1. DL manuals
  2. Lanner Electronics
  3. Desktop
  4. fw-3600
  5. User Manual

Lanner Electronics fw-3600 User Manual

Manual is about: intel ixp 42x

Summary of fw-3600

  • Page 1

    Fw-3600 series mini desktop intel ixp 42x network security platforms user’s manual.

  • Page 2: Copyright and Disclaimers

    Ii copyright and disclaimers © copyright 2004 - lanner electronics inc. All rights reserved the contents in this publication have been thoroughly checked and considered accurate. The publisher and manufacturer of this product, lanner electronics, is not responsible for any violation of patents or ot...

  • Page 3: Safety Instructions

    Iii safety instructions the following information relates to the safety of installation and maintenance personnel. Read all instructions before attempting to unpack, install or operate this equipment, especially before connecting the power adapter. Please keep the following in mind as you unpack and...

  • Page 4: About This Manual

    Iv getting technical assistance should you encounter questions or problems with your fw-3600, lanner electronics is ready to assist you within the guidelines of our product support programs. First, check the electronic product documentation for assistance. If you still cannot find the solution to yo...

  • Page 5: Table of Contents

    V table of contents copyright and disclaimers..................................................................................Ii trademark acknowledgments ............................................................................Ii radio frequency emissions notice....................................

  • Page 6: C H A P T E R  1

    1 c h a p t e r 1 getting started 1.1 introduction figure 1 – fw-3600 outlook the fw-3600 is a mini desktop intel ixp based firewall platform equipped with an intel ixp 422/425 processor. A cost-effective and fanless solution of its kind, it comes with a pre-installed booting code and linux kernel. ...

  • Page 7: 1.2 Technical

    2 1.2 technical specifications chassis: − construction: bench top chassis − chassis material: spcc 1.0t − chassis color: pms 877c control board: − em-434 − dimensions: 147mm x 209mm processor: − intel ixp425, 533mhz (fw-3600a) − ixp422, 266mhz (fw-3600b) flash ram: onboard 16mb nor flash rom system ...

  • Page 8: 1.3 Packing

    3 1.3 packing contents carefully unpack your package and make sure that you have the following items. Fw-3600 firewall platform console cable 1.8 meters long cross-over ethernet cable 1.8 meters long straight-through ethernet cable face panel name plate label power adapter drivers and user’s manual ...

  • Page 9: 1.4.2 Board Layout

    4 1.4.2 board layout figure 3 – em-434 jumpers and connectors 1.4.3 jumper settings the onboard jumper settings of em-434 are custom-tailored to fit the fw-3600 functionality. Changing the jumper settings may result in system malfunction or unforeseen damages. 1.4.4 connector pin assignments ps4s1: ...

  • Page 10

    5 gpioa1: 2x4 gpio pin header pin no. Description pin no. Description 1 gpio14 2 gnd 3 gpio7 4 gnd 5 gpio6 6 gnd 7 gpio5 8 gnd ejc1: ejprob connector pin no. Description pin no. Description 1 gnd 2 ejtag_tck 3 gnd 4 ejtag_tms 5 gnd 6 ejtag_tdi 7 gnd 8 ejtag_tdo lana1~ lana3: type 1 (rj-45) descripti...

  • Page 11

    6 lan4pa1: 4 x rj-45 ports pin no. Description 1 rx+ port1 2 rx- 3 tx+ 4 t45 5 t45 6 tx- 7 t78 8 t78 9 rx+ port2 10 rx- 11 tx+ 12 t45 13 t45 14 tx- 15 t78 16 t78 17 rx+ port3 18 rx- 19 tx+ 20 t45 21 t45 22 tx- 23 t78 24 t78 25 rx+ port4 26 rx- 27 tx+ 28 t45 29 t45 30 tx- 31 t78 32 t78 41 gnd 42 gnd.

  • Page 12

    7 pcib1~2:124-pin mini pci sockets pin no. Description pin no. Description 1 tip 2 ring 3 8pmj-3 4 8pmj-1 5 8pmj-6 6 8pmj-2 7 8pmj-7 8 8pmj-4 9 8pmj-8 10 8pmj-5 11 led1_grnp 12 led2_yelp 13 led1_grnn 14 led2_yelp 15 chsgnd 16 reserved 17 int-b 18 +5v 19 +3.3v 20 int-a 21 reserved 22 reserved 23 grou...

  • Page 13

    8 pin no. Description pin no. Description 83 ground 84 ad9 85 ad8 86 c_be-0 87 ad7 88 +3.3v 89 +3.3v 90 ad6 91 ad5 92 ad4 93 reserved 94 ad2 95 ad3 96 ad0 97 +5v 98 reserved-wip 99 ad1 100 reserved-wip 101 ground 102 ground 103 ac_sync 104 m66en 105 ac_sdata_in 106 ac_sdata_out 107 ac_bit_clk 108 ac...

  • Page 14: 1.5.1 Mechanical Dimensions

    9 1.5 fw-3600 mini desktop firewall mechanisms this section of the manual describes the mechanical and device nomenclature of fw-3600. 1.5.1 mechanical dimensions the illustration below identifies the physical measurements of the fw-3600. The measurement unit used is in millimeters (mm). Figure 4 – ...

  • Page 15: 1.5.3 Rear View

    10 face panel led status and behavior the following table lists and explains the behavior of each led on the fw-3600 front panel. Led color status description on when fw-3600 power is switched on power green off no power connected on when gpio 15 is programmed and set to a value of “0” status (progr...

  • Page 16: C H A P T E R  2

    11 c h a p t e r 2 em-434 image download this chapter explains the procedures when configuring the fw-3600, including its os and applications. The following sections and each procedure are highly required to achieve your technical requirements. 2.1 pre-installed linux software the pre-installed linu...

  • Page 17: 2.2 Boot-Up

    12 2.2 boot-up conditions once the fw-3600 console port is connected to a console pc, there will be two choices available mid-way during the fw-3600 system boot up: 1 enter os (default): “1” allows access into fw-3600 os and runs the firewall 2 enter redboot: “2” allows entry to redboot for download...

  • Page 18

    13 the displayed screen will show the figure below after selecting option “2”..

  • Page 19: 2.3 Downloading

    14 2.3 downloading redboot there are two standard boot code file names bundled with your fw-3600. Ixp422-based fw-3600: jfixp266.Exe ixp425-based fw-3600: jfixp533.Exe downloading the redboot is required when you intend to perform the following: modify the existing redboot, replace the entire redboo...

  • Page 20: 2.4.1 Procedures

    15 2.4 downloading linux and ramdisk note: downloading of linux and ramdisk are only possible using the rtl8305sb ethernet port: lana3. The bundled linux kernel of fw-3600 is an open source architecture. This section is of vital use for programmers who wish to set up the fw-3600 into a tft server. D...

  • Page 21: A P P E N D I X  A

    16 a p p e n d i x a driver information this appendix contains a rundown of the drivers contained in the drivers and user’s manual disk. The drivers of each component are vital for programmers when developing their proprietary kernels. Nor flash dram realtek rtl8100b realtek 8305sb mini pci socket r...

  • Page 22: Terms and Conditions

    Terms and conditions date:2004.07.08 warranty policy 1. All products are warranted against defects in materials and workmanship for a period of two years from the date of your purchase. 2. The buyer will bear the return freight charges for goods returned for repair within the warranty period; wherea...

  • Page 23: Rma Service Request Form

    Rma service request form when requesting rma service, please fill out this rma service request form. Without this form your rma will be rejected!!! Rma no: reasons to return: □ repair(please include failure details) □ testing purpose company: contact person: phone no. Purchased date: fax no.: applie...

  • Page 24

    Pexnsd01-040709 version 1.0 printed and published in taiwan.