1. DL manuals
  2. L.B. White
  3. Heater
  4. CP350AK
  5. Owner's Manual

L.B. White CP350AK Owner's Manual

Other manuals for CP350AK: Owner's Manual
Manual is about: HIGH PRESSURE KEROSENE PORTABLE FORCED AIR HEATER (with Thermostat)

Summary of CP350AK

  • Page 1

    350 side pv 026 model number: cp350ak heater size: 350,000 btu/hr arl logo g 004 ® owner’s manual tradesman k350 high pressure kerosene portable forced air heater (with thermostat) important read and understand this manual before assembling, starting, or servicing heater. Improper use of heater can ...

  • Page 2: Contents

    2 104042 contents section page safety information .................................................................................... 2 product identification ............................................................................... 4 unpacking ...................................................

  • Page 3: Safety

    3 104042 safety information • use only kerosene or no. 1 fuel oil to avoid risk of fire or explosion. Never use gasoline, naphtha, paint thinners, alcohol, or other highly flammable fuels. • fueling a) personnel involved with fueling shall be qualified and thoroughly familiar with the manufacturer's...

  • Page 4: Product

    4 104042 product identification upper shell power cord thermostat fuel cap fuel tank hot air outlet lower shell figure 1 - 350,000 btu unit unpacking 1. Remove all protective packing applied to heater for shipment. 2. Remove heater from shipping container. 3. Check heater for any shipping damage. If...

  • Page 5: Theory Of

    5 104042 theory of operation the fuel system: the motor turns the fuel pump. The fuel pump pulls fuel from the fuel tank. The fuel pump pushes fuel through a filter and a solenoid valve and out the burner head nozzle. A fine mist of fuel is sprayed into the combustion chamber. The air system: the mo...

  • Page 6: Operation

    6 104042 operation continued to start heater 1. Follow all ventilation and safety information. 2. Fill fuel tank with kerosene or no. 1 fuel oil. 3. Attach fuel cap. 4. Set thermostat dial to desired temperature. Note: thermostat setting must be higher than surrounding air temperature. 5. Plug power...

  • Page 7: Caution

    7 104042 to stop heater ! Caution never unplug heater while heater is running. Heater must go through purge cycle. The purge cycle cools the combustion chamber. Damage to heater can occur if combustion chamber is not cooled. Do not restart heater until purge cycle is complete. 1. Turn thermostat dia...

  • Page 8: Preventative

    8 104042 preventative maintenance schedule item fuel tank filler neck screen fuel filter assembly (fuel tank) fuel filter lines fuel filter (pump) spark plug fan blades and air deflectors air passages around burner head motor ! Warning never service heater while it is plugged in, operating, or hot. ...

  • Page 9: Warning

    9 104042 observed problem ! Warning icon g 001 warning never service heater while it is plugged in, operating, or hot. Severe burns and electrical shock can occur. Only a qualified service person should service and repair heater. Trouble- shooting motor does not start when heater is plugged in and t...

  • Page 10: Warning

    10 104042 observed problem heater will not ignite, but motor runs for a short period of time. 1. A) add fuel to tank. B) check fuel tank for bubbles of water in bottom. If found, remove fuel (see storing, transporting, or shipping, page 7). Clean tank and fuel filters (see fuel filters, page 15). Fi...

  • Page 11: Trouble-

    11 104042 observed problem trouble- shooting continued heater ignites, but flame-out control shuts off heater after a short period of time. 1. Wrong pump pressure 2. Dirty fuel filters 3. Dirt in nozzle 4. Dirty photocell lens 5. Open or damaged photocell 6. Bad flame-out control 7. Damaged fan swit...

  • Page 12: Service

    12 104042 service procedures ! Warning never service heater while it is plugged in, operating, or hot. Severe burns and electrical shock can occur. Only a qualified service person should service and repair heater. Upper shell removal 1. Remove screws along each side and top of heater using 5/16" nut...

  • Page 13

    13 104042 figure 6 - spark plug removal spark plug wire spark plug burner head spark plug 1. Remove upper shell (see page 12). 2. Remove spark plug wire from spark plug (see figure 6). 3. Remove spark plug from burner head using 13/16" open-end wrench (see figure 6). 4. Replace spark plug if dam- ag...

  • Page 14

    14 104042 psi pump (procedure if pump is binding) 1. Remove upper shell (see page 12). 2. Loosen hex screw on flange clamp at rear of motor with 5/16" nut-driver (see figure 10). 3. Turn fan with hand (see figure 11). 4. If fan turns freely, tighten screw on flange clamp. 5. If fan does not turn fre...

  • Page 15

    15 104042 fuel filter fuel lines fuel filters a. Tank fuel filter 1. Disconnect fuel lines from pump and pump fuel filter assembly with 7/16" wrench (see figure 14). 2. Carefully pry fuel filter loose from fuel tank with flat end of screwdriver. 3. Inspect fuel filter for water or dirt. 4. Rinse fue...

  • Page 16: Specifications

    16 104042 specifications 350,000 btu unit output rating (btu/hr) 350,000 fuel use only kerosene or no. 1 fuel oil fuel tank capacity (u.S. Gallons) 30 fuel consumption (gallons per hr) 2.5 electric requirements 120v/60 hz amperage (normal run) 7.1 motor rpm 1725 fuel pump pressure (psi) 100 spark pl...

  • Page 17: Illustrated

    17 104042 illustrated parts breakdown 350,000 btu unit 1 2 2 4 5 21 2 7 8 9 10 13 11 12 14 15 16 19 20 21 4 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 37 38 34 2 39 2 40 4 6 20 13 3 17 18 41.

  • Page 18: Parts List

    18 104042 ref. No. Part no. Description qty. 1 130-20768 upper shell 1 2 130-20805 screw, #10-16 x 1/2" 15 3 130-20776 combustion chamber & shield 1 4 130-20931 bushing 7 5 130-20942 air deflector 5 6 400-20829 burner head assembly 1 7 130-20828 photocell assembly 1 8 130-20845 fan 1 9 130-20937 fan...

  • Page 19

    19 104042 4 9 8 7 6 5 3 1 2 ref no. Part no. Description qty. 1 130-20808 screw, #6-32 x 3/8" 2 2 130-20826 photocell bracket 1 3 130-20830 spark plug 1 4 130-20767 nozzle 1 5 130-20839 plug 1 6 130-20836 burner head body 1 7 130-20841 straight nipple 1 8 120-20840 solenoid valve 1 9 130-20842 compr...

  • Page 20: II. General Information

    104042-01 rev. B 09/97 150-20762 for purchasing l. B. White. This l. B. White heater incorporates the benefits from the most experienced manufacturer of heating products using state-of-the-art technology. If you have any suggestions or comments, please call us toll-free at 1-800-345-7200 or write or...