Land Pride FDR1648 Series Operator's Manual - page 2
Table of Contents
FDR1648, FDR1660 & FDR1672 Rear Discharge Grooming Mowers 310-366M
4/03/14
©
Copyright 2014 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use
of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this
product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . 8
Section 1: Assembly & Set-Up . . . . . . . . . . . 10
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Dealer Preparations . . . . . . . . . . . . . . . . . . . . . . . 10
Vented Dipstick Installation . . . . . . . . . . . . . . . . . . 10
Upper 3-Point Hitch Assembly . . . . . . . . . . . . . . . . 10
Gauge Wheel Assembly . . . . . . . . . . . . . . . . . . . . 11
Lower 3-Point Clevis Hitch Assembly . . . . . . . . . . 11
Tractor 3-Point Hook-up . . . . . . . . . . . . . . . . . . . . 12
Top Center Link Adjustment . . . . . . . . . . . . . . . . . 12
Driveline Hook-up to Gearbox . . . . . . . . . . . . . . . . 13
Driveline Hook-up to Tractor . . . . . . . . . . . . . . . . . 13
Check Driveline Collapsible Length . . . . . . . . . . 14
Shorten Driveline . . . . . . . . . . . . . . . . . . . . . . . . 14
Check Maximum Allowable Length . . . . . . . . . . 14
Driveline Safety Chains . . . . . . . . . . . . . . . . . . . 15
Check Driveline Interference . . . . . . . . . . . . . . . 15
Section 2: Accessories & Set-up . . . . . . . . . 16
Front Roller Assembly . . . . . . . . . . . . . . . . . . . . . . 16
Cutting Blades . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Low Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Medium Lift Blades (Factory Standard) . . . . . . . 16
High Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . . 16
Mulching Blades . . . . . . . . . . . . . . . . . . . . . . . . . 16
Accessory Part Numbers . . . . . . . . . . . . . . . . . . . . 16
Section 3: Operating Instructions . . . . . . . . 17
Operating Check . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Pre-Start Checklist . . . . . . . . . . . . . . . . . . . . . . . . . 17
Tractor Shut Down Procedure . . . . . . . . . . . . . . . . 17
Inspection Procedures . . . . . . . . . . . . . . . . . . . . . . 17
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 18
Un-hooking the Mower . . . . . . . . . . . . . . . . . . . . . . 19
General Operating Instructions . . . . . . . . . . . . . . . 20
Section 4: Adjustments . . . . . . . . . . . . . . . . . 21
Leveling the Mower . . . . . . . . . . . . . . . . . . . . . . . . 21
Cutting Height Adjustment . . . . . . . . . . . . . . . . . . . 21
3-Point Hitch Adjustments . . . . . . . . . . . . . . . . . . . 21
Belt Tension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Section 5: Maintenance & Lubrication . . . . . 22
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Service Mowing Blades . . . . . . . . . . . . . . . . . . . . . 22
Blade Inspection . . . . . . . . . . . . . . . . . . . . . . . . . 22
Blade Sharpening or Replacement . . . . . . . . . . . 23
V-Belt Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Storage Instructions . . . . . . . . . . . . . . . . . . . . . . . . 24
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Driveline Shaft U-Joints . . . . . . . . . . . . . . . . . . . 25
Inner Tube Bearings . . . . . . . . . . . . . . . . . . . . . . 25
Driveline Profiles . . . . . . . . . . . . . . . . . . . . . . . . 25
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Wheel Support Busings & Wheel Bearings . . . . . 26
Bearing in Blade Spindle Hubs . . . . . . . . . . . . . . 26
Section 6: Specifications & Capacities . . . . . 27
Section 7: Features & Benefits . . . . . . . . . . . 28
Section 8: Troubleshooting . . . . . . . . . . . . . . 29
Section 9: Torque Values Chart . . . . . . . . . . 30
Section 10: Warranty . . . . . . . . . . . . . . . . . . . 31
Table of Contents