Majestic GBR36 Homeowner's Installation & Operating Manual

Manual is about: Decorative

Summary of GBR36

  • Page 1

    Decorative gas appliance model: gbr36 homeowner's installation and operating manual certified design certified 7412955 1/08 rev. 13 please readthis manual before installing and using appliance. Important: read all instructions and warnings carefully before starting installation. Failure to follow th...

  • Page 2: Table of Contents

    2 gbr series b-vent gas fireplace 7412955 table of contents thank you and congratulations on your purchase of a majestic fireplaces fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and warnings carefully before starting insta...

  • Page 3: General Information

    3 gbr series b-vent gas fireplace 7412955 general information this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. For u.S.A installations follow local codes and...

  • Page 4

    4 gbr series b-vent gas fireplace 7412955 gbr36 series gas appliance fp623 fig. 1 gbr36 series specification and framing dimensions. 36" (914mm) " (356mm) " (140mm) 40" (1016mm) 36" (914mm) 3" (76mm) " (16mm) 37 " (953mm) " (13mm) " (1372mm) " (502mm) " (533mm) 40 ...

  • Page 5

    5 gbr series b-vent gas fireplace 7412955 clearance to combustibles appliances top .......................................................... 0” (0 mm) bottom ..................................................... 0” (0 mm) side ......................................................... 0” (0 mm) back...

  • Page 6

    6 gbr series b-vent gas fireplace 7412955 be sure to always maintain the proper one (1) inch distance to combustibles around b-vent pipe sections. Note: insulating for cold climates is strictly a recom- mendation and not a requirement. Framing and finishing check appliance to make sure it is levelle...

  • Page 7

    7 gbr series b-vent gas fireplace 7412955 gas line installation this appliance must be isolated from the gas supply piping system by closing its individual manual shut off valve during any pressure equal to or less than 1/2 psig (3.45 kpa). The appliance and its individual shutoff valve must be disc...

  • Page 8

    8 gbr series b-vent gas fireplace 7412955 u.S.: consult the current national fuel gas code, ansi z223.1/nfpa 54/ canada: csa - b149.1 installation code. Always check for gas leaks with a mild soap and water solution. Apply water/soap solution with brush only - do not over ap- ply. Never test with an...

  • Page 9

    9 gbr series b-vent gas fireplace 7412955 eb-1 electrical box the fireplace, when installed, must be elec- trically connected and grounded in accor- dance with local codes or, in the absence of local codes, with the current csa c22.1 canadian electrical code. For usa installations, follow local codes...

  • Page 10

    10 gbr series b-vent gas fireplace 7412955 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 10 8 2 4 6 8 10 12 14 16 18 20 a fp567a venting run graph 8/17/99 djt horizontal run (in feet) vertical run (in feet) = acceptable venting configuration = unacceptable venting configuration a: vertical installati...

  • Page 11: Operating Instructions

    11 gbr series b-vent gas fireplace 7412955 operating instructions glass information only glass approved for use in majestic fireplaces products may be used for re- placement. • glass doors are optional. The appliance may be operated safely without glass doors. • the use of any non-approved replaceme...

  • Page 12

    12 gbr series b-vent gas fireplace 7412955 first firing upon completing the gas line connection, a small amount of air will be trapped in the line. When first lighting the unit with pilot light, it will take a few minutes to purge the trapped air. Once purging is complete, the pilot and burner will l...

  • Page 13

    13 gbr series b-vent gas fireplace 7412955 3. Open control access panel. 4. Push in gas control knob slightly and turn clock- wise to " off ". Do not force. 5. Close control access panel. 1. Stop! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For mn/mp/tn/tp...

  • Page 14

    14 gbr series b-vent gas fireplace 7412955 gf598 nvb gas supply install 12/4/97 lighting and operating instructions for fireplaces equipped with sit822 gas valve (en or ep) a. This fireplace is equipped with an ignition device which automatically lights the pilot. Do not try to light the pilot by han...

  • Page 15: Troubleshooting

    15 gbr series b-vent gas fireplace 7412955 troubleshooting nova sit 820 standing pilot fp396 remove glass panel before servicing. Gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • piezo not tight enough for good ground. • f...

  • Page 16: Troubleshooting

    16 gbr series b-vent gas fireplace 7412955 gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • for spark at electrode while depressing piezo - 1/8" gap to pilot hood needed. • all wiring connections • replace piezo ignitor • ...

  • Page 17: Troubleshooting

    17 gbr series b-vent gas fireplace 7412955 troubleshooting nova sit 822 with honeywell 8600b electronic ignition • turn gas supply off • turn on/off switch to call for heat. No no no no no no no spark across ignitor sensor gap power to module (24v nominal) yes yes yes yes yes yes yes • turn gas on p...

  • Page 18

    18 gbr series b-vent gas fireplace 7412955 fuel conversion instructions to convert the gbr36 equipped with the nova sit820 valve only from one gas type to another, follow these instructions: before proceeding, turn control knob on valve to "off" and turn gas supply off. Turn off any electricity that...

  • Page 19

    19 gbr series b-vent gas fireplace 7412955 d e f fc108 sit regulator conversion 10/03 off pilot on fc108 fig. 22 replace regulator. Testing for leaks 1. Apply gas to the system and light the pilot. 2. Using a soapy solution check for leaks around the pilot assembly where the tube enters the pilot as...

  • Page 20: Maintenance

    20 gbr series b-vent gas fireplace 7412955 maintenance keep the control compartment, logs and burner area surrounding the logs clean by vacuuming or brushing at least twice a year. The logs can get very hot — handle only when cool. Always turn off gas to the pilot before cleaning. For relighting, re...

  • Page 21: Gbr36

    21 gbr series b-vent gas fireplace 7412955 16 3a,b,c,d 1a 1b gbr36 logs nova sit 820 valve 1d 1c 6 11 fp626/gbr36 (from fp397 & fp578) replacement parts 5/7/98 7/9/99 djt 9/29/99 djt 12a/b hi l o on off e a p ilo t thtp tp th 8 9 5a/b 10 7 4a,b,c,d 18 2a/b/c/d 14 13 14 17 20 19 21 nova sit 822 valve...

  • Page 22: Gbr36

    22 gbr series b-vent gas fireplace 7412955 * must order honeywell valve 30000030 gbr36 (continued) ref. Description gbr36 3d. Burner orifice - lp (model #f35b0b) 20005251 4a. Pilot orifice - natural (up to and including f34a0b) 54273 4b. Pilot orifice - lp (up to and including f34b0b) 54272 4c. Pilot o...

  • Page 23

    23 gbr series b-vent gas fireplace 7412955 contact cfm corporation for questions concerning prices and policies covering replacement parts. Parts may be ordered through your majestic fireplaces dis- tributor or dealer. You will need the following information when ordering replacement parts: 1. The a...

  • Page 24: Accessories

    24 gbr series b-vent gas fireplace 7412955 accessories glass doors b-fold and single panel glass doors are available to enhance the viewing of the fireplace. Models 36gskbb 36gdkbb 36gdkbk 36gdkdp 36gdks outside air kit the model ak-mst outside air kit is designed to bring additional combustion air d...

  • Page 25

    25 gbr series b-vent gas fireplace 7412955.

  • Page 26

    26 gbr series b-vent gas fireplace 7412955.

  • Page 27

    27 gbr series b-vent gas fireplace 7412955 © cfm corporation basic warranty cfm corporation (hereinafter referred to collectively as the company) warrants that your new vermont castings or majestic gas fireplace/ stove is free from manufacturing and material defects for a period of one year from the...

  • Page 28

    Efficiency ratings model energuide ratings fireplace efficiency (%) gbr36rn 15.5 gbr36rp 15.5 gbr36en 11.6 gbr36ep 11.6 2695 meadowvale blvd. • mississauga, ontario, canada l5n 8a3 800-668-5323 • www.Cfmcorp.Com cfm corporation.