Il2412 envirozone-tstat gas griddle commercial 224zt, 236zt, 248zt, 260zt, 272zt installation and operation instructions 2m-w1785 rev. C 4/23/15 272zt.
2 safety symbol model no.: serial no.: voltage: 1-phase or 3 phase: purchased from: location: purchase date: installed date: these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. For your saftey do n...
3 table of contents specifications 4 equipment description 5 unpacking 6 installation leg installation 6 ventilation & clearence 7 electrical & gas connection 8 initial start-up initial lighting procedure 9 seasoning cooking surface 9 operation setting the griddle temperature 10 suggested times and ...
4 front side top 31.375” 16.5” 20” 4” il2411 equipment specifications gas and electric input requirments model number description total btu input gas connection electrical connection cord/plug & pressure regulator unit width griddle surface depths natural propane 5” wc 10” wc voltage amps 224zt 24” ...
5 equipment description exterior construction the griddle dimensions are 17” (43.18cm) high, 30” (76.20cm) deep, and width is dependent on the actual model number. The sides, bottom, and rear wall are constructed of double wall stainless steel, which allows closer installation to combustible surface...
6 caution unpacking receiving the griddle upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier’s agent. Concealed loss or damage means it does not become apparent until the merchandise...
7 ventilation & clearence clearance for use on non-combustible countertops only. Combustible and non-combustible material must be at least 48” (120cm) from the top of the appliance. Combustible material must be 5” (150mm) from the sides and back, while clearance to non-combustible material on the si...
8 installation electrical connection the griddle is supplied with a cord and plug. The receptacle is not provided with the griddle. Follow the receptacle manufacturer’s instructions when connecting the receptacle to the power supply. Gas connection this griddle is manufactured for use with the type ...
9 initial start up initial lighting procedure clean the preservative coating from the griddle plate and splash guard. Add a mild detergent to hot water and wash the griddle plate and splash guard. Rinse with a damp sponge and dry with a clean rag. Warning: before lighting, use a soap and water solut...
10 operation setting the griddle temperature the suggested time and temperature chart (below) is provided as a guide for the products listed only. If different temperature settings are to be used, select one side of the griddle and operate at the lowest temperature. Adjoining sections should be set ...
11 operation loading the griddle an understanding of how the griddle sections are controlled will be a valuable aid in loading your griddle. Each 12 inch section of your griddle is independently controlled. The temperature control sensor is mounted under the griddle plate in the center of each cooki...
12 maintenance & cleaning daily cleaning (non chrome only) • empty the grease drawer daily or whenever it is 3/4 full. Clean using mild soap and warm water. • keep the griddle surface clean. After each cooking load, scrape the griddle surface to remove any carbonized grease. • once a day or when nec...
13 maintenance & cleaning continued chrome griddle surface limited warranty exclusions your chrome griddle has been designed to give you many years of cooking reliability and requires minimum maintenance to keep the chrome surface in its original condition. All chrome griddle surfaces are warranted ...
14 troubleshooting symptoms the chart below is to assist in the troubleshooting of the griddle. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked. Notice: service on this, or any other, lang appliance must be performed by qualifiedperso...
15 r 6 5 4 3 2 1 grn wht blk grn brn brn brn brn yel yel org blk blk wht wht blk wht key: power cord on/off switch pilot solenoid burner solenoid thermostat pilot ignition module pilot ignitor wire nut 1 2 5 6 7 8 3 4 4 5 5 6 7 8 8 4 3 2 1 rev. Date/eco description of change dr this drawing contains...
16 r 6 5 4 3 2 1 6 5 4 3 2 1 grn wht blk grn brn brn brn brn yel yel org blk blk blk wht wht wht blk wht yel brn brn brn brn grn yel wht blk org wht blk key: power cord on/off switch pilot solenoid burner solenoid thermostat pilot ignition module pilot ignitor wire nut 1 2 5 6 7 8 3 3 4 4 4 4 5 5 5 ...
17 r 6 5 4 3 2 1 6 5 4 3 2 1 6 5 4 3 2 1 grn wht blk grn brn brn brn brn yel yel org blk blk blk wht wht wht blk wht yel brn brn brn brn grn yel wht wht blk blk org wht wht blk blk blk wht grn brn brn yel yel brn brn org key: power cord on/off switch pilot solenoid burner solenoid thermostat pilot i...
2m-z1785; envirozone-tst at gas griddle model:envirozone thermostat gas griddle sk2564, rev. A 5/17/2014 1 2 3 4 5 6 7 8 9 12 13 14 15 15 27 28 29 26 timer units 16 17 18 19 20 21 22 23 20 19 24 25 2 see detail a.
2m-z1785; envirozone-tst at gas griddle parts list april 23, 2015, rev. C important: when ordering, specify voltage or type gas desired page 1 include model and serial number of 2 some items are included for illustrative purposes only and in certain instances may not be available. Model: 224zt, 236z...
2m-z1785; envirozone-tst at gas griddle important: when ordering, specify voltage or type gas desired page 2 include model and serial number of 2 some items are included for illustrative purposes only and in certain instances may not be available. Parts list april 23, 2015, rev. C model: 224zt, 236z...
2m-z1785; envirozone-tst at gas griddle sk2565, rev. A 4/23/2015 detail a manifold removed for clarity 1 4 5 6 7 8 10 17 11 16 13 14 15 12 16 2 3.
2m-z1785; envirozone-tst at gas griddle important: when ordering, specify voltage or type gas desired page 1 include model and serial number of 3 some items are included for illustrative purposes only and in certain instances may not be available. Parts list april 23, 2015, rev. C model: 224zt, 236z...
2m-z1785; envirozone-tst at gas griddle some items are included for illustrative purposes only and in certain instances may not be available. Parts list april 23, 2015, rev. C important: when ordering, specify voltage or type gas desired page 2 include model and serial number of 3 model: 224zt, 236z...
Star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com model: 224zt, 236zt, 248zt, 260zt, 272zt detail a 17 2a-45408 2 orifice hood .0935 #42 224zt-nat 3 236zt-nat 4 248zt-nat 5 260z...