1. DL manuals
  2. Landa
  3. Pressure Washer
  4. HS-3000
  5. Operator's Manual

Landa HS-3000 Operator's Manual

Summary of HS-3000

  • Page 1

    Operator’s manual for technical assistance or the dealer nearest you, consult our web page at www.Landa.Com hs-3000 hs 89139430-8 8.913-943.0

  • Page 3: Contents

    3 contents 8.913-943.0 • landa hs • rev. 4/13 model number __________________________________________ serial number __________________________________________ date of purchase _________________________________________ the model and serial numbers will be found on a decal attached to the pressure was...

  • Page 4

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 4 trigger gun kicks back - hold with both hands warning warning: spray gun kicks back — hold with both hands. 9. Grip cleaning wand securely with both hands before starting. Failure to do this could result in injury from a whipp...

  • Page 5

    8.913-943.0 • landa hs • rev. 4/13 5 pressure w asher opera tor’s manu al warning ear protection must be worn warning: appropriate ear protection must be worn if attached pressure washer exceeds 85 db. Warning risk of injury from falls when using ladder. Warning: be extremely careful when using a la...

  • Page 6: Component Identification

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 6 component identification 89139430-3 customer’s pressure washer, attached (not included) fresh water faucet water supply hose (not included) stackless top adapter kit 30-199 note: the water in this machine is hot. The wand and ...

  • Page 7: Assembly Instructions

    8.913-943.0 • landa hs • rev. 4/13 7 pressure w asher opera tor’s manu al assembly instructions step 1: location of machine is important. Avoid installing near combustible material or in poorly ventilated areas. Connect the power cord into the proper electrical outlet, then push in the gfci reset bu...

  • Page 8: Installation

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 8 installation place machine in a convenient location providing ample support, draining and room for maintenance. Location: the location should protect the machine from damaging environmental conditions, such as; wind, rain, and...

  • Page 9: Operating Instructions

    8.913-943.0 • landa hs • rev. 4/13 9 pressure w asher opera tor’s manu al operating instructions step 1: connect the high pressure hose quick coupler from attached pressure washer to discharge nipple by sliding the quick coupler collar back and inserting quick coupler on coupler nipple and pushing t...

  • Page 10: Cleaning Tips

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 10 89139430-5 warning: some detergents may be harmful if inhaled or ingested, causing severe nau- sea, fainting or poisoning. The harmful elements may cause property damage or severe injury. Step 1: connect detergent injector to...

  • Page 11: Shutting Down and Clean-Up

    8.913-943.0 • landa hs • rev. 4/13 11 pressure w asher opera tor’s manu al warning protect from freezing warning: protect machine from freezing. 89139430-11 shutting down and clean-up step 1: remove detergent suction tube from container and insert into one (1) gallon of fresh water. Pull trigger on ...

  • Page 12: Maintenance & Service

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 12 maintenance & service preventative maintenance 1. Use clean fuel - kerosene, no. 1 home heating fuel or diesel. Clean or replace fuel filter every 100 hours of operation. Avoid water contaminated fuel as it will seize up the ...

  • Page 13: Maintenance & Service

    8.913-943.0 • landa hs • rev. 4/13 13 pressure w asher opera tor’s manu al 89139430-7 date code serial no. Xxxxxx part no. 0000-0000.0 maintenance & service the fuel solenoid valve functions properly. This can be done by operating the machine and checking to see that when the trigger on the spray gu...

  • Page 14: Maintenance & Service

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 14 coil removal hs-3000 removal of the coil, because of freeze breakage, thermal expansion or to clean soot from it, can be done quickly and easily. 1. Disconnect hose from inlet side of the coil. 2. Disconnect electrical connec...

  • Page 15: Troubleshooting

    8.913-943.0 • landa hs • rev. 4/13 15 pressure w asher tr oub leshooting guide troubleshooting problem possible cause solution burner will not light disconnected or short in electrical wiring all wire contacts should be clean and tight. No breaks in wire. Burner motor thermal protector tripped if tr...

  • Page 16: Troubleshooting

    8.913-943.0 • landa hs • rev. 4/13 pressure w asher tr oub leshooting guide 16 troubleshooting problem possible cause solution low water temperature improper fuel or water in fuel drain fuel tank and replace with proper fuel. Low fuel pressure increase fuel pressure. Weak fuel pump check fuel pump t...

  • Page 17: Preventative Maintenance

    8.913-943.0 • landa hs • rev. 4/13 17 pressure w asher opera tor’s manu al preventative maintenance this pressure washer was produced with the best available materials and quality craftsmanship. However, you as the owner have certain responsibilities for the correct care of the equipment. Attention ...

  • Page 18: Chassis Assembly

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 18 89139430-2 chassis assembly fuel line to fuel pump fuel line to fuel filter 19 18 26 24 25 23 3 1 21 2 22 20 28 7 8 9 11 10 12 33 17 17 16 14 6 4 5 13 27 3 3 14 4 4 4 4 4 3 3 5 11 10 30 31 15 34 32 29 brake assembly 35.

  • Page 19: Chassis Assembly Parts List

    8.913-943.0 • landa hs • rev. 4/13 19 pressure w asher opera tor’s manu al chassis assembly parts list item part no. Description qty 1 8.912-201.0 u-handle, hot 1 2 9.802-069.0 grip, 1", handle (waffle) 2 3 9.802-728.0 bolt, 3/8" x 2", hh grades 6 4 8.725-394.0 washer, 3/8", sae flat 6 5 8.725-395.0...

  • Page 20: Tank & Burner Assembly

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 20 89139430-1 to pressure washer to fuel tank to fuel tank 23 44 19 2 38 20 16 21 22 45 14 17 18 5 6 6 7 34 35 47 4 48 11 9 8 42 15 5 4 10 40 36 32 32 31 28 29 30 33 41 3 24 25 39 3 43 13 41 1 46 37 37 26 tank & burner assembly ...

  • Page 21

    8.913-943.0 • landa hs • rev. 4/13 21 pressure w asher opera tor’s manu al item part no. Description qty 1 9.802-896.0 insulation, blanket-no foil, 24" x 57" 1 2 9.800-033.0 label, warning, hot water 1 3 9.802-024.0 elbow, street, 3/8" x 1/2" 2 4 9.803-132.0 phw insulation retainer 2 5 8.933-009.0 g...

  • Page 22: Exterior View

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 22 89139430-6 exterior view exterior view parts list item part no. Description qty 1 9.800-016.0 label, disconnect power supply 1 2 9.800-049.0 label, manufacturer’s cleaning solution 1 3 8.900-336.0 label, hs-3000 control panel...

  • Page 23: Specifications

    8.913-943.0 • landa hs • rev. 4/13 23 pressure w asher specifications specifications burner burner fuel/pump model no. Assy no. Fuel nozzle transformer motor solenoid/cord electrode hs-3000 8.918-913.0 8.717-273.0 8.919-114.0 8.750-517.0 8.700-759.0 8.750-778.0 burner specifications.

  • Page 24

    8.913-943.0 • landa hs • rev. 4/13 opera tor’s manu al pressure w asher 24 surefire burner replacement parts for best performance specify genuine surefire replacement parts.

  • Page 25

    8.913-943.0 • landa hs • rev. 4/13 25 pressure w asher opera tor’s manu al item # p ar t # description qty item # p ar t # description qty 1 8.919-050.0 b urner housing assembl y 1 25 8.750-830.0 plug, hole 0.285 plastic 1 2 8.751-160.0 air guide 26 8.751-134.0 plug, 1/8" npt x h ex s houlder 1 3 8....

  • Page 27

    8.913-943.0 • landa hs • rev. 4/13 pressure w asher w arranty landa limited new product warranty pressure washers what this warranty covers all landa pressure washers are warranted by landa to the original purchaser to be free from defects in materials and workmanship under normal use, for the perio...

  • Page 28

    • 8.913-943.0 • landa hs • revised 4/13 • printed in u.S.A..