1. DL manuals
  2. Lang
  3. Convection Oven
  4. ECOF-2/4CECN
  5. Installation, Operation And Maintenance Instructions

Lang ECOF-2/4CECN Installation, Operation And Maintenance Instructions

Manual is about: Electric Full Size Convection Oven

Summary of ECOF-2/4CECN

  • Page 1

    Star manufacturing international 10 sunnen drive st. Louis, mo 63143 part number: 2m-w490 phone: 314-781-2777 fax: 314-781-2714 rev b www.Star-mfg.Com june 17, 2008 installation, operation, and maintenance instructions electric full size convection oven models: ecof-c-cn ecof-c2/3vcn ecof-c2/4vcn ec...

  • Page 2: For Your Safety

    The information in this manual is crucial and must be retained for future reference. Read, understand and follow the instructions and warnings contained in this manual. Danger potentially hazardous situation, which, if not avoided, could result in death. Warning potentially hazardous situation, whic...

  • Page 3: Table of Contents

    Ul file # e8138 3 table of contents chapter page table of contents........................................................................................................................3 read first ........................................................................................................

  • Page 4

    Ul file # e8138 4 caution the unit is extremely heavy. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. Caution any stan...

  • Page 5

    Ul file # e8138 5 notice service on this, or any other, lang appliance must be performed by qualified personnel only. Consult your lang authorized service agent directory or call the factory at 1-800-807-9054, or www.Star-mfg.Com for the service agent nearest you. Warning both high and low voltages ...

  • Page 6: Equipment Description

    Ul file # e8138 6 equipment description model no: ecof-c exterior construction the oven exterior dimensions are 40” (101.6cm) wide, 28” (71.12cm) high, 38” (96.52cm) deep, and a 3.25” (8.26cm) handle extension on the door. The front, back, top, and sides are constructed of stainless steel with an al...

  • Page 7: Unpacking

    Ul file # e8138 7 unpacking receiving the oven upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become appare...

  • Page 8: Installation

    Ul file # e8138 8 installation danger this appliance must be grounded at the terminal provided. Failure to ground the appliance could result in electrocution and death. Warning installation of the unit must be done by personnel qualified to work with electricity and plumbing. Improper installation c...

  • Page 9: Installation Cont’D

    Ul file # e8138 9 installation cont’d leg pad adapter identify the front and rear leg adapters (the front adapters have two threaded inserts and the rear has four). Leg to adapter installation: install the leg’s threaded stud through the hole in the adapter labeled “c” with the bent flange of the ad...

  • Page 10: Installation Cont’D

    Ul file # e8138 10 installation cont’d ventilation and clearances standard minimum clearance from combustible construction is as follows. 4” from side 4” from back 6” from floor these ovens may be set directly, without legs, on a curbed base or non- combustible floor. If the oven is set without legs...

  • Page 11: Initial Start Up

    Ul file # e8138 11 initial start up pre-power on after the oven is installed and connected to power, prior to turning on, verify the following: the doors open and close freely. All racks are in the oven correctly. All packing materials have been removed from the inside of the oven. All power connect...

  • Page 12: Operation

    Ul file # e8138 12 operation control panel program enable buttons temperature button shelf timers status display power switch pace timers light switch minute timers.

  • Page 13: Operation Cont’D

    Ul file # e8138 13 operation cont’d general convection ovens constantly circulate air over and around the product. This strips away the thin layer of moisture and cool air from around the product allowing heat to penetrate more quickly. Always weigh your product. This will give you a more consistent...

  • Page 14: Operation Cont’D

    Ul file # e8138 14 operation cont’d status display the status display informs the operator of the oven’s status. Preht stands for preheat. The oven is on and adjusting to the preprogrammed temperature (350 °f). Ready the oven has reached the preset temperature and is waiting for product to be loaded...

  • Page 15: Programming

    Ul file # e8138 15 programming pace timers the pace timers can be set at any time. Press and hold the “pace” button for three seconds. The display will read out the set time then begin to flash. Press the “1” minute button to increase the time, or the “2” minute button to decrease the time. Once the...

  • Page 16: Maintenance & Cleaning

    Ul file # e8138 16 maintenance & cleaning warning keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles...

  • Page 17: Troubleshooting

    Ul file # e8138 17 troubleshooting symptoms what follows is a chart of symptoms and possible causes to aid in diagnosing faults with the oven. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked. To test for a possible causes refer to the...

  • Page 18: Troubleshooting Cont’D

    Ul file # e8138 18 troubleshooting cont’d notice service on this, or any other, lang appliance must be performed by qualified personnel only. Consult your lang authorized service agent directory or call the factory at 1-800-807-9054, or www.Star-mfg.Com for the service agent nearest you. Warning bot...

  • Page 19

    Sk2366 rev 4/21/2008 ecof main assembly 1 5 7 6 1 2 3 4 8 9 10 11 13 16 10 17 18 19 20 21 22 10 24 26 27 28 29 30 46 48 49 1 4 10 50 51 47 32 33 34 35 36 41 42 43 44 45 37 38 39 40 31 23 25 detail a control panel assy detail b can assembly 14 15 12 10

  • Page 20: Parts List

    Model no: ecof-c main assembly commercial cinnabon full size electric convection oven parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not...

  • Page 21: Parts List

    Parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number ni q9-eccoplmdr-c 1 panel ecco 208/2...

  • Page 22

    1 9 10 12 1 11 8 1 6 1 7 5 6 3 16 23 29 24 32 1 1 23 11 28 30 17 35 36 41 42 34 44 43 37 11 38 25 26 27 39 40 18 19 31 1 21 22 33 20 13 14 15 4 2 sk2363 rev 4/2/2008 ecof-c cinnabon controller panel.

  • Page 23: Parts List

    Model no: ecof-c cinnabon control panel assembly full size electric convection oven parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not b...

  • Page 24: Parts List

    Model no: ecof-c cinnabon control panel assembly full size electric convection oven parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not b...

  • Page 25: Parts List

    Model no: ecof-c cinnabon control panel assembly full size electric convection oven parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not b...

  • Page 26

    Sk2367 rev. A 6/03/08 ecof: can & motor assemlby detail b 16 8 28 33 34 suggested marine parts stocking 1 2 3 4 5 6 7 8 9 10 14 17 4 18 19 20 21 13 15 22 13 23 25 26 27 35 28 30 31 27 32 33 34 29 24 15 16 11 12 13.

  • Page 27: Parts List

    Model no: ecof-c can & motor assembly commercial cinnabon full size electric convection oven parts list june 17, 2008 important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances ...

  • Page 28

    Ul file # e8138 20 wiring diagram 208/240

  • Page 29

    Ul file # e8138 21 wiring diagram 380/400

  • Page 30

    Ul file # e8138 22 wiring diagram 480

  • Page 31

    N i a m m o r f r o t c a t n o c s t h g i l n e v o c a v 0 4 2 l a n o i t p o m a e t s l o r t n o c y a l e r p u k c a b r e t u p m o c t h g i l h c t i w s h c t i w s r e w o p h c t i w s r e w o p o t f f o m a e t s m a e t s f f o r e t u p m o c o t r e z z u b d t r 0 4 2 m a e t s ...