Lang manufacturing company 6500 merrill creek parkway everett, wa 98203 phone: 1-800-224-5264 fax: 1-425-349-2733 www.Langworld.Com ©copyright 2000 service manual for the lang models: lg-24s, lg-36s, lg-48s, lg-60s, lg-72s, lg-24, lg-36, lg-48, lg-60, lg-72 xl-24, xl-36, xl-48 pb-12, pb-24.
1 table of contents chapter page 1. Table of contents .......................................................................1 2. Read first ........................................................................................2 3. Equipment description................................................
2 important read first important caution: each unit is extremly heavy. For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. ...
3 important read first important warning: keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or fac...
4 equipment description electric griddle exterior ♦ griddle the griddle dimensions are 17” (43.18cm) high, 30” (76.20cm) deep, and width is dependent on the actual model number. The sides, bottom, and rear wall are constructed of double wall stainless steel, which allows closer installation to combu...
5 installation receiving the griddle upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become apparent until t...
6 installation cont’d phasing lg / lgs all griddles are shipped from the factory set up for a three-phase service. Rearrange the wires in the power supply terminal block to convert the griddle to single phase. Rephasing the griddle is not chargeable to lang manufacturing company as warranty. To conv...
7 start-ups electric griddles electric griddle start-up 1) verify connections at plug and terminal block 2) incoming volt - single phase l1-l2______ three phase l1-l2______ l2-l3______ l3-l1______ 3) amp draw l1______ l2______ l3______ 6) verify actual temperature at 350 °f ________ °f. Note: instal...
8 general general the suggested time and temperature chart (below) is provided as a guide for the products listed only. Caution: always keep the area near the appliance free from combustible materials. Caution: keep floor in front of equipment clean and dry. If spills occur, clean immediately, to av...
9 general cont’d operations an understanding of how the griddle sections are controlled will be a valuable aid in loading your griddle. Each 12 inch section of your griddle is independently controlled by a temperature controller. The temperature control sensor is mounted in the center of each cookin...
10 sequence of operation lg griddle 208/ 240 vac to thermostat. Thermostat turned on. 208/ 240 vac to elements. Lgs griddle power switch turned to on: 208/240 vac to poles of each sections contactor. 240/24 transformer energized. Individual section switch turned to on. 24vac across pins 9 & 7 on com...
11 troubleshooting lg griddle: problem solution whole griddle will not heat confirm that circuit breakers are on. Confirm that griddle is connected properly. One section will not heat confirm that elements have power. Confirm that thermostat is operating properly. Lgs griddle problem solution whole ...
12 troubleshooting cont’d pane bella problem solution grill will not heat confirm that incoming power is correct. Check thermostat for normal operation. Check elements for proper operation. Confirm that there are no breaks in the wires. Xl hood problem solution hood will not heat confirm that incomi...
13 technical data element resistance 208 / 240 volt i/s 11030-29 lg griddle 9 Ω / 9.6 Ω 23 / 25 amps 208 volt o/s 11030-30 lg griddle 29 Ω 8 amps 480 volt 11030-31 lg griddle 38 Ω 12.5 amps 120 volt bottom 11030-51 pb griddle 13.5 Ω 9 amps 120 volt top 11030-50 pb griddle 17 Ω 7 amps 208/240 volt bo...
14 technical data cont’d probe resistance temp resistance volt drop temp resistance volt drop 70 ° 556 Ω 1.11 290 ° 881 Ω 1.76 80 ° 569 Ω 1.14 300 ° 897 Ω 1.79 90 ° 583 Ω 1.17 310 ° 914 Ω 1.83 100 ° 596 Ω 1.19 320 ° 931 Ω 1.86 110 ° 610 Ω 1.22 330 ° 948 Ω 1.90 120 ° 623 Ω 1.25 340 ° 965 Ω 1.93 130 °...
15 wiring diagram lg 208/240
16 wiring diagram lg 480
17 wiring diagram lg-s 208/240
18 wiring diagram lgs 480
19 pb-24 208/240 wiring diagram.
20 pb-12 120 wiring diagram.
21 pb-12, 208/240 wiring diagram.
22 xl hood.
23 lg-24, lg-36, lg-48, lg-60, lg-72 electric griddle description part no. Element griddle 380 volt 5991 watts 11030-04 element griddle 208/240 volt i/s 4500/5991 watts 11030-29 element griddle 208 volt o/s 1491 watts 11030-30 element griddle 480 volt 5991 watts 11030-31 thermostat 550 °f griddle (g...
24 lg-24s, lg-36s, lg-48s, lg-60s, lg-72s electric selectronic griddle description part no. Element griddle 208/240 volt i/s 4500/5991 watts 11030-29 element griddle 208 volt o/s 1491 watts 11030-30 element griddle 480 volt 5991 watts 11030-31 switch toggle on-off 30303-06 switch temperature control...
25 pb-24 electric pane bella griddle description part no. Element lower 208/240 volt 900 watts 11030-40 element upper 208/240 volt 720 watts 11030-41 stud grill plate 10-24 x 1” 20101-13 stud grill plate 10-24 x 1 1/4” 20101-14 screw, crumb tray knob 20101-24 thermostat 500 °f griddle (before a-8600...
26 pb-12 electric pane bella griddle description part no. Element lower 115 volt 900 watts 11030-51 element upper 115 volt 720 watts 11030-52 stud grill plate 10-24 x 1” 20101-13 stud grill plate 10-24 x 1 1/4” 20101-14 screw, crumb tray knob 20101-24 thermostat 650 °f griddle 30402-36 terminal stri...
27 xl-24, xl-36, xl-48, xl-60, xl-72 electric quartz combo griddle description part no. Element griddle 208/240 volt i/s 4500/5991 watts 11030-29 element griddle 208 volt o/s 1491 watts 11030-30 element griddle 480 volt 5991 watts 11030-31 quartz lamp 208v 1200 watts 2ft socket type (serial prefix a...