1. DL manuals
  2. Land Pride
  3. Lawn and Garden Equipment
  4. 322-215M
  5. Operator's Manual

Land Pride 322-215M Operator's Manual

Manual is about: Seed Bed Roller With Pull Hitch Option Without Pull Hitch Option

Summary of 322-215M

  • Page 1

    Table of contents cover photo may show optional equipment not supplied with standard unit. Read the operator’s manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! ! © copyright 201...

  • Page 2

    Table of contents model sbr72 seed bed roller 322-215m 2/04/12 © copyright 2012 all rights reserved land pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, land pride assumes no r...

  • Page 3

    1 important safety information 2/04/12 model sbr72 seed bed roller 322-215m table of contents important safety information ▲ safety at all times thoroughly read and understand the instructions given in this manual before operation. Refer to the “safety label” section, read all instructions noted on ...

  • Page 4

    2 important safety information model sbr72 seed bed roller 322-215m 2/04/12 table of contents these are common practices that may or may not be applicable to the products described in this manual. Transport machinery safely ▲ comply with state and local laws. ▲ maximum transport speed for implement ...

  • Page 5

    3 important safety information 2/04/12 model sbr72 seed bed roller 322-215m table of contents these are common practices that may or may not be applicable to the products described in this manual. Prepare for emergencies ▲ be prepared if a fire starts. ▲ keep a first aid kit and fire extinguisher ha...

  • Page 6

    4 important safety information model sbr72 seed bed roller 322-215m 2/04/12 table of contents 848-148c negative hitch weight located below and above the tongue. 25762 below tongue above tongue safety labels your seed bed roller comes equipped with all safety labels in place. They were designed to he...

  • Page 7

    5 introduction 2/04/12 model sbr72 seed bed roller 322-215m table of contents definitions owner assistance the warranty registration card should be filled out by the dealer at the time of purchase. This information is necessary to provide you with quality customer service. If customer service or rep...

  • Page 8

    6 introduction model sbr72 seed bed roller 322-215m 2/04/12 table of contents further assistance your dealer wants you to be satisfied with your new seed bed roller. If for any reason you do not understand any part of this manual or are not satisfied with the service received, the following actions ...

  • Page 9

    7 section 1: assembly & set-up 2/04/12 model sbr72 seed bed roller 322-215m table of contents tractor requirements the tractor horsepower and weight must be capable of controlling the seed bed roller under all operating conditions. Smaller horsepower and lighter weight tractors must not be used. Thr...

  • Page 10

    8 section 1: assembly & set-up model sbr72 seed bed roller 322-215m 2/04/12 table of contents c. Attach back of tongue with two 3/8"-16 x 1" gr5 cap screws (#8) and 3/8" flange lock nuts (#15). 7. Tighten flange lock nuts (#14, #15 & #16) to the correct torques. 8. Remove wire snap lock pin (#1b). R...

  • Page 11: Danger

    9 section 1: assembly & set-up 2/04/12 model sbr72 seed bed roller 322-215m table of contents roller scraper assembly figure 1-4 3-point hook-up refer to figure 1-5 & figure 1-6: ! Danger crushing hazard between tractor and implement. Do not allow anyone to stand between tractor and implement while ...

  • Page 12: Danger

    10 section 1: assembly & set-up model sbr72 seed bed roller 322-215m 2/04/12 table of contents pull-type hook-up ! Danger crushing hazard between tractor and implement. Do not allow anyone to stand between the tractor and implement while backing-up to an implement. ! Danger engage parking brake, shu...

  • Page 13

    11 section 2: adjustments 2/04/12 model sbr72 seed bed roller 322-215m table of contents scraper bar adjustment refer to figure 2-1: 1. Slightly loosen hex nuts (#3) on both ends of the scraper bar (#1). Nuts should be loose enough to allow scraper bar movement but tight enough to hold the scraper b...

  • Page 14: Warning

    12 section 3: operating procedures model sbr72 seed bed roller 322-215m 2/04/12 table of contents operating checklist hazard control and accident prevention are dependent upon the awareness, concern, prudence and proper training involved in the operation, transport, maintenance and storage of the se...

  • Page 15: Caution

    13 section 3: operating procedures 2/04/12 model sbr72 seed bed roller 322-215m table of contents operating instructions ! Caution be careful when lowering the pull type roller to ground. Make sure no one is under, behind or near the unit when lowering. The roller is very heavy and can crush someone...

  • Page 16: Danger

    14 section 3: operating procedures model sbr72 seed bed roller 322-215m 2/04/12 table of contents unhooking the seed bed roller ! Danger always engage parking brake, shut off tractor and remove key before dismounting from tractor. 3-point type 1. See figure 1-1 on page 7. Set support stand in park p...

  • Page 17: Warning

    15 section 3: operating procedures 2/04/12 model sbr72 seed bed roller 322-215m table of contents storage positions for tight areas figure 3-3 storage positions for tighter areas figure 3-4 storage position using support stand figure 3-5 stored supported on rear wheels & scraper 25798 chock front & ...

  • Page 18: Caution

    16 section 4: maintenance & lubrication model sbr72 seed bed roller 322-215m 2/04/12 table of contents maintenance ! Caution do not work on or around the seed bed roller without blocking the unit properly. The roller raised off the ground could drop suddenly crushing someone. If the roller is on the...

  • Page 19

    17 section 5: additional equipment 2/04/12 model sbr72 seed bed roller 322-215m table of contents section 5: additional equipment electric spin spreader, mounting bracket & rear hitch figure 5-2 drag harrow refer to figure 5-3: the land pride drag harrows are designed for various types of seedbed an...

  • Page 20

    18 section 5: additional equipment model sbr72 seed bed roller 322-215m 2/04/12 table of contents complete one pass seeding application refer to figure 5-4: land pride offers a seeder/overseeder component system for one-pass ground cultivation and seed to soil integration for applications on previou...

  • Page 21

    19 section 6: specifications & capacities 2/04/12 model sbr72 seed bed roller 322-215m table of contents section 6: specifications & capacities pull type three point type sbr72 = 84" sbr72 = 77" 30 3/4" 19" 77 3/4" 26790 26791 18" sbr72 model description three-point pull-type unit weight 442 lbs. 47...

  • Page 22

    20 section 7: features and benefits model sbr72 seed bed roller 322-215m 2/04/12 table of contents sbr series features benefits category 1 three-point hitch or pull-type configurations. Matches customers operational and equipment needs. Three point hitch model is cat. 1 quick hitch compatible. Makes...

  • Page 23

    21 section 8: torque values chart 2/04/12 model sbr72 seed bed roller 322-215m table of contents section 8: torque values chart torque values chart for common bolt size in-tpi 1 n · m ft-lb 3 n · m ft-lb n · m ft-lb mm x pitch n · m ft-lb n · m ft-lb n · m ft-lb 1/4" - 20 7.4 5.6 11 8 16 12 m 5 x 0....

  • Page 24

    22 section 8: torque values chart model sbr72 seed bed roller 322-215m 2/04/12 table of contents.

  • Page 25

    23 section 9: warranty 2/04/12 model sbr72 seed bed roller 322-215m table of contents warranty land pride warrants to the original purchaser that this land pride product will be free from defects in material and workmanship beginning on the date of purchase by the end user according to the following...

  • Page 26

    Corporate office: p.O. Box 5060 salina, kansas 67402-5060 usa www.Landpride.Com.