Summary of KM 120
Page 1
Register and win! Www .Kaercher .Com 59637740 03/12 km 120/150 r p km 120/150 r d km 120/150 r lpg.
Page 2
- 1 please read and comply with these original instructions prior to the initial operation of your appliance and store them for later use or subsequent own- ers. Before first start-up it is definitely neces- sary to read the safety indications nr. 5.956-250! – km 120/150 r p = petrol engine – km 120...
Page 3
- 2 hauptverband der gewerblichen berufsg- enossenschaften e.V. (hvbg). Liquified gases (propellants) are butane and pro- pane or a mixture of butane/propane. They are available in special cylinders. The op- erating pressure of these gases depends on the outside temperature. Danger risk of explosion...
Page 4
- 3 figure 1 the sweeper operates using the overthrow principle. – the side brushes (3) clean the corners and edges of the surface, moving dirt and debris into the path of the roller brush. – the rotating roller brush (4) moves the dirt and debris directly into the waste container (5). – the dust ra...
Page 5
- 4 figure 2a 1 operator control unit for waste contain- er and parking brake 2 steering wheel 3 operator console 4 fuses (behind front panel) 5 accelerator pedal, forwards 6 accelerator pedal, reverse 7 lights 8 right side brush 9 left side brush 10 bulk waste flap 11 pedal for raising/lowering bul...
Page 6
- 5 figure 3 danger risk of injury! When open, the cover must be propped up using the retaining rod. Figure 1 operate steering wheel adjustment le- ver and fold steering wheel forwards. Operate seat adjustment lever and slide seat forwards. Figure 2 fold seat bracket to the side. Figure 3 fold out r...
Page 7
- 6 figure 4 1 programme switch 2 switch two-hand operations lift/tilt emptying mechanism 3 button for filter shaker system 4 button for power-operating mode 5 indicator lamp for power-operating mode 6 elapsed-time counter with reset button 7 switch for working lamp 8 horn switch 9 raise/lower waste...
Page 8
- 7 몇 warning do not use a forklift truck to unload the ma- chine as this may damage it. To unload the machine, proceed as follows: cut plastic packing belt and remove foil. Connect battery (see section on care and maintenance) remove the elastic tape fasteners at the stop points. Four indicated flo...
Page 9
- 8 check engine oil level. * only km 120/150 r p and r d: check fill level of fuel tank. * only km 120/150 r lpg: check and ensure that the union nut is fixed prop- erly on the gas tube. * check hydraulics fluid fill level. * check side brush. * check roller brush. * empty waste container. Check ty...
Page 10
- 9 note to achieve an optimum cleaning result, the driving speed should be adjusted to take specific situations into account. Note during operation, the waste container should be emptied at regular intervals. Note when cleaning surfaces, only lower the roller brush. Note also lower side brush when ...
Page 11
- 10 only km 120/150 r p and r lpg: un- screw spark plugs and pour approx. 3 cm³ of oil into the spark plug hole. Crank the engine several times before replacing the spark plug. Screw in the spark plug. Secure sweeper to prevent it rolling away, lock parking brake. Clean the inside and outside of th...
Page 12
- 11 check tension, wear and function of drive belts (v-belt and circular belt). Maintenance following wear: replace sealing strips. Replace roller brush. Replace side brush. For description, see section on mainte- nance work. Note where maintenance is carried out by the customer, all service and ma...
Page 13
- 12 check gas filter in the screw to gas cyl- inder to see if it is dirty. Clean dirty filters with compressed air. Note inspection must be carried out by a quali- fied specialist. Check gas connections, pipes and evaporators using leak-search spray for leaks. Note leaks in the gas cylinder cause f...
Page 14
- 13 open cover and secure it (diag. 3). Km 120/150 r p and r lpg: km 120/150 r d: unscrew wing nut. Remove, check and clean filter car- tridge. Use either a new or cleaned filter car- tridge in the vacuum container. Screw on wing nut. Open cover and secure it (diag. 3). Remove spark-plug connector....
Page 15
- 14 remove side panel. Unscrew and withdraw bolt on the roller brush swinging arm. Pull out roller brush swinging arm. Remove lifting rod assembly from pins. Open quick-release locks and remove cover. Pull out roller brush. Installation position of roller brush in direc- tion of travel push new rol...
Page 16
- 15 danger empty waste container before replacing dust filter. Wear a dust mask when working around the dust filter. Observe safety regu- lations on the handling of fine particulate material. Slightly raise the waste container and tipp it a little. Disconnect filter motor from power sup- ply (1). D...
Page 17
- 16 troubleshooting fault remedy appliance cannot be started sit on the driver seat, activate seat contact mat refuel/ replace gas cylinder open fuel tap/ gas supply check connections and links in petrol or gas lines. Check fuse of the electrical starter, replace if required (only km 120/150 r d) c...
Page 18
- 17 technical specifications km 120/150 r p km 120/150 r d km 120/150 r lpg machine data length x width x height (without driver cabin) mm 1900 x 1230 x 1400 1900 x 1230 x 1400 1900 x 1230 x 1800 length x width x height (with driver cabin) mm 1900 x 1230 x 2010 1900 x 1230 x 2010 1900 x 1230 x 2010...
Page 19
- 18 remove suction hose from holder. Suck in the dirt. Insert the suction hose in the holder. Note after completing the suction, ensure that the tube of the suction hose lies on the floor of the holder. We hereby declare that the machine de- scribed below complies with the relevant basic safety and...
Page 21
– 2 02/12 ae karcher fze, p.O. Box 17416, jebel ali free zone (south), dubai, united arab emirates, +971 4 886-1177, www.Kaercher.Com ar kärcher s.A., urugguay 2887 (1646) san fernando, pcia. De buenos aires +54-11 4506 3343, www.Karcher.Com.Ar at alfred kärcher ges.M.B.H., lichtblaustraße 7, 1220 w...