M anual 1192039 (10/09) $30.00 i nfrared c ompact b roiler m anual s ection sr owner’s manual infrared compact broiler warning improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury, or death. Read installation, operation, and maintenance instruction...
S afety p recautions i nfrared c ompact b roiler p age 2 of 24 o wner ’ s m anual 1192039 (10/09) safety precautions before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure t...
I nfrared c ompact b roiler i ntroduction o wner ’ s m anual 1192039 (10/09) p age 3 of 24 i ntroduction congratulations! You have purchased one of the finest pieces of heavy-duty commercial cooking equipment on the market. You will find that your new equipment, like all lang equipment, has been des...
S pecifications i nfrared c ompact b roiler p age 4 of 24 o wner ’ s m anual 1192039 (10/09) s pecifications notice local codes regarding installation vary greatly from one area to another. The national fire protection association, inc. States in its nfpa 96 latest edition that local codes are the “...
I nfrared c ompact b roiler s pecifications o wner ’ s m anual 1192039 (10/09) p age 5 of 24 d imensions figure 2 model width (w) height (h) depth (d) lgr36-nfr lgr36-rad 36″ (915) 21″ (533) 15.5″ (394) lgr48-nfr lgr48-rad 48″ (1220) 21″ (533) 15.5″ (394).
S pecifications i nfrared c ompact b roiler p age 6 of 24 o wner ’ s m anual 1192039 (10/09) v entilation warning improper ventilation can result in personal injury or death. Ventilation, which fails to properly remove flue products, can cause headaches, drowsiness, nausea, or could result in death....
I nfrared c ompact b roiler o peration o wner ’ s m anual 1192039 (10/09) p age 7 of 24 o peration danger explosion hazard in the event a gas odor is detected, shut down equipment at the main shutoff valve. Immediately call the emergency phone number of your gas supplier. Caution if the broiler pilo...
O peration i nfrared c ompact b roiler p age 8 of 24 o wner ’ s m anual 1192039 (10/09) l ighting a fter g as h as b een s hut o ff when turning on the main gas supply to an appliance or a group of appliances, do the following: 1. Make sure that all the control valves and power switches of all the a...
I nfrared c ompact b roiler c leaning & m aintenance o wner ’ s m anual 1192039 (10/09) p age 9 of 24 c leaning & m aintenance warning shut off the gas supply to the appliance before cleaning or performing maintenance on any gas appliance. The appliance may be equipped with a restraint device to lim...
C leaning & m aintenance i nfrared c ompact b roiler p age 10 of 24 o wner ’ s m anual 1192039 (10/09) s tainless -s teel s urfaces to remove normal dirt, grease and product residue from stainless steel surfaces that operate at low temperature, use ordinary soap and water (with or without detergent)...
I nfrared c ompact b roiler i nstallation o wner ’ s m anual 1192039 (10/09) p age 11 of 24 i nstallation notice these installation procedures must be followed by qualified personnel or warranty will be void. Local codes regarding installation vary greatly from one area to another. The national fire...
I nstallation i nfrared c ompact b roiler p age 12 of 24 o wner ’ s m anual 1192039 (10/09) s tep 2 a : m ount on f lue r iser of r ange the infrared compact broiler mounts over a range. A special flue riser is shipped with the broiler and range. Depending on the shipping requirements, the broiler, ...
I nfrared c ompact b roiler i nstallation o wner ’ s m anual 1192039 (10/09) p age 13 of 24 s tep 2 b : m ount on w all the infrared compact broiler is installed by first attaching a mounting bracket to the wall, then attaching the broiler to the bracket. 1. Attach the wall-mount assembly to the wal...
I nstallation i nfrared c ompact b roiler p age 14 of 24 o wner ’ s m anual 1192039 (10/09) s tep 2 c : a ttach c ountertop l egs 1. Install each leg by screwing them into the threaded holes in the bottom of the base. 2. Stand the broiler on its legs and position to minimum clearances specified on s...
I nfrared c ompact b roiler i nstallation o wner ’ s m anual 1192039 (10/09) p age 15 of 24 caution all pipe joints and connections must be tested thoroughly for gas leaks. Use only soapy water for testing on all gases. Never use an open flame to check for gas leaks. All connections must be checked ...
I nstallation i nfrared c ompact b roiler p age 16 of 24 o wner ’ s m anual 1192039 (10/09) s tep 5: c heck the i nstallation 1. Check that all screws and bolts are tightened. 2. Check that gas connection has been made correctly. 3. Move the broiler into the final position at which it will be operat...
I nfrared c ompact b roiler s ervice o wner ’ s m anual 1192039 (10/09) p age 17 of 24 s ervice warning adjustments and service work may be performed only by a qualified technician who is experienced in, and knowledgeable of, the operation of commercial cooking equipment. To assure your confidence, ...
S ervice i nfrared c ompact b roiler p age 18 of 24 o wner ’ s m anual 1192039 (10/09) a ccess to s erviceable p arts some serviceable parts are only accessible by removing body side panels and the front panel. The main front panel is fastened with six sheet-metal screws. To remove the front panel, ...
I nfrared c ompact b roiler s ervice o wner ’ s m anual 1192039 (10/09) p age 19 of 24 a djustment of b roiler b urners the infra-red burners require no air adjustment after they have left the factory. If a major change in burner operation is noticed, check for obstruction of airflow, around the ori...
S ervice i nfrared c ompact b roiler p age 20 of 24 o wner ’ s m anual 1192039 (10/09) p arts for lgr36-nfr and lgr36-rad u nits the following table describes the serviceable parts for lgr36-nfr and lgr36-rad units. For parts not listed, contact a lang authorized parts distributor or a lang authoriz...
I nfrared c ompact b roiler s ervice o wner ’ s m anual 1192039 (10/09) p age 21 of 24 p arts for lgr48-nfr and lgr48-rad u nits the following table describes the serviceable parts for lgr48-nfr and lgr48-rad units. For parts not listed, contact a lang authorized parts distributor or a lang authoriz...
I nfrared c ompact b roiler p age 22 of 24 o wner ’ s m anual 1192039 (10/09) notes:.
I nfrared c ompact b roiler o wner ’ s m anual 1192039 (10/09) p age 23 of 24 notes:.
I nfrared c ompact b roiler p age 24 of 24 o wner ’ s m anual 1192039 (10/09) infrared compact broiler flue-riser mount, wall mount, or countertop a product with the lang name incorporates the best in durability and low maintenance. We all recognize, however, that replacement parts and occasional pr...