1. DL manuals
  2. Lang
  3. Ranges
  4. R60S
  5. Installation, Operation, Maintenance, & Troubleshooting

Lang R60S Installation, Operation, Maintenance, & Troubleshooting

Manual is about: Standard Bake Oven Range

Summary of R60S

  • Page 1

    Star manufacturing international 10 sunnen drive st. Louis, mo.63143-3800 part number: 2m-w822 ph: 314-781-2777 fax: 314-781-2714 rev. B www.Star-mfg.Com october 8, 2008 installation, operation, maintenance, & troubleshooting model: r60s standard bake oven range.

  • Page 2: For Your Safety

    2 this manual must be retained for future reference. Read, understand and follow the instructions and warnings contained in this manual. For your safety do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Post in a prominent location ins...

  • Page 3: Table of Contents

    Table of contents 3 chapter page 1. Table of contents .................................................................................................3 2. Read first..............................................................................................................4 3. Equipment descripti...

  • Page 4: Warnings

    Warnings 4 caution: the range weighs 900 lbs. (408 kilograms). For safe handling, installer should obtain help as needed, or employ appropriate materials handling equipment (such as a forklift, dolly, or pallet jack) to remove the unit from the skid and move it to the place of installation. Caution:...

  • Page 5: Warnings

    Warnings 5 warning keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution: most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Wear rubber gloves, goggles/face shield and protective clothing. Carefully read the warn...

  • Page 6: Equipment Description

    Equipment description 6 double bake oven range exterior the range dimensions are 30” (76.2cm) high, 35” (89.0cm) deep, and 60” (152.5cm) wide. The sides, bottom, and rear wall are constructed stainless steel. The range surface can come in 7 different configurations. Controls the r60s series range is...

  • Page 7: Unpacking

    Unpacking 7 receiving the oven upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become apparent until the mer...

  • Page 8: Installation

    Installation 8 installation danger: this appliance must be grounded at the terminal provided. Failure to ground the appliance could result in electrocution and death. Warning: installation of the unit must be done by personnel qualified to work with electricity. Improper installation can cause injur...

  • Page 9: Operation

    Operation 9 prior to putting any range or oven into full time operation at normal cooking temperatures, it must be thoroughly "seasoned" or dried out. Moisture absorption in the closed spaces, in the insulation and even inside the heating elements can cause future trouble if not properly treated. Be...

  • Page 10: Operation

    Operation 10 ovens warning always keep the area near the appliance free from combustible materials.Keep floor in front of equipment clean and dry. If spills occur, clean immediately, to avoid the danger of slips or falls. The range ovens must be thoroughly, preheated before satisfactory baking can b...

  • Page 11: Operation Cont'D.

    Operation cont'd. 11 range top consists of the various top arrangements, depending on specific model purchased: 12" x 24" hot plate controlled by high temperature thermostats. Temperature ranges from 0 °f- 850 °f. Recommended: stock pots and heavy kettle work. Round french plates, controlled by indi...

  • Page 12: Maintenance and Cleaning

    Maintenance and cleaning 12 cleaning warning keep water and solutions out of controls. Never spray or hose control console, electrical connections, etc. Caution most cleaners are harmful to the skin, eyes, mucous membranes and clothing. Precautions should be taken to wear rubber gloves, goggles or f...

  • Page 13: Troubleshooting

    Troubleshooting 13 symptom cause corrective action no power to oven turn on power internal breaker tripped reset breaker defective thermostat verify calibration defective 3-heat switch failed 3-heat or 6-heat switch* oven will not heat defective oven element remove the wires and check for continuity...

  • Page 14

    Sk2316 rev. - 9/26/07 model: r60s electric 60” range 26 23 25 24 38 46 39 40 37 44 36 45 1 13 14 16 17 21 20 19 15 35 18 12 3 2 5 4 6 7 8 9 10 11 28 27 29 22 41 42 46 43 34 33 34 32 31 30 oven controls range controls.

  • Page 15: Parts List

    Model no: r60s-ata, r60s-atb, r60s-atc, r60s-atd, r60s-ate, r60s-atf, r60s-atg, r60s-ath commercial & marine electric 60” range parts list october 8, 2008, rev b important: when ordering, specify voltage or type gas desired page 1 include model and serial number of 4 some items are included for illu...

  • Page 16: Parts List

    Model no: r60s-ata, r60s-atb, r60s-atc, r60s-atd, r60s-ate, r60s-atf, r60s-atg, r60s-ath commercial & marine electric 60” range parts list october 8, 2008, rev b some items are included for illustrative purposes only and in certain instances may not be available. Description part number key number 8...

  • Page 17: Parts List

    Model no: r60s-ata, r60s-atb, r60s-atc, r60s-atd, r60s-ate, r60s-atf, r60s-atg, r60s-ath commercial & marine electric 60” range parts list october 8, 2008, rev b important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustra...

  • Page 18: Parts List

    36 2e-31800-04 2 cb 480v 50a 3 pole r60s-ata480/440m/480m, r60s-atb480m, r60s-atc-480/440m/480m, r60s-atd-480/440m/480m, r60s-ate480m, r60s-atf-480, r60s-atg-480/480m, r60s-ath-480 37 2e-30304-09 2 swtrot 6 heat+off208/240v r60s-atb-208/240/208m/240m, r60s-atc-208/240/240m/440m/480/480m, r60s-atd-20...

  • Page 19: Wiring Diagram 208/240 Volt

    Wiring diagram 208/240 volt 16.

  • Page 20: Range Top Wiring

    Range top wiring 17 1. Griddl e and t op plate element 2. Pilot light 3. 450 ° g riddl e therm o stat 4. Circuit brea kers 5. Fren ch pl ate 6. 6-heat switch 7. Hot top 8. 800 ° hot top thermos tat. Griddle hot top french p late.

  • Page 21: Wiring Diagram 480 V

    Wiring diagram 480 v olt 18.

  • Page 24

    Star manufacturing 10 sunnen drive, st. Louis, mo 63143 u.S.A. (800) 807-9054 (314) 781-2777 parts & service (800) 807-9054 www.Star-mfg.Com.