- DL manuals
- Lang
- Kitchen Appliances
- 124cm
- Installation Operation & Maintenance
Lang 124cm Installation Operation & Maintenance
Summary of 124cm
Page 1
Lang manufacturing 10 sunnen drive st. Louis, mo 63143 rev. B phone: (314) 678-6315 fax: (314) 781-2714 part # 2m-60803-01 www.Langworld.Com march 06, 2013 installation, operation, & maintenance electric cheese melter model: 124cm, 136cm and 148cm.
Page 2: For Your Safety
2 this manual must be retained for future reference. Read, understand and follow the instructions and warnings contained in this manual. For your safety do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Post in a prominent location ins...
Page 3: Table of Contents
3 table of contents chapter page table of contents....................................................................................3 read first......................................................................................................4 equipment description ...............................
Page 4
4 important read first important caution: each unit is extremely heavy. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation....
Page 5
5 important read first important warning: keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or fac...
Page 6: Equipment Description
6 equipment description lang electric cheese melter: exterior construction the melter dimensions are 19.5” (49.5cm) high, 16.5” (42cm) deep, 24”, 36”, 48” (61cm, 91cm, 122cm) wide dependent on the actual model number. The sides, bottom, and rear wall are constructed stainless steel. The melter cavit...
Page 7: Unpacking
7 unpacking receiving the melter upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become apparent until the m...
Page 8: Installation
8 installation danger: this appliance must be grounded at the terminal provided. Failure to ground the appliance could result in electrocution and death. Warning: installation of the unit must be done by personnel qualified to work with electricity and plumbing. Improper installation can cause injur...
Page 9: Installation Cont’D
9 installation cont’d counter top split the back into two pieces. Remove the screws from the rear of the cheese-melter; screw the stainless steel portion of the back to the cheese-melter with the offset at the top. Reinstall the two back halves together and replace the screws around the edge. When i...
Page 10
10 installation cont’d 124cm & 136cm 148c m figure 1 figure 2 connect connect connect connect connect blue blue red red 104v or 120v element 104v or 120v element 208v or 240v element connect blue blue red connect connect connect 208v or 240v element 104v or 120v element 104v or 120v element 208v or ...
Page 11: Operation
11 operation general the lang electric cheese-melter can be used to poach, sauté and brown. In addition to melting cheese on sandwiches, french onion soup, hot apple pie and casseroles, it may be used for finishing italian, mexican and au gratin dishes utilizing less energy than conventional broiler...
Page 12: Operation Cont’D
12 operation cont’d operating do’s and don’ts do: insure all dishes placed in the cheese-melter are oven safe. Pre-heat pans in the cheese-melter or on a stove. Turn products halfway through cooking, as needed. Use the unit in automatic as much as possible, use constant during peak periods. Don't: d...
Page 13: Maintenance & Cleaning
13 maintenance & cleaning warning: keep water and solutions out of controls. Never spray or hose control console. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or face shield and protective clothing. Ca...
Page 14: Troubleshooting
14 troubleshooting symptoms what follows is a chart of symptoms and possible causes to aid in diagnosing faults with the melter. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked. To test for a possible causes refer to the test section ...
Page 15: Troubleshooting Cont’D
15 troubleshooting cont’d test notice: service on this, or any other, lang appliance must be performed by qualified personnel only. Consult your authorized service station directory or call the factory at 314-678-6315, or www.Langworld.Com for the service station nearest you. Warning: both high and ...
Page 16: Wiring Diagram 124Cm & 136Cm
16 wiring diagram 124cm & 136cm.
Page 17: Wiring Diagram 148Cm
17 wiring diagram 148cm.
Page 18
1 2 3 4 1 5 6 1 7 20 19 17 see detail a 9 12 18 13 14 15 16 8 8 9 10 11 1 1 1 1 1 1 21 22 30 31 sk2246 rev. - 5/2/07 model: 124cm electric cheesmelter.
Page 19
23 25 24 26 11 9 27 28 29 sk2247 rev. - 5/2/07 model: 124cm electric cheesmelter - control panel assembly 26 3-pole 2-pole detail a.
Page 20: Parts List
Parts list september 24, 2013, rev. B important: when ordering, include model and serial number some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description and model designation model part number key number 124cm electric cheeseme...
Page 21: Parts List
Parts list september 6, 2013, rev. B 136cm electric cheesemelter important: when ordering, include model and serial number some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description and model designation model part number key num...
Page 22: Parts List
Parts list september 6, 2013, rev. B 148cm electric cheesemelter important: when ordering, include model and serial number some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description and model designation model part number key num...
Page 24
Star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com.