1. DL manuals
  2. Majestic Fireplaces
  3. Indoor Fireplace
  4. GBR36
  5. Homeowner's Installation And Operating Manual

Majestic Fireplaces GBR36 Homeowner's Installation And Operating Manual

Manual is about: Decorative Gas Appliance

Summary of GBR36

  • Page 1

    Decorative gas appliance installer: do not discard this manual - leave in fireplace for homeowner. Gbr36 homeowner's installation and operating manual ™ certified design certified 7412955 10/05 rev. 11 please readthis manual before installing and using appliance. Important: read all instruc- tions an...

  • Page 2: Table of Contents

    2 gbr series b-vent gas fireplace 7412955 table of contents thank you and congratulations on your purchase of a majestic fireplaces fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and warnings carefully before starting insta...

  • Page 3: General Information

    3 gbr series b-vent gas fireplace 7412955 general information this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. For u.S.A installations follow local codes and...

  • Page 4

    4 gbr series b-vent gas fireplace 7412955 gbr36 series gas appliance fp623 fig. 1 gbr36 series specification and framing dimensions. 36" (914mm) 14 " (356mm) 5¹⁄₂ " (140mm) 40" (1016mm) 36" (914mm) 3" (76mm) ⁵⁄₈ " (16mm) 37¹⁄₂" (953mm) ¹⁄₂ " (13mm) 54 " (1372mm) 19 ³⁄₄ " (502mm) 21 " (533mm) 40¹⁄₂" (...

  • Page 5

    5 gbr series b-vent gas fireplace 7412955 clearance to combustibles appliances top ........................................................... 0” (0mm) bottom ...................................................... 0” (0mm) side .......................................................... 0” (0mm) back...

  • Page 6

    6 gbr series b-vent gas fireplace 7412955 be sure to always maintain the proper one (1) inch distance to combustibles around b-vent pipe sections. Note: insulating for cold climates is strictly a recom- mendation and not a requirement. Framing and finishing check appliance to make sure it is levelle...

  • Page 7

    7 gbr series b-vent gas fireplace 7412955 parts identification and chase installation fig. 4 parts identification and system installation. (insulation methods shown are optional for cold climate, not a require- ment for unit operation.) fp625 note: do not install header until unit is in place. Refer t...

  • Page 8

    8 gbr series b-vent gas fireplace 7412955 u.S.: consult the current national fuel gas code, ansi z223.1/nfpa 54/ canada: csa - b149.1 installation code. Always check for gas leaks with a mild soap and water solution. Apply water/soap solution with brush only - do not over ap- ply. Never test with an...

  • Page 9

    9 gbr series b-vent gas fireplace 7412955 eb-1 electrical box the fireplace, when installed, must be elec- trically connected and grounded in accor- dance with local codes or, in the absence of local codes, with the current csa c22.1 canadian electrical code. For usa installations, follow local codes...

  • Page 10

    10 gbr series b-vent gas fireplace 7412955 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 10 8 2 4 6 8 10 12 14 16 18 20 a fp567a venting run graph 8/17/99 djt horizontal run (in feet) vertical run (in feet) = acceptable venting configuration = unacceptable venting configuration a: vertical installati...

  • Page 11: Operating Instructions

    11 gbr series b-vent gas fireplace 7412955 operating instructions glass information only glass approved for use in majestic fireplaces products may be used for re- placement. • glass doors are optional. The appliance may be operated safely without glass doors. • the use of any non-approved replaceme...

  • Page 12

    12 gbr series b-vent gas fireplace 7412955 first firing upon completing the gas line connection, a small amount of air will be trapped in the line. When first lighting the unit with pilot light, it will take a few minutes to purge the trapped air. Once purging is complete, the pilot and burner will l...

  • Page 13

    13 gbr series b-vent gas fireplace 7412955 3. Open control access panel. 4. Push in gas control knob slightly and turn clock- wise to "off". Do not force. 5. Close control access panel. 1. Stop! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For mn/mp/tn/tp a...

  • Page 14

    14 gbr series b-vent gas fireplace 7412955 1/2" gas supply 1/2" x 3/8" shut-off valve 3/8" union 3/8" nipple 3/8" nipple gf598 nvb gas supply install 12/4/97 lighting and operating instructions for fireplaces equipped with sit822 gas valve (en or ep) a. This fireplace is equipped with an ignition dev...

  • Page 15: Troubleshooting

    15 gbr series b-vent gas fireplace 7412955 troubleshooting nova sit 820 standing pilot fp396 remove glass panel before servicing. Gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • piezo not tight enough for good ground. • f...

  • Page 16: Troubleshooting

    16 gbr series b-vent gas fireplace 7412955 gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • for spark at electrode while depressing piezo - 1/8" gap to pilot hood needed. • all wiring connections • replace piezo ignitor • ...

  • Page 17: Troubleshooting

    17 gbr series b-vent gas fireplace 7412955 troubleshooting nova sit 822 with honeywell 8600b electronic ignition • turn gas supply off • turn on/off switch to call for heat. No no no no no no no spark across ignitor sensor gap power to module (24v nominal) yes yes yes yes yes yes yes • turn gas on p...

  • Page 18

    18 gbr series b-vent gas fireplace 7412955 fuel conversion instructions to convert the gbr36 equipped with the nova sit820 valve only from one gas type to another, follow these instructions: before proceeding, turn control knob on valve to "off" and turn gas supply off. Turn off any electricity that...

  • Page 19

    19 gbr series b-vent gas fireplace 7412955 fc107 sit820 valve conversion 10/03 a b c off pilo t on fc107 fig. 21 remove mounting screws, pressure regulator tower and spring and diaphragm assembly. D e f fc108 sit regulator conversion 10/03 off pilot on fc108 fig. 22 replace regulator. Valve conversi...

  • Page 20: Maintenance

    20 gbr series b-vent gas fireplace 7412955 maintenance keep the control compartment, logs and burner area surrounding the logs clean by vacuuming or brushing at least twice a year. The logs can get very hot — handle only when cool. Always turn off gas to the pilot before cleaning. For relighting, re...

  • Page 21: Gbr36

    21 gbr series b-vent gas fireplace 7412955 16 3a,b,c,d 1a 1b gbr36 logs nova sit 820 valve 1d 1c 6 11 fp626/gbr36 (from fp397 & fp578) replacement parts 5/7/98 7/9/99 djt 9/29/99 djt 12a/b hi lo off on off p il o t o ff e a pilo t thtp tp th 8 9 5a/b 10 7 4a,b,c,d 18 2a/b c/d 14 13 14 17 20 19 21 no...

  • Page 22: Gbr36

    22 gbr series b-vent gas fireplace 7412955 * must order honeywell valve 30000030 gbr36 (continued) ref. Description gbr36 4a. Pilot orifice - natural (up to and including f34aob) 54273 4b. Pilot orifice - lp (up to and including f34bob) 54272 4c. Pilot orifice - natural (model #f35aob) 10002268 4d. Pil...

  • Page 23

    23 gbr series b-vent gas fireplace 7412955 contact cfm specialty home products for questions concerning prices and policies covering replacement parts. Parts may be ordered through your majestic fire- places distributor or dealer. You will need the following information when ordering replacement par...

  • Page 24: Accessories

    24 gbr series b-vent gas fireplace 7412955 accessories glass doors b-fold and single panel glass doors are available to enhance the viewing of the fireplace. Models 36gskbb 36gdkbb 36gdkbk 36gdkdp 36gdks outside air kit the model ak-mst outside air kit is designed to bring additional combustion air d...

  • Page 25

    25 gbr series b-vent gas fireplace 7412955.

  • Page 26

    26 gbr series b-vent gas fireplace 7412955.

  • Page 27

    27 gbr series b-vent gas fireplace 7412955 © cfm specialty home products basic warranty cfm specialty home products (hereinafter referred to collectively as the company) warrants that your new vermont castings or majestic gas fireplace/stove is free from manufacturing and material defects for a peri...

  • Page 28

    410 admiral blvd. • mississauga, ontario, canada l5t 2n6 • 905-670-7777 www.Majesticproducts.Com • www.Vermontcastings.Com cfm specialty home products.