Keating Of Chicago 2005 Series User Manual

Other manuals for 2005 Series: Manual

Summary of 2005 Series

  • Page 1

    1-800-keating www.Keatingofchicago.Com users manual top side™ cooker series 2005 read and save this manual for future reference. Keep this manual for training new personnel. Important: keep a copy of your bill of sale. The date on the bill establishes the warranty period should service be required. ...

  • Page 2: Warning

    Notice: this operating, installation, and service manual should be given to the user. The operator of the top- side cooker ™ should be familiar with its functions and operation. This manual must be kept in a prominent, easily reachable location near the top-side cooker ™ . Notice: keating of chicago...

  • Page 3: I Introduction

    1 i introduction general keating top-side ™ cookers are designed to give maximum production efficiency, delivering high quality food products. The following design features are incorporated into keating top-side ™ cookers. Standard features stainless steel control panel stainless steel head cover mi...

  • Page 4: III Operating

    2 electrical connection each keating top-side ™ cooking head is equipped with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2), three wire with ground electrical cord. Each cooking head is rated 4000w, 18 amps, single phase at 220 volts and is designed to be connected to its own 208- 240v single phase...

  • Page 5

    3 programming to program the timers, the unit must be in the idle mode. Press and hold the set button for approximately two seconds. The display will show “set”. Press t1, t2 or t3 for the cook time to be programmed. The display will show the current setting for that cook time. Use the up or down bu...

  • Page 6: IV Maintenance

    4 do not hack, chop or hit the surface. You will dent the steel plate under the trivalent chrome. It is even possible to hack two nicks close together and actually tear the miraclean ® surface as the chromium will not stretch. Below is a sketch showing a side view of a cooking head and how the surfa...

  • Page 7

    Installing a cooking seet 1. Raise top-side ™ cooking head completely. 2. Lay the 20'' x 24'' (508mm x 610mm) cooking sheet on the griddle plate with 20'' (508mm) dimension front to back. 3. Lower the top-side ™ cooker head onto the cooking sheet, ensuring that the sheet is centered under the head, ...

  • Page 8: V Service Diagnosis

    6 v service diagnosis a properly adjusted keating top-side ™ cooker, with no load, will cycle “on” approximately every 5 1 / 2 to 6 1 / 2 minutes. Each cycle will last 40 seconds, ensuring that the temperature setting is held within a narrow range. A. Trouble-shooting the following diagnosis is only...

  • Page 9

    Temperature (°f) resistance (ohm) 95 0.30 100 3.80 125 4.60 150 5.50 175 6.40 200 7.90 225 8.40 250 9.70 275 10.90 300 12.40 325 13.80 350 15.10 375 17.00 400 18.40 425 20.20 450 21.30 475 23.30 7 troubleshooting the thermostat temperature reading is incorrect, showing a sensor error, or load led is...

  • Page 10

    8 vi exploded view & parts list ordering parts parts may be ordered by part number by calling 1-800-keating or your local service company. You may also order online at keating’s part store, www.Keatingofchicago.Com. Refer to the keating top-side ™ cooker limited warranty for complete service and ord...

  • Page 11

    Top-side ™ cooking head – manual & auto-lift figure 6-1 part item description qty. Number 1 thermostat temperature probe kit 1 016671 2 cooking head (complete) 1 1-800-keating 3 stop clevis pin, s/s 1 015164 4 swivel bracket wire sleeve (incl. In item 5) 1 --- 5 swivel bracket 1 028181 6 swivel brac...

  • Page 12

    10 part item description qty. Number 1 top-side cooker weld. Auto new arm 1 052115 2 auto top side a0-2 actuator mtg. 1 053991 3 actuator auto topside cooker 24v 1 060463 4 top-side conduit support 1 052287 5 top-side cooker lift arm rod 2 052117 6 top-side cooker head w/ conduit and control panel 1...

  • Page 13

    11 1. Remove the limit switch black plastic cover on the actuator. 2. Turn on the power on unit and push the t1, t2 or t3 button on the timer. The actuator will extend the stroke and lower head. The motor must stop and the stroke should stop extending before it reaches its mechanical stop. This move...

  • Page 14

    12 top-side ™ cooker control panel figure 6-4 part item description qty. Number 1 thermostat 1 056840 thermostat replacement kit for pre 2005 models 1 057138 2 hi-limit control 1 010311 3 hi-limit mounting bracket 1 016654 4 contactor, 50a, 3 pole 1 011184 5 rocker switch, lighted, on/off 1 016689 6...

  • Page 15

    13 top-side ™ cooker power supply box for auto-lift actuators with digital timer - 120vac supply figure 6-5 part item description qty. Number 1 transformer stepdown 24vac 75va 1 056037 2 relay dpdt 24vac 1 030844 3 rectifier 24vdc 1 018321 4 circuit breaker 3a 1 pole 250v 1 053338 5 cord power 6’ 1 ...

  • Page 16

    14 top-side ™ cooker power supply box for auto-lift actuators with digital timer - 240vac supply figure 6-6 part item description qty. Number 1 transformer stepdown 24vac 75va 1 056037 2 relay dpdt 24vac 1 030844 3 rectifier 24vdc 1 018321 4 circuit breaker 3a 1 pole 250v 1 053338 5 cord power 9’ 22...

  • Page 17: Vii Wiring Diagram

    15 vii wiring diagram top-side ™ cooker manual lift wiring diagram figure 6-7 lighted rocker on/off switch green light on top lighted rocker on/off switch green light on bottom or note: angled terminals of switch are always toward control panel bottom..

  • Page 18

    16 notes: 2. All other wires are 18 awg. 1. = 12 awg wire. Rd - red gr - green wire color codes: or - orange wh - white bl - black gy - gray br - brown bu - blue component codes: cr - contactor 220/240vac eo - “element on” light (red) tb - terminal block of - “on/off” switch, lighted (green) th - th...

  • Page 19

    17 top-side ™ cooker auto-lift wiring diagram for electric griddle 208 - 240volt figure 6-9.

  • Page 20

    18 top-side ™ cooker auto-lift wiring diagram for electric griddle 480volt figure 6-10

  • Page 22

    20 service information if you have a service related question call 1-800-keating. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. Keating of chicago, inc. 8901 w. 50th street, mccook, illinois ...