions before using the ...
Page 5
5 assembly instructions step 1 attach the handle to the frame of the pressure washer. Align holes, insert bolts, and tighten with knobs. Step 2 attach the gun/hose storage handle. Step 3 place the quick connect nozzles in the nozzle holder. Step 4 attach the wand to the spray gun. Step 5 pull the sp...
Page 6
6 operating instructions engine with fixed throttle: move the engine stop switch to the on position. Step 9 pull the starter handle. If the engine fails to start after 3 pulls, squeeze the trigger gun to release pressure, and repeat step. Important! Do not run the engine with a high or low oil level...
Page 7
7 using the accessories warning to avoid serious injury, never point spray nozzle at yourself, other persons or animals danger high pressure in nozzle area. Risk of injury caused by improper locked nozzle. • make sure you hear a ‘click’ when inserting the nozzle tip into the wand. • pull the nozzle ...
Page 8
8 working with detergents detergents can only be applied with the black nozzle. Step 1 install the black quick-connect low pressure nozzle for detergent application at low pressure. Step 2 adjust the filter end of the detergent tube for light (– / 0.15 gpm), or maximum (+ / 0.20 gpm) detergent cover...
Page 9
9 shutting down step 1 remove detergent suction tube from container and insert into 1 gallon of fresh water. Siphon water at low pressure for one minute. Step 2 engine with manual throttle: • move the throttle lever to the slow position. • allow the engine to idle for a few seconds, then move the th...
Page 10
10 cleaning tips deck cleaning (with or without detergent) pre-rinse deck and surrounding area with fresh water. If using kärcher deck & patio cleaner, ( canada: deck + fence wash) place detergent suction tube directly into cleaning solution and apply to surface at low pressure. For best results, li...
Page 11
11 cleaning tips continued continued continued continued continued barbecue grills, outdoor power equipment & gardening tools (with or without detergent) pre-rinse cleaning surface with fresh water. If using kärcher all purpose and vehicle wash or heavy duty degreaser ( canada: pressure wash or de...
Page 12
12 please remove the spark plug cable to prevent accidental ignition of the engine before making any repair. Engine will not start. no gasoline. - fill gas tank. choke is not in correct position. - slide choke lever out to closed position. engine throttle is not in correct position. - slide th...
Page 13
13 troubleshooting continued continued continued continued continued garden hose connection leaks. loose fittings. - tighten fittings. missing/worn rubber washer. - insert new washer. Spray wand leaks. spray wand not properly attached. - attach the wand to the spray gun. Turn the wand collar...