1. DL manuals
  2. Lang
  3. Grill
  4. 236CM
  5. Installation Operation & Maintenance

Lang 236CM Installation Operation & Maintenance - Troubleshooting

Manual is about: Gas Infrared Cheesemelter

Summary of 236CM

  • Page 1

    Lang manufacturing 10 sunnen drive, st. Louis, mo 63143 part # 2m-60803-02 phone:314-678-6315 fax: 314-781-2714 rev. C www.Langworld.Com july 22, 2008 installation, operation, & maintenance model: 236cm, 248cm, gas infrared cheesemelter.

  • Page 2: For Your Safety

    Lang manufacturing 10 sunnen drive, st. Louis, mo 63143 part # 2m-60803-02 phone:314-678-6315 fax: 314-781-2714 rev. C www.Langworld.Com july 22, 2008 the information in this manual is crucial and must be retained for future reference. Read, understand and follow the instructions and warnings contai...

  • Page 3: Table of Contents

    3 the information in this manual is crucial and must be retained for future reference. Read, understand and follow the instructions and warnings contained in this manual. Table of contents chapter page table of contents ...................................................................................

  • Page 4: Important Read

    4 important read first important caution the unit is extremely heavy. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. C...

  • Page 5: Important Read

    5 important read first important notice service on this, or any other, lang appliance must be performed by qualified personnel only. Consult your lang authorized service agent directory or call the factory at 314-678-6315 or www.Langworld.Com for the lang service agent nearest you. Warning both high...

  • Page 6: Safety Procedures

    6 safety procedures lockout procedure 1. Announce lockout to other personnel. 2. Turn both heat and control power off at main panel. 3. Test lockout by turning power switch on and observing if fan(s) come on. Check heater circuit with voltmeter. 4. Perform necessary repairs or tests. 5. Turn power o...

  • Page 7: Equipment Description

    7 equipment description lang model: 236cm, 248cm gas infrared cheesemelter exterior the unit dimensions are 28” (71cm) high without legs, 21” (53cm) deep, and 36”, 48” (91cm, 122cm,) wide dependent on the actual model number. The sides, bottom, and rear wall are of constructed stainless steel. The m...

  • Page 8: Unpacking

    8 unpacking caution the unit is extremely heavy. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. Caution any stand, cou...

  • Page 9: Installation

    9 installation danger this appliance must be grounded at the terminal provided. Failure to ground the appliance could result in electrocution and death. Warning installation of the unit must be done by personnel qualified to work with electricity and plumbing. Improper installation can cause injury ...

  • Page 10: Installation Cont’D

    10 installation cont’d gas connection this appliance must be installed under a ventilation hood. The installation of any components such as vent hoods, grease extractors, fire and smoke detection devices, or fire extinguisher systems, must conform to n.F.P.A standard #96, latest edition. This applia...

  • Page 11: Initial Start Up

    11 initial start up notice during the first few hours of operation you may notice a small amount of smoke coming from the unit, and a faint odor from the smoke. This is normal for a new unit and will disappear after the first few hours of use. Pre-power on after the melter is connected to power and ...

  • Page 12: Operation

    12 operation caution always keep the area near the appliance free from combustible materials. Caution keep floor in front of equipment clean and dry. If spills occur, clean immediately, to avoid the danger of slips or falls. General the lang gas melter can be used to poach, sauté and brown. In addit...

  • Page 13: Operation Cont’D

    13 operation cont’d operating do’s and don’ts do: insure all dishes placed in the melter are oven safe. Pre-heat pans in the melter or on a stove. Turn products halfway through cooking, as needed. Use the unit in automatic as much as possible, use constant during peak periods. Don’ts do not use the ...

  • Page 14: Maintenance & Cleaning

    14 maintenance & cleaning warning keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or face shield ...

  • Page 15

    15 maintenance & cleaning cont’d pilot burner adjustment pilot flame adjustment is accomplished at the brass tube fitting on the main manifold. The brass fitting located between the regulator and the solenoid valve which has the 1/8 inch tube connected to it is the adjuster. Turn the hex head screw ...

  • Page 16: Troubleshooting

    16 troubleshooting symptoms what follows is a chart of symptoms, possible causes, and remedy’s to aid in diagnosing faults with the unit. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked. On the following pages is a chart with the poss...

  • Page 17: Troubleshooting Cont’D

    17 troubleshooting cont’d test possible cause test tripped circuit breaker • reset circuit breaker and re-test defective power switch, constant / auto switch • check switch for normal operation defective power cord • check power cord for continuity* defective regulator • check unit for proper water ...

  • Page 18: Parts List

    Etl file 52501 18 parts list july 22, 2008, rev. C gas cheese meleter: 236cm & 248cm description part no. Switch toggle on-off 2e-30303-06 pilot light 208/240v 6” lead black body 2j-31601-01 rack, 2ft 2b-50200-13 rack, 3ft 2b-50200-14 rack, 4ft 2b-50200-15 rack, 5ft 2b-50200-29 spring regulator lp 2...

  • Page 20

    Star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com.