- DL manuals
- Magikitch'n
- Broiler
- 600 CE SERIES
- Installation And Operation Manual
Magikitch'n 600 CE SERIES Installation And Operation Manual
Summary of 600 CE SERIES
Page 1
31-01-12962 rev b l25-004 rev 0 5-2001 600 ce series gas broiler installation – operation - maintenance magikitch’n p.O. Box 501 concord nh 03302-0501 509 route 3a bow nh 03304 800-258-3708 603-225-6684 fax 603-225-8497 www.Magikitchn.Com.
Page 2: Important
Important this appliance is intended for professional use by qualified personnel only, not for individual/home use. The information contained in this manual is important for the proper installation, use, and maintenance of this unit. Adherence to these procedures and instructions will result in sati...
Page 3
For installation or maintenance, contact your local dealer or authorized service agent. Installation or service by other than magikitch’n authorized service agencies or personnel may void warranty coverage. Call pitco frialator technical support at 603-225-6684 who will put you in touch with the pro...
Page 4
Installation delivery and location broiler assembly gas connection and conversion operation broiler set up lighting instructions general charbroiling tips maintenance cleaning and preventative maintenance accessory and replacement parts list 1-01-12962 rev b l25-004 rev 0 5-2001 4.
Page 5
Installation delivery and location delivery each broiler was carefully inspected and packaged before being tendered to the carrier. Upon delivery of your new broiler: • uncrate the broiler and check for damage. Most carriers will accept claims for damage if they are notified within seven days of del...
Page 6
Installation broiler assembly note: this appliance shall be installed in accordance with current regulations and used only in a well– ventilated space. Refer to these instructions before installing and using this appliance. Note: installation and connection must be performed by a qualified installer...
Page 7
Installation gas connection an adequate gas supply is required for proper broiler performance. With all burners on “high”, the manifold pressure should not show any appreciable drop. Fluctuations of more than 25% will create pilot problems and affect burner operation. Warning!! This unit must be con...
Page 8
Operation gas connection and conversion information for 600-ce model broilers supply burner main air appliance gas gas pressure pressure burner shutter country category category type (mb) (mb) (mm) (mm) nl ii2l3b/p 2l g25 25 10.7 1.85 open 3b/p g30 30 29.5 1.02 open ii2l3p 3p g31 50 36.5 1.02 open b...
Page 9
Operation broiler set up note: after initial installation, the unit must be thoroughly cleaned prior to operation. Refer to the maintenance section of this manual for cleaning instructions. Top cooking grid the cooking grid has two positions, flat or tilted. • to place the grid in the tilted positio...
Page 10
Operation lighting instructions 1. Turn all burners to off. 2. Remove the top grid. 3. Remove the last radiant on the right. 4. Turn the shut off valve to on. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds. Light the runner tube. Do not release the reset butt...
Page 11
Operation general charbroiling tips preheating the broiler must be preheated before cooking. We recommend a preheat time of 10-15 minutes. After preheating, the broiler will be hot enough to cook on without sticking and will produce the proper searing effect. Cook zones there are three separate cook...
Page 12
Operation general charbroiling tips marking product 1. Place the product diagonally on the back 1/3 of a clean broiler grid. Note: for white fleshed product (chicken, fish) be sure marking product to baste the product and brush the grid with pure vegetable oil. 2. When the product is marked, rotate ...
Page 13
Maintenance cleaning and preventative maintenance proper maintenance of your broiler will prolong the life of the appliance and ensure proper performance. Daily cleaning top grid 1. Remove the grid. 2. Use the magikitch’n scraper to remove any cooking debris from the rods, especially the underside. ...
Page 14
Maintenance accessory and replacement parts list note: this is a partial parts list for parts not shown here, call magikitch’n or a magikitch’n service representative. Always give the model and serial numbers of your unit when ordering parts and accessories. Item description 1 top grid 2 radiant 3 b...
Page 15
Maintenance 31-01-12962 rev b l25-004 rev 0 5-2001 11 maintenance figure 7 31-01-12962 rev b l25-004 rev 0 5-2001 11.
Page 16: Smb
31-01-12962 rev b l25-004 rev 0 5-2001 12 magikitch’n any 180 penn am dr nsylvania 18951-2435 usa telepho x: (215) 538-3644 hn.Com a maytag comp ive quakertown, pen ne 800-441-1492 fa website: www.Magikitc © 2000– magikitch’n magikitch’n p.O. Box 501 concord nh 03302-0501 509 route 3a bow nh 03304 8...
Page 17
Table of contents 1. Lighting instructions 2. Initial set up 3. Smb 600 series illustration 4. Accessories and parts list 31-01-12962 rev b l25-004 rev 0 5-2001 13.
Page 19
1. Lighting instructions smb 600 series -ce models with safety pilot 1. Turn all burners to off. 2. Remove the top grid. 3. Turn the shut off valve to on. 4. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds. Light the runner tube. Do not release the reset button. ...
Page 20
Smb 600 series -ce models with safety pilot 2. Initial set-up smb 600 series-ce models coal support - the coal support must be installed so that it is pushed against the back wall of the unit. This creates an air gap over the runner tube to allow proper ventilation. Coals - use only magicoals suppli...
Page 21
3. Typical smb 600 series illustration (model smb 636 shown) note: your unit may vary from this typical diagram. 31-01-12962 rev b l25-004 rev 0 5-2001 17.
Page 22
4. Accessory / parts list for smb 600 series models not all parts are illustrated, nor are all parts are listed. If you need a part that is not listed here, call magikitch’n for a quote. Always have your model and unit serial numbers available when phoning or ordering. These parts sold thru our deal...
Page 23
Original equipment limited warranty magikitch'n appliances are designed to give you long and satisfactory service if installed and operated in accordance with our instructions. We warrant this appliance against defective workmanship and material for one year form installation or 15 months from ship ...