1. DL manuals
  2. Karcher
  3. Pressure Washer
  4. HDS 5.0/30 Ed
  5. Operator's Manual

Karcher HDS 5.0/30 Ed Operator's Manual

Summary of HDS 5.0/30 Ed

  • Page 1

    9.800-081.0 operator’s manual ® to locate your local kärcher shark commercial pressure washer dealer nearest you, visit www.Karchercommercial.Com or www.Karchershark.Com model # order # hds 5.0/30 ed / hp-5030d 1.575-650.0

  • Page 2: Contents

    Contents 2 model number ______________________________ serial number ______________________________ date of purchase ____________________________ the model and serial numbers will be found on a decal attached to the machine. You should record both serial number and date of purchase and keep in a saf...

  • Page 3: Important Safety

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 3 pressure washer operator’s manual introduction & important safety information thank you for purchasing this pressure washer. We reserve the right to make changes at any time without incurring any obligation. Owner/user responsibility: the owner and/or u...

  • Page 4: Important Safety Information

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 4 risk of injection or severe injury to persons. Keep clear of nozzle. Warning warning: high pressure de- veloped by these machines will cause personal injury or equip- ment damage. Keep clear of nozzle. Use caution when ...

  • Page 5: Important Safety Information

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 5 pressure washer operator’s manual important safety information follow the maintenance instructions specified in the manual..

  • Page 6: Component Identification

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 6 component identification pressure washer 3,000 psi maximum (not included) fresh water faucet garden hose (not included) insulated wand (not included) pressure washer to inlet hose inlet connection outlet connection high...

  • Page 7: Installation

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 7 pressure washer operator’s manual place machine in a convenient location providing ample support, drainage and room for maintenance. Remove bolts from pallet to foot bracket. Install rubber feet provided as shown on page 16. Location: the location shoul...

  • Page 8: Operating Instructions

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 8 operating instructions step 1: check fuel tank and pump oil levels on both machines and connect garden hose to pressure washer. Caution: only use fresh water to this machine. Step 2: attach high pressure hose between pr...

  • Page 9: Cleaning Tips

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 9 pressure washer operator’s manual warning: some detergents may be harmful if inhaled or ingested, causing severe nau- sea, fainting or poisoning. The harmful elements may cause property damage or severe injury. Step 1: use detergent designed specificall...

  • Page 10: Shutting Down and Clean-Up

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 10 shutting down and clean-up caution: always store your pressure washer in a location where the temperature will not fall below 32°f (0°c). The pump in this machine is susceptible to permanent damage if frozen. Freeze da...

  • Page 11: Troubleshooting

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 11 pressure washer troubleshooting guide troubleshooting problem possible cause solution burner will not light disconnected or short in electrical wiring all wire contacts should be clean and tight. No breaks in wire. Burner motor thermal protector trippe...

  • Page 12: Troubleshooting

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a pressure washer troubleshooting guide 12 troubleshooting preventative maintenance problem possible cause solution low water temperature improper fuel or water in fuel drain fuel tank and replace with proper fuel. Low fuel pressure increase fuel pressure. ...

  • Page 13: Preventative Maintenance

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 13 pressure washer operator’s manual preventative maintenance 1. Use clean fuel - kerosene, no. 1 home heating fuel or diesel. Clean or replace fuel filter every 100 hours of operation. Avoid water contaminated fuel as it will seize up the fuel pump. De-s...

  • Page 14: Maintenance and Service

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 14 maintenance and service fuel: use clean fuel oil that is not contaminated with water and debris. Replace fuel filter and drain tank every 100 hours of operation. Use kerosene no. 1 or no. 2 heating fuel (astm d306) or ...

  • Page 15: Field Repair Instructions

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 15 pressure washer operator’s manual field repair instructions 10. Align fuel pump coupler on pump shaft/fan motor. Slide pump into fan motor. Secure pump with the three set screws. 11. Test machine (make sure): q blower motor spins q fuel is on q machine...

  • Page 16: Exploded View

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 16 exploded view 98000810-2 22 16 25 46 31 39 33 27 12 31 35 14 10 28 43 41 40 43 29 42 17 11 3 9 37 26 44 15 32 5 7 29 34 18 19 8 23 54 30 48 20 24 21 13 4, 51, 52, 53 29 6 36 38 45 see burner assembly for details 47 1 4...

  • Page 17: Exploded View Parts List

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 17 pressure washer operator’s manual item part no. Description qty 1 9.802-792.0 nut, cage, 3/8" x 12 gauge 4 2 9.802-767.0 screw, 3/8" x 3/4" whiz loc 4 3 9.802-270.0 wheel & tire, 6" steel rim 2 4 8.750-095.0 thermostat, adjustable, 240°f 1 5 9.802-432....

  • Page 18

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a operator’s manual pressure washer 18 98000810-1 burner assembly exploded view 51 46 46 39 35 34 36 41 49 43 45 15 47 52 41 53 38 17 48 55 inlet outlet 31 14 3 7 29 50 50 44 33 32 32 40 28 27 25 24 23 22 10 30 21 19 20 12 13 11 8 6 5 4 9 54 62 57 40 37 58 ...

  • Page 19: Burner Assembly Parts List

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a 19 pressure washer operator’s manual burner assembly parts list item part no. Description qty 1 9.802-831.0 burner, hotbox, 5.5 gpm 115v 1 2 7-46140112 clamp, electrode 1 3 8.717-935.0 electrode 2 4 8.717-872.0 elbow 1 5 8.717-869.0 ring, locking 1 6 8.71...

  • Page 21

    Karcher • hds 650 • 9.800-081.0 • rev. 5/10a pressure washer warranty what this warranty covers all kärcher commercial pressure washers are warranted by kärcher to the original purchaser to be free from defects in materials and workmanship under normal use, for the periods specified below. This limi...

  • Page 22

    ® www.Karchercommercial.Com www.Karchershark.Com form hds 650 # 9.000-081.0 • revised 5/10a • printed in u.S.A. Or mexico.