Summary of MDP300
Page 1
Portable trash pumps mdp300 operating & parts manual.
Page 2: Magnum Products Llc
2 introduction this manual provides information and procedures to safely operate and maintain the engine and pump. For your own safety and protection from physical injury, carefully read, understand, and observe the safety instructions described in this manual. The information contained in this manu...
Page 3
3 table of contents page introduction ............................................................................................................................ 2 table of contents .................................................................................................................. 3 ...
Page 4
4 safety notes this is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. This manual contains dangers, warnings, cautions, notices and notes which must be followed to prevent the ...
Page 5
5 engine safety internal combustion engines present special hazards during operation and fueling! Failure to follow the safety guidelines described below could result in severe injury or death. Read and follow all safety warnings described in the engine operator's manual. A copy of this manual was s...
Page 6
6 unit serial number location refer to the location illustrated below to find the unit id tag. Important information, such as the unit serial and model numbers are found on this tag. Record the information from this tag, so it is available if the tag is lost or damaged. When ordering parts or reques...
Page 7
7 specifications read this manual carefully before attempting to use this pump. The potential for property damage, personal injury or death exists if this equipment is misused or installed incorrectly. Read all of the manuals included with this unit. Each manual details specific information regardin...
Page 8
8 component locations hose recommendations hoses • suction hoses must be rigid enough not to collapse when pump is operating. • discharge hoses need to be thin-walled and collapsible. Rigid hoses may also be used as discharge hoses. Note: a small air leak from the suction hose will prevent the pump ...
Page 9
9 starting the pump before starting the pump, add engine oil and gasoline. See page 11 for instructions on how to properly fill the unit with engine oil. 1. Attach suction and discharge hoses. Danger carbon monoxide: using a generator indoors can kill you in minutes! 2. Fill up pump casing with wate...
Page 10
10 maintenance schedule the following maintenance schedule should be followed to ensure proper performance of the unit. Daily maintenance checks and tips • check the engine oil level daily before starting engine. • do not start the pump if the oil level is low! The normal operating level for the eng...
Page 11
11 adding engine oil 1. Place the pump on a firm, level surface. 2. Remove the oil fill cap/dipstick. Clean the area around the oil fill cap and wipe the dipstick clean. 3. Insert the dipstick in oil filler neck. Do not thread into filler neck. Remove the dipstick, and check the oil level. 4. If oil...
Page 12
12 1 2 3 1 26 4 5 6 8 5 4 1 7 9 10 11 13 14 12 15 20 19 18 17 16 1 21 22 23 24 25 25 24 26 unit assembly and parts.
Page 13
13 item part qty description notes 1 41830 15 spring washer 2 41822 1 suction flange 3 41821 1 check valve 4 41827 2 cap plug 5 41829 2 o-ring, 24mm 6 41818 1 casing 7 41824 1 packing 8 41823 1 delivery flange 9 41819 1 packing, u-type 10 41817 1 inner casing 11 41815 1 impeller 12 41816 1 mechanica...
Page 14
14 g warning advertencia avertissement prime pump before starting. Bomba primera antes de comenzar. Pompe principale avant de commencer. Warning advertencia avertissement warning advertencia avertissement warning advertencia avertissement mdp 300 pn: 26562 decal, small "m" - portables pn: 41946 deca...
Page 15
15 notes __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________...
Page 16
Rev: a part no: 41861 05.27.09.