1. DL manuals
  2. Lance-Larkin
  3. Coffee Maker
  4. Brew Express
  5. Cleaning Instructions Manual

Lance-Larkin Brew Express Cleaning Instructions Manual

Manual is about: Flow Control CLEANING / REPLACEMENT Procedure

Summary of Brew Express

  • Page 1

    45b7df64-103b-08a7b4.Doc flow control cleaning / replacement procedure step #1 please remove the brew express from the wall by removal of 4 outside set screws, and pull away by holding the sides of the unit. Upon removal, press a grey button on the water line (quick-connection) to disconnect the wat...

  • Page 2

    45b7df64-103b-08a7b4.Doc step #2 place brew express face down on a towel to protect front face.

  • Page 3

    45b7df64-103b-08a7b4.Doc step #3 loosen lower valve connection nut with 18 mm or equivalent wrench. Step 4 carefully pull away slightly and rotate water line using pliers. Caution: gasket o-ring seal may fall into unit. Remove / watch so it does not fall off. Caution: do not bend copper line! Just r...

  • Page 4

    45b7df64-103b-08a7b4.Doc step 5 remove flow control with 18 mm or equivalent wrench.

  • Page 5

    45b7df64-103b-08a7b4.Doc step 6 to clean for low volume (flow) problem : rinse under strong stream of water to clean or and use small paper clip / wire to push through center hole to clear. Dry with towel. (for replacement of flow control, go to #7).

  • Page 6

    45b7df64-103b-08a7b4.Doc step 7 place cleaned or replacement flow control back into valve. Seal o-ring on flow control should be upward direction only..

  • Page 7

    45b7df64-103b-08a7b4.Doc tighten with wrench snug to valve. Step 8 re-align copper line with flow control by rotating. Ensure small o-ring did not fall off. Tighten nut snug to secure copper line to flow control. Do not over-tighten nut o-ring.

  • Page 8

    45b7df64-103b-08a7b4.Doc tighten copper line connection. Do not over tighten. Step 9 re-install brew express into wall, “snap” together water connection re-set clock, remove and clean spray-head (recommended), and run two pots of water without spray-head to clear any debris that maybe in the system....

  • Page 9

    45b7df64-103b-08a7b4.Doc.