1. DL manuals
  2. Karcher
  3. Blower
  4. KM 100/40 W
  5. Operating Instructions Manual

Karcher KM 100/40 W Operating Instructions Manual

Manual is about: Spare Parts List

Summary of KM 100/40 W

  • Page 1

    5.960 - 535 a2003105 (08/02) km 100/40 w 750 xl ksm www.Karcher.Com 1.049 - 984.

  • Page 2

    Km 100/40 w operating instructions 3 spare parts list 40 notice d'instructions 15 liste des pièces de rechange 40 instrucciones de servicio 28 lista de piezas de requesto 40

  • Page 3

    English km 100/40 w 3 contents for your safety! 4 general information 4 tip hazard when slope too steep! 4 opening/closing the unit‘s cover 4 power drive 4 to protect our environment 4 caution! Exausted batteries can cause pollution! 4 use only for intended purpose 5 functional description of the sw...

  • Page 4

    English km 100/40 w 4 for your safety! General instructions it is mandatory to read and observe this prior to using the appliance! ♦ notify your sales outlet if during unpacking you detect damage that has occurred in transit. ♦ read the operating instructions of your appliance prior to putting it in...

  • Page 5

    English km 100/40 w 5 utilisation for the intended purpose only ♦ this sweeper is intended for sweeping inside- and outside surfaces. ♦ it corresponds to the l utilisation classification for non-health hazardous dusts. ♦ it is not intended for use on public traffic routes functional description of s...

  • Page 6

    English km 100/40 w 6 commissioning note: initial operation permissible only if the unit‘s cover is closed! Sweeping operation lower sweeping strap. Start-up the machine release parking brake switch-on the engine • master switch setting "1" note: main brush and sweeping strap revolve run the machine...

  • Page 7

    English km 100/40 w 7 pull out debris container. Empty the swept material container. Push-in the swept material container. Hook-in the catch on the swept material container. Close the catch. Instructions for use safety precautions when sweeping never sweep up packing straps, wires or the like as thi...

  • Page 8

    English km 100/40 w 8 sweeping around barriers travel slowly toward the barrier. • sweeping strap yields toward the back. Moving the machine in tight passages pull slowly backwards towards obstacle. • sweeping strap yields toward the front. Discontinuation of usage please observe the following point...

  • Page 9

    English km 100/40 w 9 maintenance by the customer service organisation maintenance after 20 operating hours ♦ first inspection maintenance every 100 operating hours maintenance every 300 operating hours maintenance every 500 hours note: to ensure the guarantee, all service and maintenance work must ...

  • Page 10

    English km 100/40 w 10 safety instructions for the battery ♦ observe the operating instructions ♦ work on batteries is permitted only after instruction by trained personnel ♦ observe the safety instructions of the battery manufacturer. ♦ only when you use batteries and battery chargers prescribed by...

  • Page 11

    English km 100/40 w 11 check the sweep roller lock the hand brake remove the swept material container remove tapes and string from the sweep roller insert the swept material container replacing the sweep roller ♦ replacing it is necessary if the sweeping result is visibly diminished due to worn bris...

  • Page 12

    English km 100/40 w 12 replace sweeping strap ♦ replacing it is necessary if the sweeping result is visibly diminished due to worn bristles. Loosen the fastening nut from the deflector plate relieving the sweeping strap unscrew the tensioning screw in the cover plate completely grip the bristles of ...

  • Page 13

    English km 100/40 w 13 replacing the sealing strips front sealing strip loosen the fastening of the sealing strip replace sealing strip don’t tighten the sealing strip yet adjust the ground clearance of the sealing strip such that there is a spacing of 10 15 mm toward the back align the sealing stri...

  • Page 14

    English km 100/40 w 14 fault indications machine will not start charge the battery check overload fuse notify kÄrcher customer service motor running but machine not moving set the bowden cable to the driving operation mode notify kÄrcher customer service machine remains stationary on inclines select...

  • Page 15

    Km 100/40 w 40 07.2002 1.049-984.0 *usa 4.777-043.0 6.905-587.0 6.365-454.0 7.306-040.0 5.047-121.0 5.731-585.0 6.375-213.0 6.634-196.0 6.634-201.0 4.070-217.0 7.312-291.0 6.303-057.0 6.365-395.0 6.365-411.0 6.365-412.0 6.682-383.0 1.049-921.0 6.654-021.0 1.049-921.0 6.654-068.0 1.049-921.0 6.906-13...