Majestic Al Fresco ODGSR36A Homeowner's Installation And Operating Manual

Manual is about: Outdoor Gas Fireplace

Summary of Al Fresco ODGSR36A

  • Page 1

    Outdoor gas fireplace models: odgsr36a, odgsr42a please read this manual before installing and using appliance. Warning: if the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. — do not store or use gasoline ...

  • Page 2: Table of Contents

    2 odgsr series outdoor gas fireplace 20007114 table of contents thank you and congratulations on your purchase of a mhsc fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and warnings carefully before starting installation. F...

  • Page 3: General Information

    3 odgsr series outdoor gas fireplace 20007114 general information this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. For u.S.A installations follow local code...

  • Page 4

    4 odgsr series outdoor gas fireplace 20007114 42" (1067mm) 46" (1168mm) 396 " (1007mm) 6 " (16mm) 50" (1270mm) 50" (1270mm) 56o " (13mm) 56o " 56o " (1791mm) " (610mm) 436m" (1111mm) 56o " (191mm) 56o " (165mm) 56o " (191mm) rough opening height 6 " (16mm) 22" (559mm) 56o " (572mm) 56m " (667mm) rec...

  • Page 5

    5 odgsr series outdoor gas fireplace 20007114 moisture resistance this outdoor fireplace will shed moderate amounts of water, but is not waterproof. Water and condensing wa- ter vapor may enter the chase under certain conditions. The fireplace will not perform as an exterior wall. Mois- ture penetra...

  • Page 6

    6 odgsr series outdoor gas fireplace 20007114 framing and finishing check appliance to make sure it is levelled and properly positioned. The appliance should only be mounted on the following surfaces: • a flat combustible (burnable) surface. • a raised wooden platform. • a concrete block or other so...

  • Page 7

    7 odgsr series outdoor gas fireplace 20007114 gas inlet & manifold pressures natural lp minimum inlet pressure 5.5” w.C. 11.0” w.C. Maximum inlet pressure 14.0” w.C. 14.0” w.C. Manifold pressure 3.5”w.C. 10.0” w.C. Gas specification max. Min. Model fuel gas control input input odgsr36arn nat. Milliv...

  • Page 8

    8 odgsr series outdoor gas fireplace 20007114 fp1416 oduvsr part id 11/24/03 djt nailing flange valve access panel firebox grate screen standoff surround gas line ac- cess fp1416 fig. 8 parts identification. *do not install header until unit is in place. Fp1416 oduvsr part id 11/24/03 djt nailing fl...

  • Page 9

    9 odgsr series outdoor gas fireplace 20007114 remote wall switch note: use an approved outdoor switch. 1. Thread wire through the low voltage wire access hole located on either side of unit. Do not cut wire or insu- lation on metal edges. Ensure that wire is protected. Run the other end to a conveni...

  • Page 10: Operating Instructions

    10 odgsr series outdoor gas fireplace 20007114 operating instructions log installation 1. Remove logs from the packaging. As with all plastic, these bags are not toys and should always be kept away from children and infants. 2. Place left rear log on rear log support. Ensure that log is firmly posit...

  • Page 11

    11 odgsr series outdoor gas fireplace 20007114 lg320 oduvsr42 log flames 11/24/03 djt lg320 fig. 18 odgsr42a flame appearance. Fig. 16 proper pilot flame height. Fp581 3/8"-1/2" fp581 nvb-pilots 12/4/97 electronic ignition nova sit pilot lg319 oduvsr36 log flames 11/24/03 djt red glow lg319 fig. 17 ...

  • Page 12

    12 odgsr series outdoor gas fireplace 20007114 optional weather enclosure an optional weather enclosure is available to protect the burner when not in use. Caution: do not use the weather enclosure if the unit has glass doors installed. Installation instructions 1. Turn the unit off and allow to coo...

  • Page 13

    13 odgsr series outdoor gas fireplace 20007114 3. Open control access panel. 4. Push in gas control knob slightly and turn clockwise to "off". Do not force. 5. Close control access panel. 1. Stop! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For mn/mp/tn/t...

  • Page 14: Troubleshooting

    14 odgsr series outdoor gas fireplace 20007114 troubleshooting fp396 gas supply on supply line hooked up shutoff valve open no no no no lockout has engaged. Wait 60 seconds and try again. Piezo not tight enough for good ground. For spark at electrode while depressing piezo (red button) 1/8" gap to p...

  • Page 15: Maintenance

    15 odgsr series outdoor gas fireplace 20007114 maintenance burner and burner compartment it is important to keep the burner and the burner compartment clean. At least once per year the logs should be removed and the burner compartment vacuumed and wiped out. Remove and replace the logs as per the in...

  • Page 16: Odgsr36A, Odgsr42A

    16 odgsr series outdoor gas fireplace 20007114 7114 oduvsr36/42a parts 11/24/03 djt 4a/b 11 13 hi lo off on off e a pilo t thtp tp th 14 12a/b 16 15 18a/b 6 9 10 a b d c h c d a b f e 2 3 7 8 17 20 g 19a/b 21 22 25 odgsr36a, odgsr42a ref. Description odgsr36a odgsr42a 1. Logs - complete set 20007180...

  • Page 17: Odgsr36A, Odgsr42A

    17 odgsr series outdoor gas fireplace 20007114 odgsr36a, odgsr42a (continued) ref. Description odgsr36a odgsr42a 14. Pilot tubing 10001296 10001296 15. Cable ignitor 24" 7522432 7522432 16. Thermocouple 24" 7531137 7531137 17. Grate 20006819 20006819 18a. Pilot orifice - natural 10002268 10002268 18...

  • Page 18: Accessories

    18 odgsr series outdoor gas fireplace 20007114 accessories the following accessories are available from your local majestic fireplaces distributor. Each accessory comes with a separate installation instruction for mounting to the particular firebox. Be sure to read each instruction thoroughly before...

  • Page 19: Limited Warranty

    19 odgsr series outdoor gas fireplace 20007114 limited warranty factory-build fireplace and components (except blowers) what is covered and for how long five-year coverage: for five years from the date this fireplace and components are first purchased for use, mhsc will, at its option, repair or rep...

  • Page 20

    Mhsc 149 cleveland drive • paris, kentucky 40361 www.Mhsc.Com.