1. DL manuals
  2. Lang
  3. Oven
  4. FCOF-AT
  5. Installation, Operation And Maintenance Instructions

Lang FCOF-AT Installation, Operation And Maintenance Instructions

Manual is about: lANG Electric Full Size Economy Convection Oven

Summary of FCOF-AT

  • Page 1

    Lang manufacturing 10 sunnen drive st. Louis, mo 63143 part #: 2m-w731 phone: 314-678-6315 fax: 314-781-2714 rev b www.Langworld.Com june 05, 2012 installation, operation, and maintenance instructions with troubleshooting electric full size economy convection oven models : fcofl-at (lower) fcof-at (...

  • Page 2: For Your Safety

    2 this manual must be retained for future reference. Read, understand and follow the instructions and warnings contained in this manual. For your safety do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Post in a prominent location ins...

  • Page 3: Table of Contents

    3 table of contents chapter page 1. Table of contents..........................................................................3 2. Read first ..........................................................................................4 3. Equipment description ...........................................

  • Page 4

    4 important read first important caution: each unit weighs 275 lbs. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. Cau...

  • Page 5

    5 important read first important warning: keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or fac...

  • Page 6: Equipment Description

    6 equipment description model: fcofl-at/fcof-at exterior construction the oven exterior dimensions are 36” (91.44cm) wide, 22” (55.88cm) high, 34” (86.36cm) deep. The front, back, and sides are constructed of stainless steel with an aluminized top and bottom. The door handle is constructed of polyca...

  • Page 7: Unpacking

    7 unpacking receiving the oven upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become apparent until the mer...

  • Page 8: Installation

    8 installation danger: this appliance must be grounded at the terminal provided. Failure to ground the appliance could result in electrocution and death. Warning: installation of the unit must be done by personnel qualified to work with electricity and plumbing. Improper installation can cause injur...

  • Page 9: Installation

    9 installation stacking the ovens stacking kits must be requested upon purchase. Remove all the plug buttons from the top of the lower oven. Remove the stacking kit from the oven compartment of one oven and install the 1 1/4-inch plastic bushing into the top of the lower oven. Tip the top oven backw...

  • Page 10: Operation

    10 caution: always keep the area near the appliance free from combustible materials. Caution: keep floor in front of equipment clean and dry. If spills occur, clean immediately, to avoid the danger of slips or falls. General operation the convection oven roasts and bakes in shorter time and at lower...

  • Page 11: Maintenance & Cleaning

    11 maintenance & cleaning cleaning warning: keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or f...

  • Page 12: Maintenance & Cleaning

    12 maintenance & cleaning trouble shooting symptoms what follows is a chart of symptoms, possible causes, and remedy’s to aid in diagnosing faults with the oven. Refer to the symptoms column to locate the type of failure then to the possible cause for the items to be checked and the remedy to column...

  • Page 13: Maintenance & Cleaning

    13 maintenance & cleaning tests notice: service on this, or any other, lang appliance must be performed by qualified personnel only. Consult your lang authorized service agent directory or call the factory at 1-800-807-9054, or www.Star-mfg.Com for the service agent nearest you. Warning: both high a...

  • Page 14: Maintenance & Cleaning

    14 maintenance & cleaning calibration calibration check place thermometer or thermocouple in the center of oven cavity. Set thermostat to 350 °f. Allow the oven to preheat for at least half an hour. Note cycle on temperatures and cycle off temperatures for 3 cycles. (red indicator light indicates wh...

  • Page 15: Maintenance & Cleaning

    15 maintenance & cleaning blower wheel secure oven from power. Inside the oven, remove the racks and right hand rack slide. Remove wing nut holding oven baffle. Remove oven baffle exposing the blower wheel. Loosen the two 1/4-20-set screws holding the blower wheel to the motor shaft. Using a three-f...

  • Page 16: Wiring Diagram 208/ 240

    16 wiring diagram 208/ 240

  • Page 17: Wiring Diagram 480

    17 wiring diagram 480

  • Page 18

    20 13 marine application 1 3 5 19 9 11 20 10 12 13 14 16 18 15 17 8 6 7 2 see can assy see controls assy see door assy 4 sk2288 rev. - 7/30/07 model: fcof & fcofl main assembly f6s main assembly.

  • Page 19: Parts List

    Model no: fcof & fcofl commercial & marine full size economy convection oven parts list june6,2008,revb important: when ordering, specify voltage or type gas desired page1 include model and serial number of1 some items are included for illustrative purposes only and in certain instances may not be a...

  • Page 20

    10 11 1 2 4 3 5 6 7 9 8 17 19 18 20 21 26 27 25 22 31 23 28 12 16 13 14 24 15 29 30 see can assy see controls assy see door assy 32 sk2289 rev. - 7/30/07 model: fcof-submarine main assembly f6s submarine main assembly.

  • Page 21: Parts List

    Model no: fcofat480sub submarine submarine full size economy convection oven parts list june6,2008,revb some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 1 q9-f6-160-3 1 toppartasub 2 q9-f6-160-4 1 toppartbsub 3 q...

  • Page 22

    1 2 5 4 6 7 8 9 10 11 12 13 11 10 9 8 3 sk2290 rev. - 7/30/07 model: fcof & fcofl door assembly f6s door assembly.

  • Page 23: Parts List

    Model no: fcof & fcofl door assembly commercial, marine & submarine full size economy convection oven parts list december11,2008,revb some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 1 ps-50301-50-1 1 doorstopass...

  • Page 24

    1 16 2 3 4 5 7 9 10 6 8 11 12 13 14 15 sk2291 rev. - 7/30/07 model: fcof-sub can assembly f6s can assembly.

  • Page 25: Parts List

    Model no: fcof & fcofl can assembly commercial, marine & submarine full size economy convection oven parts list april5,2010,revb some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 1 q9-f6-102-5 1 spotcantopsub fcof...

  • Page 26

    Rf21sm controls sk2292 rev. - 7/30/07 model: fcof-at & fcofl-at controls assembly f6s-at controls assembly 2 11 12 12 11 13 14 15 1 2 3 4 2 5 6 7 8 9 10 marine application.

  • Page 27: Parts List

    Model no: fcof & fcofl controls assembly commercial, marine & submarine full size economy convection oven parts list october4,2012,revb some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 1 2e-30701-03 1 contc2pol35...

  • Page 28

    2 3 4 1 5 6 19 18 17 16 7 8 9 10 11 2 12 13 14 15 sk2293 rev. - 7/30/07 model: fcof & fcofl motor fan assembly f6s motor fan assembly.

  • Page 29: Parts List

    Model no: fcof & fcofl motor fan assembly commercial, marine & submarine full size economy convection oven parts list april5,2010,revb some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 1 2c-20104-18 4 scrwhxhdcp5/...

  • Page 32

    Star international holdings inc. Company star - holman - lang - wells - bloomfield - toastmaster 10 sunnen drive, st. Louis, mo 63143 u.S.A. (314) 678-6303 www.Star-mfg.Com.