- DL manuals
- Keating Of Chicago
- Kitchen Appliances
- Cooktop
- Service Manual
Keating Of Chicago Cooktop Service Manual
Summary of Cooktop
Page 1
Keep this manual for training new personnel keating of chicago, inc. 1-800-keating www.Keatingofchicago.Com service manual top-side tm cooker manufactured years 1998 - 2004.
Page 2: Table of Contents
I table of contents section i introduction general . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 standard features . . . . . . . . . . . . . . . . . . . . . . . . . .1 standard accessories . . . . . . . . . . . . . . . . . . . . . . .1 cooking head specifications . . . . . . ....
Page 3: Warning
Notice: this operating, installation, and service manual should be given to the user. The operator of the griddle should be familiar with the functions and operation of the griddle. This manual must be kept in a prominent, easily reachable location near the griddle. Notice: keating of chicago, inc. ...
Page 4: I Introduction
1 i introduction general keating top-side tm cookers are designed to give maximum production efficiency, delivering high quality food products. The following design features are incorporated into keating top-side tm cookers. Standard features stainless steel control panel stainless steel head cover ...
Page 5: Warning
2 electrical connection each keating top-side tm cooking head is equipped with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2), three wire with ground electrical cord. No plug is provided. Each cooking head is rated 4000w, 18 amps, single phase at 220 volts (4.37kw, 19 amps, single phase at 230 volts...
Page 6: Warning
3 warning the cooking head will be hot. Use proper care when cleaning the cooking sheets. End of day cleaning: before the griddle is turned off for the day, the cooking sheets should be cleaned as described below. Wear heat resistant gloves for maximum safety during the entire cleaning procedure. 1....
Page 7: Warning
4 proper care should be taken to fully clean the top- side tm cooker on a regular basis. The control panel should be cleaned of any greasy residue with a damp cotton cloth. Remove any residue from the on/off switch and the thermostat knob. Wipe down the cabinet, sides and back on a regular basis. In...
Page 8: V Service Diagnosis
Problem probable cause solution power on light does a. No electricity to top-side tm a. Connect top-side tm cooker to an not come on. Cooker. Approved source of power. B. On/off switch is faulty. B. Replace on/off switch. Element on light does a. Connections to thermostat are a. Check connections an...
Page 9
6 thermostat replacement kit (part #057138) mounting and wiring instructions new thermostat mounting and wiring instructions 1. After removing the old thermostat, drill four larger holes for mounting new housing (see figure a). After drilling holes, remove any metal filings from inside the unit. 2. ...
Page 10
7 figure c: wiring diagram part # 056840
Page 11
8 vi exploded view & parts list ordering parts parts may be ordered by part number by calling 1-800-keating or your local service company. You may also order online at keating’s part store, www.Keatingofchicago.Com refer to the keating top-side™ cooker limited warranty for complete service and order...
Page 12
9 top-side tm cooking head for manufactured years 4/99 - 2004 figure 6-1 part item description qty. Number 1 thermostat temperature probe kit 1 016659 2 cooking head (complete) 1 1-800-keating 3 stop clevis pin, s/s 1 015164 4 swivel bracket wire sleeve (incl. In item 5) 1 --- 5 swivel bracket 1 028...
Page 13
10 to cooking head top-side tm cooker control panel part item description qty. Number 1 thermostat 1 057138 2 thermostat knob 1 no longer available 3 thermostat dial plate 1 no longer available 4 hi-limit control 1 010311 5 hi-limit mounting bracket 1 016654 6 contactor, 50a, 3-pole 1 011184 7 rocke...
Page 14: Vii Wiring Diagram
11 vii wiring diagram top-side tm cooker wiring diagrams.
Page 16
13 service information if you have a service related question call 1-800-keating. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. Keating of chicago, inc. 8901 west 50th street, mccook, illinoi...