1. DL manuals
  2. Majestic Fireplaces
  3. Indoor Fireplace
  4. NVBC36
  5. Installation & Operation Instructions

Majestic Fireplaces NVBC36 Installation & Operation Instructions - Table of Contents

Manual is about: NVB Series B-Vent

Summary of NVBC36

  • Page 1

    Decorative gas appliances installer: do not discard this manual - leave in fireplace for homeowner. Please read this manual before installing and using appliance. Important: read all instruc- tions and warnings carefully before starting installation. Failure to follow these instruc- tions may result...

  • Page 2: Table of Contents

    2 majestic fireplaces ® nvb series b-vent 7412950 table of contents thank you and congratulations on your purchase of a vermont castings, majestic products fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and warnings carefu...

  • Page 3: General Information

    3 majestic fireplaces ® nvb series b-vent 7412950 general information this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. For u.S.A installations follow local ...

  • Page 4

    4 majestic fireplaces ® nvb series b-vent 7412950 fig. 1 nvbr36 series specification and framing dimensions. Nvbr36 series gas appliance fp561 36" (914mm) 14 " (356mm) 13¹⁄₄ " (337mm) 40" (1016mm) 36" (914mm) 3" (76mm) ⁵⁄₈ " (16mm) 45 ³⁄₄ " (1162mm) 45 ³⁄₄ " (1 162mm) ¹⁄₂ " (13mm) ¹⁄₂ " 32³⁄₈ " (822...

  • Page 5

    5 majestic fireplaces ® nvb series b-vent 7412950 nvbr42 series gas appliance fp563 fig. 3 nvbr42 series specification and framing dimensions. 42" (1067mm) 14 " (356mm) 13¹⁄₄ " (337mm) 46" (1168mm) 36" (914mm) 3" (76mm) ⁵⁄₈ " (16mm) 49" (1245mm) 49" (1245mm) ¹⁄₂ " (13mm) ¹⁄₂ " 69¹⁄₂ " (1765mm) 19³⁄₄...

  • Page 6

    6 majestic fireplaces ® nvb series b-vent 7412950 clearance to combustibles appliances top .......................................................... 0” (0mm) bottom .................................................... 0” (0mm) side ........................................................ 0” (0mm) b...

  • Page 7

    7 majestic fireplaces ® nvb series b-vent 7412950 framing and finishing check appliance to make sure it is levelled and properly positioned. The appliance should only be mounted on the following surfaces: • a flat combustible (burnable) surface. • a raised wooden platform. • a concrete block or othe...

  • Page 8

    8 majestic fireplaces ® nvb series b-vent 7412950 parts identification and chase installation fig. 7 parts identification and system installation. (insulation methods shown are optional for cold climate, not a requirement for unit operation.) fp597 *do not install header until unit is in place. See ...

  • Page 9

    9 majestic fireplaces ® nvb series b-vent 7412950 u.S.: consult the current national fuel gas code, ansi z223.1 canada: csa - b149.1 installation code. Test for leaks. Use a 50/50 solution of liquid soap and water to test for leaks at gas fittings and joints. Apply water/soap solution with brush onl...

  • Page 10

    10 majestic fireplaces ® nvb series b-vent 7412950 eb-1 electrical box the fireplace, when installed, must be electrically connected and grounded in accordance with local codes or, in the absence of local codes, with the current csa c22.1 canadian electrical code. For usa installations, follow local...

  • Page 11

    11 majestic fireplaces ® nvb series b-vent 7412950 fp567 fig. 13 venting configurations. Venting runs 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 8 9 10 1 2 3 4 5 6 7 horizontal run (in feet) ve rtical run (in feet) a a: vertical installations up to 40 feet (12m) in height. Up to a 6 ft. Horizontal...

  • Page 12: Operating Instructions

    12 majestic fireplaces ® nvb series b-vent 7412950 operating instructions glass information only glass approved for use in majestic fireplaces products may be used for replacement. • glass doors are optional. The appliance may be operated safely without glass doors. • the use of any non-approved rep...

  • Page 13

    13 majestic fireplaces ® nvb series b-vent 7412950 ember material placement separate the ember material into small pieces, roughly 1/2" in diameter and place on bracket over front burner tube. Do not pack down; leave in loose, fluffy condition for most realistic ember effect. (fig. 15 & 16) lava roc...

  • Page 14

    14 majestic fireplaces ® nvb series b-vent 7412950 3. Open control access panel. 4. Push in gas control knob slightly and turn clockwise to "off". Do not force. 5. Close control access panel. 1. Stop! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For mn/mp/...

  • Page 15

    15 majestic fireplaces ® nvb series b-vent 7412950 1/2" gas supply 1/2" x 3/8" shut-off valve 3/8" union 3/8" nipple 3/8" nipple lighting and operating instructions for fireplaces equipped with sit822 gas valve (en or ep) a. This fireplace is equipped with an ignition device which automatically ligh...

  • Page 16: Troubleshooting

    16 majestic fireplaces ® nvb series b-vent 7412950 troubleshooting fp396 gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • piezo not tight enough for good ground. • for spark at electrode while depressing piezo (red button)...

  • Page 17: Troubleshooting

    17 majestic fireplaces ® nvb series b-vent 7412950 fp649 • turn gas supply off • turn on/off switch to call for heat. No no no no no no no spark across ignitor sensor gap power to module (24v nominal) yes yes yes yes yes yes yes • turn gas on pilot burner lights? Spark stops when pilot is lit? Main ...

  • Page 18: Maintenance

    18 majestic fireplaces ® nvb series b-vent 7412950 maintenance burner and burner compartment it is important to keep the burner and the burner compartment clean. At least once per year the logs and lava rock/ember material should be removed and the burner compartment vacuumed and wiped out. Remove a...

  • Page 19: Nvb Series

    19 majestic fireplaces ® nvb series b-vent 7412950 nvb series ref. Description nvb36 nvb42 1. Logs - complete set 20003868 20003910 1a. Log - left rear 20003862 20003904 1b. Log - right rear 20003863 20003905 1c. Log - right cross 20003864 20003906 1d. Log - left cross 20003865 20003865 1e. Log - ce...

  • Page 20: Nvb

    20 majestic fireplaces ® nvb series b-vent 7412950 nvb (continued) ref. Description nvb36 nvb42 10. Door track - black 3061102 3062102 door track - brass 3067102 3072102 11. Side brick - left 3030104 3030104 12. Back brick 3030102 3032102 13. Side brick - right 3030160 3030160 14. Ceramic panel - le...

  • Page 21: Optional Accessories

    21 majestic fireplaces ® nvb series b-vent 7412950 optional accessories fan kit the fk12 fan kit is available for use on the nvbc36 and nbvc42 model appliances only. Auxiliary fan systems increase the efficiency of the circulation of the heating air. The fk12 fan assembly is a fixed speed fan system...

  • Page 22

    22 majestic fireplaces ® nvb series b-vent 7412950 shrouds decorative shrouds are available to enhance the appearance of the termination cap. Square shroud sskdku pagoda shroud pskdku bishop shroud bskdku tt shroud ttskdku.

  • Page 23

    23 majestic fireplaces ® nvb series b-vent 7412950 basic warranty vermont castings , majestic products (hereinafter referred to collectively as the company) warrants that your new vermont castings or majestic gas fireplace/stove is free from manufacturing and material defects for a period of one yea...

  • Page 24

    410 admiral blvd. • mississauga, ontario, canada l5t 2n6 • 905-670-7777 www.Majesticproducts.Com • www.Vermontcastings.Com vermont castings, majestic products.