1. DL manuals
  2. Lang
  3. Oven
  4. DO36
  5. Installation, Operation And Maintenance Instructions

Lang DO36 Installation, Operation And Maintenance Instructions

Summary of DO36

  • Page 1

    Star manufacturing international 10 sunnen drive st. Louis, mo.63143-3800 part number: 2m-w475 ph: 314-678-6315 fax: 314-781-2714 rev.A www.Langworld.Com november 2, 2007 installation, operation, and maintenance instructions deck oven model: do36 and do36l.

  • Page 2: Table of Contents

    Table of contents table of contents ..............................................................................................................1 introduction description................................................................................................................1 features ........

  • Page 3: Introduction

    Introduction this manual contains the necessary information to install, operate, and maintain the lang do36l series electric deck oven. Description the do36 series deck oven is designed as a single pan all purpose baking and roasting oven. The oven can be stacked with other 36 bake ovens, stacked wi...

  • Page 4

    2 safety precautions and warnings danger make sure the main power supply is turned off at the source prior to connecting power to the appliance. Disconnect the appliance from power before attempting any repair the following clearances to combustible surfaces must be maintained. 4 inches to sides 3 i...

  • Page 5: Installation

    3 installation receiving and uncrating upon receipt of the equipment, check for freight damage, both concealed and visible. Visible damage must be noted on the freight bill at the time of delivery and signed for by the freight company's agent. Concealed loss or damage means loss or damage which does...

  • Page 6

    4 electrical connection danger make sure the power supply to the appliance is turned off before making the connection. If the oven is to be assembled as a range, skip this section and refer to the range top installation manual. The electrical connection is made through a 1 1/4 inch knockout in the b...

  • Page 7

    5 oven phasing oven power supply terminal block 1st deck 2nd deck 3rd deck l1 x x x single phase l2 x x x l1 x x l2 x x three phase l3 x x load requirements loading three phase amps kw per phase 208 volt 240 volt 480 volt single phase amps model no. Li l2 l2 l3 l3 l1 tota l kw l1 l2 l3 l1 l2 l3 l1 l...

  • Page 8

    6 range assembly installation on oven base remove all the plastic plug buttons from the top of oven(s). Lay a 2 x 4 or cardboard corner pad across the top of the oven. Lift the range top off of the shipping skid and place it on top of the oven so that the front edge of the range top is sitting on th...

  • Page 9

    7 phasing range assembly follow the drawings, below, to group the supply wires to match the power phase. Three phase single phase load requirements for proper supply wire and circuit breaker size, refer to the chart below. Three phase loading nominal amps per line three phase single phase k.W. Per p...

  • Page 10: Operation

    8 operation initial start-up the preservatives must be cleaned off the oven front before it is heated. Wipe the oven front with a damp rag and a mild soap solution, rinse with warm water and a damp rag, and then completely dry the oven front. Before the initial use of the oven it must be allowed to ...

  • Page 11

    9 control panel 3-heat switches while the oven thermostat controls the temperature, the 3-heat switches control the amount of power from the upper and lower elements. Setting the top element 3-heat switch to "high" will burn (or broil) the tops and setting the bottom 3-heat switch to "low" will not ...

  • Page 12

    10 pan placement place the pan in the center of the oven rack for the best baking results. Keep the oven door closed as much as possible. Excessively opening the oven door will cool the front section of the oven and the products placed near the opening will bake slower. Vent control the oven is supp...

  • Page 13: Productive Maintenance

    11 productive maintenance "productive maintenance" is defined as a means of keeping the appliance as efficient and productive after years of service as it was when new. Cleaning cleaning the appliance on a regular basis will assure years of efficient performance and maintain the gleaming appearance ...

  • Page 14

    12 calibration adjustment a 1/16 inch flat blade screwdriver with a 2 inch shaft is required to adjust the thermostat. Maintain the oven temperature at 350°f degrees. Without turning the thermostat dial, pull it off the shaft of the thermostat. Locate the screw at the base of the thermostat shaft; t...

  • Page 15

    13 installation trouble shooting guide symptom problem cause not heating breakers off not connected to power improper phasing at terminal block defective thermostat reset breakers connect to power correct phasing replace thermostat one deck works others do not internal circuit breakers off ovens not...

  • Page 16

    To fit 1 2 3 4 5 6 7 5 5 5 5 5 2 1 4 1667 1667 1667 4 1 3 2 7 1 2 3 4 3 6 2 1 3 4 2 1 3 4 4 2 5 1 4 3 3 2 c 2 1 l1 l2 1 2 l1 c l2 5 1 4 2 1 hea t element thermost at 3 hea t switch pilot lamp circuit breaker speed unit 6 hea t switch top arrangement sec-1 a b b a c sec-2 a b b a c sec-3 c b c a c to...

  • Page 17

    1 2 3 4 5 6 hea t element thermost at 3 hea t switch pilot lamp circuit breaker speed units model designa tion top arrangement sec-1 a b b a c sec-2 a b b a c sec-3 c b c a c top section wire diagrams a b c grill hot t op speed units 36s-0 36s-2 36s-3a 36s-10 36s-20 2 1 4 1667 1667 1667 4 1 3 2 7 1 ...

  • Page 18

    Sk2423 rev. - 6/08/09 model: do36 deck oven la36 deck oven 2 1 3 5 6 7 1 9 1 10 11 12 13 14 15 16 8 4 see detail a see detail b.

  • Page 19: Parts List

    Parts list october4,2012,reva important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. 1 1 model: do36 bake deck oven fig no part no qty description appl...

  • Page 20

    Model: do36 deck oven, details a & b la36 deck oven, details a & b sk2424 rev. A 6/09/2010 33 1 3 5 12 11 13 14 15 16 17 18 20 21 23 24 25 28 29 30 7 31 32 27 26 19 7 6 8 7 9 10 4 2 detail a detail b.

  • Page 21: Parts List

    Parts list october4,2012,reva important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. 1 1 star international holdings, inc. Company do36 36” bake deck o...

  • Page 24

    Star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com.