1. DL manuals
  2. Kenmore
  3. Water System
  4. 625.381560
  5. Owner's Manual

Kenmore 625.381560 Owner's Manual

Manual is about: Reverse Osmosis Drinking Water System

Summary of 625.381560

  • Page 1

    Part no.7288057 (rev. E 10/27/06) • warranty • installation • how it works • care of • specifications • repair parts reverse osmosis system sears, roebuck and co., 3333 beverly road, hoffman estates, il 60179 usa www.Kenmorewater.Com repair or parts ? Call toll free 1-800-366-7278 see back cover for...

  • Page 2

    2 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com one year full warranty on reverse osmosis system when installed, operated and maintained according to all instructions supplied with the product, if this reverse osmosis system fails due to a defect in material or work...

  • Page 3

    3 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com table of contents safety guides unpack and check shipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 what ...

  • Page 4

    4 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com unpack and check your carton inspect shipment your reverse osmosis drinking water system is shipped complete in one carton. Remove all items from your shipping carton. Check all items against the packing list below. No...

  • Page 5

    5 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com what your reverse osmosis system will do plan your installation tools needed adjustable wrench phillips screwdriver drill & drill bits, if required large adjustable jaw pliers or pipe wrench flathead screwdriver tape m...

  • Page 6

    6 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com plan your installation figure 2 figure 3 cold water supply sink drain p-trap hot cold storage tank typical under sink installation typical remote installation all install parts included in package. Drain adapter for re...

  • Page 7

    7 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com overview and site preparation figure 4 overview there are seven easy steps to installing your drinking water system. They are as follows: step 1 - install cold water supply fitting step 2 - install drain adapter step 3...

  • Page 8

    8 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 1 - install supply water fitting choose type of water fitting to install locate the cold water line in the sink cabinet. It is recom- mended, but not required, that the cold water line be soft water. You can use t...

  • Page 9

    9 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 2 - install ro drain under sink figure 6 figure 7 figure 8 introduction a suitable drain point is needed for the reject water from the reverse osmosis filter. You have two options to choose from: • install the dra...

  • Page 10

    10 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 2 - install ro drain in remote location install a remote drain point and air gap (remote location) you can also run the drain tubing to an existing drain in the house. A floor drain, laundry tub, standpipe, sump,...

  • Page 11

    11 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 3 - install ro filter assembly step 4 - install storage tank figure 11 figure 12 install reverse osmosis filter assembly the reverse osmosis filter assembly is mounted on hanger washers. The hanger washers allow ...

  • Page 12

    12 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 5 - install ro faucet select location of reverse osmosis faucet mounting hole you will need to select the location of the reverse osmosis faucet. You have three options to choose from: • use the existing sink top...

  • Page 13

    13 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 5 - install ro faucet figure 14 figure 15 5. Locate the 1/4" red tubing. One end is connected to the ro filter assembly. See figure 21. Locate the loose end. A. Route red tube through countertop to faucet. B. Cut...

  • Page 14

    14 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 6 - connect tubes how to cut and connect the tubes your reverse osmosis water system includes push-in fittings for quick tubing connection. Review the follow- ing instructions before connecting the tubes in the n...

  • Page 15

    15 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 6 - connect tubes figure 21 connect yellow tube to storage tank 1. Locate the yellow tube. One end is attached to the reverse osmosis filter assembly. 2. Run the other end of the yellow tube to the fitting on top...

  • Page 16

    16 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 7 - sanitize, test and purge system sanitize the system sanitizing is recommended immediately after installation of the reverse osmosis system. It’s also recommended after servicing inner parts. It is important t...

  • Page 17

    17 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com step 7 - sanitize, test and purge system figure 23 pressure test the system note: complete the sanitizing procedures on the pre- ceding page before pressure testing. To pressure test the system, complete the following...

  • Page 18

    18 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com how your ro water system works how your reverse osmosis system works introduction: your reverse osmosis (ro) drinking water system uses your household water pressure to force water through three filters. Minerals and ...

  • Page 19

    19 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com how your ro water system works prefilter product water storage ro membrane check valve drain flow control automatic shutoff water in postfilter product water faucet air gap gravity drain red yellow blue green product ...

  • Page 20

    20 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com maintenance prefilter/postfilter maintenance note: it is recommended to replace the battery, prefilter and postfilter cartridges at least every 6 months of prod- uct water use. Replace more often if they begin to plug...

  • Page 21

    21 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com maintenance figure 26 figure 27 figure 28 figure 29 flow control the flow control is vital for proper operation of the reverse osmosis membrane cartridge. See figure 26. The control keeps water flowing through the mem...

  • Page 22

    22 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com specifications supply water pressure limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40-100 psi (280-689 kpa) supply water temperature limits . . . . . ....

  • Page 23

    23 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com notes.

  • Page 24

    24 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com problem: chlorine taste and/or odor in the ro product water. Cause: the level of chlorine in your water supply exceeds maximum limits, and has destroyed the reverse osmosis mem- brane. Correction: if the water supply ...

  • Page 25

    25 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com troubleshooting problem: water leaking from faucet airgap hole. Cause: drain side of faucet airgap (3/8” black tub- ing) plugged, restricted or incorrectly con- nected to drain point. Correction: inspect and eliminate...

  • Page 26

    26 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com exploded view 18 17 14 13 15 16 12 11 1/4” red tubing 10 20 1 2 3 4 o-ring seal collet 8 9 7 5 6 manifold housing push-in fittings 19.

  • Page 27

    27 questions? Call the kenmore water line 1-800-426-9345 or visit kenmorewater.Com parts list key no. Part no. Description 1 9006062 screw (2 req’d) 2 9041700 hanger washer (2 req’d) 3 7115432 o-ring (2 req’d) 4 7272658 check valve 5 7273337 screw (6 req’d) 6 7281330 washer (4 req’d) 7 7273345 autom...

  • Page 28

    ® registered trademark / t m trademark / sm service mark of sears brands, llc ® marca registrada / t m marca de fábrica / sm marca de servicio de sears brands, llc mc marque de commerce / md marque déposée de sears brands, llc © sears brands, llc get it fixed, at your home or ours! Your home for rep...