Summary of PW-F500 series
Page 1
Owner’s manual pw-f500 series.
Page 2
Contents directions/before use 01 safety sign 02 parameters 03 wheelchair structure 04 electromagnetic interference information 05 safety guidelines 06 user 06 caregiver 06 notes when using joystick 07 notes of using in stationary state 07 operating environment 08 applicable road 08 road driving 09 ...
Page 3
Battery instruction 19 install/remove the battery 21 charge the battery 21 over discharge protection device 22 over-current protection device 22 clean the battery socket 22 fold and unfold 23 fold the wheelchair 23 unfold the electric wheelchair 24 malfunction and eliminating methods 25 diagnosis sy...
Page 4
Introduction the wheelchair is driven by e l e c t r i c dc motors, which can be used indoors and outdoors. It is an individual transport for the disabled and the elderly. It is a small- volume, lightweight, foldable and easy to carry electric wheelchair as well as a safe & comfortable electric whee...
Page 5
2 safety sign the signs below can help you identify some warnings, mandatory operation and prohibitive operation of the electric wheelchair. Identifying and understanding them completely is very important. Read and follow the guidance of this manual. The safety warning sign: or a suggestion for a da...
Page 6
3 the right to recycle, the company manufacturer authorized will recycle and pack the products after receiving the user's requirements..
Page 7
4 parameters model pw-f500 folded size 61cm*26cm*77cm (24x11x30 inches) weight capacity 120 kg / 264 lbs motor type brushless dc motor rated power 180 w*2pcs input power dc 24v brake system intelligent electromagnetic brake battery type lithium battery capacity 10 ah/per; 20ah/ 2 pcs output voltage ...
Page 8: Wheelchair Structure
4 wheelchair structure back rest seat battery bag peda l fender motor front wheel.
Page 9
5 electromagnetic interference information caution electromagnetic interference may cause impact on the electric wheelchair, thus reading and understanding the owner’s manual is very important. This chapter will state the problems caused by the electromagnetic interference, so as to help the users t...
Page 10
6 safety guidelines user caution before using this electric wheelchair, you should keep tools and other metal objects from the positive or negative of the battery, if exposed to both ends, it will cause a short circuit and electric shock. 1. Health nursing staff should have been trained and have obt...
Page 11
7 preparations and reduce the risk of accidental injury..
Page 12: Caution
8 4.3 when go straight up and straight down along the steps or stairs near the road, if you are in an angle bend, climb up or down, there may be a risk of falling and turning over. 4.4 when you are going to back tilting, you should remind the user to close the back. 5. The electric wheelchair should...
Page 13
8 operating environment caution this wheelchair cannot be used and placed in heavy rain, snow or ice conditions. 1. Contact with water or excessive moisture can cause electrical failure. Frame, motor and other electric wheelchair parts are not waterproof-designed, it may rust or corrosion from the i...
Page 14
9 road driving caution in most countries and regions, power wheelchair on public roads is illegal. The user must realize that d r i v i n g wheelchair on the road or in the parking lot is dangerous. Please comply with any and all federal, state, and local laws. Consult with your local city. 1. For e...
Page 15
10 4. Don't place the electric wheelchair in the front of other vehicles, so as not to interfere with the other drivers. 5. When getting on or off, if you need to raise up the user with the wheelchair, please grip the edge of the seat frame, do not hold the handrail or back of chair to lift. Balance...
Page 16
11 learn the safest way of moving the body from your professional health nursing staff, and know how to locate your body, and how to support yourself in the process of transportation. Let others help you until you ensure that you can up and down the wheelchair safely by yourself. 1. Move your electr...
Page 17
12 4. Don’t try to pick up the goods between you knees or in front of your body in any cases.(as shown in figure c2) 5. When extending your body, please do not exert pressure, in case of electric wheelchair being overturned and causing serious hurt. 6. Don’t lean on the top of the seat back, to prev...
Page 18
13 1. Attention: threshold is very dangerous. Even a small height change may cause the caster to freeze, lock, or become stuck, and can cause.
Page 19
14 the electric wheelchair to tilt or rollover. Recommended precautionary measures: •dismantling the doorsill or covering the doorsill to allow a smoother transition over obstruction. •install a door with a ramp. 2. When you move the electric wheelchair, please look around the area carefully where y...
Page 20
15 load capacity caution 1. The maximum load of this electric wheelchair is 120 kg (264 pounds). When using it, the load should not exceed the maximum bearing. 2. The backrest’s load capacity is less than 75 kg, please do not press or raised up the backrest. 3. In any case, please don't do any weigh...
Page 21
16 installation instruction safety belt installation caution the safety belt is used to fix user’s body and prevent the user f r o m sliding from the seat. But it can’t protect you in the accident. The safety belt can be adjusted according to the user’s need. The safety belt is used to support the u...
Page 22
16 inserted in the right place, and then fixed the joystick with rubber-head bolt. 2. As shown in figure of d2, aim at the socket, and insert the four-core plugs into the left sockets. The control panel controls electric wheelchair. It consists of the following sections: joystick instruction 1. Powe...
Page 23
17 light flashes intermittently to provide diagnostic information. About the detail, please refer to the following table: there are some diagnosis functions, the diagnosis codes showed can reflect the property of problems. Diagnostic code diagnosis description recommended solving methods flash one t...
Page 24
18 movement operate the joystick forward move the joystick forward backward move the joystick backward right move the joystick to the right left move the joystick to the left stop release the joystick (wheelchair will slow down immediately) use the joystick to control the wheelchair caution when spe...
Page 25: Brake Instruction
19 brake instruction caution after any adjustment, repair or maintenance, please make sure all accessories parts are installed tightly before using, otherwise it may cause harm or damage. Please do not open or close the electromagnetic brake when the power is on. Through the operation of the joystic...
Page 26
20 don't close to flammable materials. Don't g e t close to or exposed to the heat source, such as fires or sparks, etc. Don’t transport the battery with flammable or combustible materials together. There are some corrosive chemicals in battery box, disassembling the battery is prohibited. Do not sh...
Page 27
21 red to green..
Page 28: Caution
22 4. The recommended charging time is about 6 to 8 hours. 5. Charge the battery often, as long as the electric wheelchair is used. Please charge the battery after using until it’s full. If you do not use the electric wheelchair for a long time, please recharge it every 2 months, each time at about ...
Page 29
23 shown in figure g1) 4. Insert the other side of the charger into socket. If the red indicator is light, it shows it’s charging. 5. After the charger indicator light change from red to green, then keep charging for 30 minutes, so as to ensure the full charge. Unplug the external power supply socke...
Page 30: Fold And Unfold
24 fold and unfold caution after any adjustment, repair or maintenance, please make sure that all accessories parts are installed tightly, otherwise it may cause harm or damage. The weight of the wheelchair (with battery) is 21 kgs (46lbs), please use the right way to lift (lift your legs) to avoid ...
Page 31
24 unfold the wheelchair step: 1. One hand holds the scooter backrest frame, the other hand grabs at the battery tube to the outside, and at the same time presses the connecting rod to the largest extent, open the back parts of the electric scooter. (when you press the connecting rod group, make sur...
Page 32
25 malfunction and eliminating methods there is a diagnostic indicator in the control panel. When the light is green, it means this wheelchair has no problem. When there is something wrong with it, it will report by flashing/flickering. If the indicator light indicates, there is something wrong, the...
Page 33
26 2. Flashing code diagnostic code diagnosis description recommended solving methods flash one time slowly hall malfunction of left motor check the welding situation of connection device of the left motor or check the internal hall component flash two times slowly hall malfunction of right motor ch...
Page 34
27 warranty the warranty scope the warranty instruction: guarantee item guarantee period for free remark main frame three years malfunction caused by improper use, man-made destruction or secret conversion, there is no guarantee, or we need charge the maintenance fee. Motor wheel the warranty of red...
Page 35
Guarantee card the warranty card must be handed over to your reseller/dealer or to our customer service department within 30 days after purchase. User name order/ref number address contact number model product number purchasing date month day year serial number supplier (stamp or signature) supplier...
Page 36
K arman h ealthcare i nc. 19255 san jose avenue, city of industry, ca 91748-1418 order.1-800-80-karma / tel.626-581-2235 / fax.626-581-2335 email: customerservice@karmanhealthcare.Com 29.