L25-003 rev 2 4/4/2002 commercial cooking appliances model lpg-30 & lpg-60 self-contained propane fueled outdoor charbroiler use and care instructions retain this manual for future reference magikitch’n p.O. Box 501 concord nh 03302-0501 509 route 3a bow nh 03304 800-258-3708 603-225-6684 fax 603-22...
L25-003 rev 2 4/4/2002 table of contents 1. Safety information 1 2. Charbroiler assembly and installation 4 3. Assembly diagram 5 4. Installing the side rack & propane tank on a 30” unit 6 5. Connecting the gas lines to the propane tanks 7 6. Operating, lighting and cleaning instructions 8 7. Burner...
L25-003 rev 2 4/4/2002 1 1. Safety information safety instructions should be obtained from your local gas supplier and posted in a prominent location near the area of operation. These instructions are to be followed in the event of a gas leak. • this unit shall only be operated outdoors. • this comm...
L25-003 rev 2 4/4/2002 2 1. Safety information (continued) • unit intended for mobile, non-permanent installation only. Adequate clearances (minimum of 3’) in front of the unit for servicing and proper operation must be maintained. Use only the legs and casters supplied with unit. Do not block the f...
L25-003 rev 2 4/4/2002 3 1. Safety information (continued) • caution: the gas pressure regulator(s) provided with this appliance must be used. The regulator is set for an outlet pressure of 10 inches water column. • do not locate this appliance under overhead unprotected combustible surfaces. • do n...
L25-003 rev 2 4/4/2002 4 2. Charbroiler assembly and installation these unassembled parts should be included in your charbroiler package (figure 1): item number description 1 cooking grid (s) 2 radiants 6 frame assembly 8 runner tube cover(s) 9 water tub(s) 10 base 25 leg & swivel lock caster assemb...
L25-003 rev 2 4/4/2002 5 3. Assembly diagram figure 1.
L25-003 rev 2 4/4/2002 6 4. Installing the side rack and tank on the residential 30” unit (some steps here will not be necessary if this is a new unit being assembled under section 2) a. Remove the charbroiler from the base unit and turn the base unit over to work on it. B. The mounting rack must be...
L25-003 rev 2 4/4/2002 7 connecting the gas lines to the propane tanks a. New propane tanks are shipped empty with no pressure and must be purged of air and filled with propane per npga (national propane gas association) recommendations prior to initial use. B. Tank rack(s) must be mounted to the ch...
L25-003 rev 2 4/4/2002 8 7. Operation, lighting and cleaning • assemble unit per installation and assembly instructions. • fill water tubs to within ½” of top edges (this will control grease flare-ups, provide for ease of cleaning and keep cooked foods moist). Re-fill tubs with water when they evapo...
L25-003 rev 2 4/4/2002 9 cleaning the unit • clean the unit regularly after use. • cooking top grid: after removing from the unit, use warm soapy water and a stiff bristled brush or plastic pad. Cooking grid (top grid) must be removed to steam clean or pressure wash. Do not use steel wool or abrasiv...
L25-003 rev 2 4/4/2002 10 9. Charbroiler illustration figure 10
L25-003 rev 2 4/4/2002 11 charbroiler parts list lpg-60 lpg-30 item # description qty part no. Qty part no. 1 cooking top grid, heavy duty 2 3912-0525300 1 3912-0525300 cooking top grid, std (shown) 2 4100-0280400 1 4100-0280400 2 radiant 8 5403-0500300-c 4 5403-0500300-c 3 screw & nut, ¼-20 x 1-1/2...
L25-003 rev 2 4/4/2002 12 10. Tank rack illustration tank rack parts list lpg-30 residential item # description qty part no. 1 wing stud & stop nut 2 5299-1154900 2 upper hold down bracket 1 5414-1117600 3 tank rack body 1 5414-1117800 4 lower tank bracket 1 5414-1117700 5 keps screw & acorn nut 3 4...
L25-003 rev 2 4/4/2002 13 12. Warranty: original equipment warranty (for u.S. And canada) magikich’n warrants to each original buyer that its electrically-heated or gas-fired charbroilers / outdoor grills will be free from defects in material and workmanship for the period specified below. Magikitch...
