- DL manuals
- Lang
- Griddle
- 124TH
- Installation And Operation Instructions Manual
Lang 124TH Installation And Operation Instructions Manual
Summary of 124TH
Page 1
Il1559 electric griddle w/24” clamshell ® 24th 36th, 36th, 36thr 48th, 48thr 48ths 48th2 installation and operation instructions 2m-w351 rev. F 1/27/12 36th.
Page 2
2 these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. For your saftey do not store or use gasoline or other flammable vapors and liquids in the vicintiy of this or any other appliance. Post in prom...
Page 3
3 table of contents specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 equipment description . . . . . . . . . . . . . . . . . . . . . . . 5 - 6 unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 installation leg installation . . . . . . . . . . . . . ....
Page 4
4 3” w d 24.0” 45.6” 22.5” il1560 equipment specifications model height x width x depth clearance from combustable surface weight freight class (not including legs, clamshell® open) actual shipping 124th 45.6” x 24.0” 31.9” sides & back: 2” 298 lbs. 335 lbs 85 1158mm x 610mm x 811mm 135 kg 152 kg 13...
Page 5
5 equipment description exterior construction griddle the griddle dimensions are 7” (43.8cm) high, 30” (76.20cm) deep, and width is dependent on the actual model number. The sides, bottom, and rear wall are constructed of double wall stainless steel, which allows closer installation to combustible s...
Page 6
6 caution equipment description continued technical griddle the griddle is standard 208/240 dual voltage, 3 phase, for on-site installation to either 208v or 240v. For simple conversion to single phase power connection see the phasing portion of this manual. This conversion is extremely easy and nei...
Page 7
7 installation leg installation the th hood comes standard with 4-inch stainless steel legs. An optional stand is available. To install the legs, remove the legs from the grease drawer. Using extreme caution elevate the griddle 0 inches off the ground and install the legs in the threaded holes provi...
Page 8
8 installation cont. Ventilation and clearances standard minimum clearance from combustible construction is as follows. 2” from side 2” from back these griddles may be set directly, without legs, on a curbed base or non-combustible surface. If the griddle is set without legs on a non-combustible flo...
Page 9
9 initial start up griddles prior to putting any griddle into full time operation at normal cooking temperatures, it must be thoroughly “seasoned” and dried out. Moisture absorption in the closed spaces, in the insulation and even inside the heating elements can cause future trouble if not properly ...
Page 10
0 operation general the suggested time and temperature chart (below) is provided as a guide for the products listed only. If different temperature settings are to be used, select one side of the griddle and operate at the lowest temperature. Adjoining sections should be set at progressively higher t...
Page 11
Maintenance & cleaning warning: keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or face shield and protec...
Page 12
2 on crome surfaces: . Never use pumice, griddle stones, or abrasives on the surface. 2. Never strike the griddle surface with a sharp instrument or spatula edge. 3. Never use steel wool. 4. Never use commercial liquid grill cleaner on the griddle surface. 5. Abusing the surface voids the warranty. ...
Page 13
3 warning troubleshooting symptoms what follows is a chart of symptoms and possible causes to aid in diagnosing faults with the griddle. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked. To test for a possible causes refer to the test ...
Page 14
4 * 1 5 4 2 3 * 1 5 4 2 3 3 2 1 down up 10 10 15 16 4 6 5 3 9 blu/w r/w 3 2 1 down up 10 10 15 16 4 6 5 3 9 blu/w r/w 5 l3 l2 l1 4 1 2 3 griddle elements 1 2 3 4 5 6 11 10 7 9 8 12 13 griddle pilot lamp griddle thermostat jumper terminal block overtemp stat #1 hood tilt switch switch terminal block ...
Page 15
5 2m-61 113-25 rev b 6/05/1998 models: 124th, 136th, 148th hood w/idle 10 jumper 12 broiler pilot lamp 11 terminal block 1 griddle elements 8 preset high temp . Cut off sw . 7 broiler switch 6 cont act or 5 hea ters 4 broiler power switch 3 griddle thermost at 2 griddle pilot lamp 9 wire nut remove ...
Page 16
6 sk2399 rev. - 10/06/08 1 32 2 3 4 5 6 7 8 9 14 10 17 15 16 18 19 20 21 10 24 23 25 26 27 10 33 10 10 29 detail a 30 22 22 12 13 10 31 10 11 28 model: 124th, 136th, 148th electric clamshell ®.
Page 17: Parts List
7 parts list march 2, 202, rev. F important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Model: 124th, 124th-208mgt, 124th-208vmg; thermostatic electri...
Page 18: Parts List
8 parts list january 27, 202, rev. F important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Model: 136th, 136the-480vm; thermostatic electric clamshell...
Page 19: Parts List
9 parts list january 27, 202, rev. F model: 148th, 148thr, 148ths; thermostatic electric clamshell® commercial fig no part number qty description application 1 k9-xl-722-9 1 plate asy 4’ combo lh 148th k9-xl-722-901 plate asy 4’ combo rh 148thr k9-xl-722-903 plate asy 4’ slider tall 148ths 2 2n-1103...
Page 20
20 sk2400 rev. - 10/06/08 detail a model: 124th, 136th, 148th electric clamshell ® 1 2 3 7 8 9 10 12 11 17 15 16 14 13 13 13 8 9 7 18 19 20 25 26 27 27 24 20 19 18 21 22 23 22 31 33 32 30 29 28 22 4 5 6 148ths slide see detail b.
Page 21: Parts List
2 parts list june 3, 20, rev. F important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Model: 124th, 136th, 148th, 148ths, 148th2, detail a, themostat ...
Page 22
22 sk2401 rev. - 10/06/08 model: 148ths electric sliding clamshell ® frame assy detail b 1 5 6 7 8 7 5 3 8 8 3 11 9 10 5 17 3 3 7 8 9 8 12 13 14 15 15 2 3 4 9.
Page 23: Parts List
23 model no: 148ths detail a: sliding hood frame assy parts list september 0, 2009, rev. F important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Descr...
Page 24
24 star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com.