Homeowner's installation and operating manual installer: do not discard this manual - leave for homeowner decorative gas appliance models: nv360 nv580 do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. What to do if you smell gas: • do ...
2 vermont castings majestic products nv360/580 series 20003565 table of contents thank you and congratulations on your purchase of a vermont castings, majestic products fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and wa...
3 vermont castings majestic products nv360/580 series 20003565 this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. If the unit is being installed in a mobile h...
4 vermont castings majestic products nv360/580 series 20003565 3565a fireplace dimensions a s k j c l t - rough opening width r d g c rough opening height electrical access rough opening depth recessed nailing flange gas line access m outside air w v x w k u h i g f e q p n o l b fig. 1 fireplace sp...
5 vermont castings majestic products nv360/580 series 20003565 hearth a hearth is not mandatory but is recommended for aesthetic purposes. We recommend a noncombustible hearth. O n m l k j f g h i mantel leg cfm164a fig. 2b combustible mantel leg minimum installation. Man- tel leg cfm170 mantel mant...
6 vermont castings majestic products nv360/580 series 20003565 fp297a fig. 4 typical gas supply installation. 1/2" gas supply 1/2" npt x 1/2" flare shut-off valve 3/8" flex line (from valve) final finishing noncombustible materials such as brick and tile can be extended over the face of the unit (do...
7 vermont castings majestic products nv360/580 series 20003565 eb-1 electrical box the fireplace, when installed, must be electrically connected and grounded in accordance with local codes or, in the absence of local codes, with the current csa c22.1 canadian electrical code. For usa installations, ...
8 vermont castings majestic products nv360/580 series 20003565 attic insulation firestop position when area above ceiling is an attic nails (4) firestop spacer joist ceiling installation firestop position when area above ceiling is not an attic (firestop/draftstop appearances may vary. Only one (1) ...
9 vermont castings majestic products nv360/580 series 20003565 venting runs 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 8 9 10 11 12 1 2 3 4 5 6 7 horizontal run (in feet) v ertical run (in feet) a a: vertical installations up to 40 feet (12m) in height. Up to an 8 ft. Horizontal vent run can be in...
10 vermont castings majestic products nv360/580 series 20003565 log installation 1 . Remove window frame assembly. (refer to page 10) 2. Remove logs from packaging. As with all plastics — these are not toys and should be kept away from children and infants. 3. Place rear log on rear bracket (ensure ...
11 vermont castings majestic products nv360/580 series 20003565 lava rock the lava rock provided with this fireplace must be placed on the firebox base around the sides of the burner assembly and on the tray beneath the grate. Under no circumstances should this lava rock be placed on any part of the...
12 vermont castings majestic products nv360/580 series 20003565 first firing upon completing the gas line connection, a small amount of air will be trapped in the line. When first lighting the unit with the pilot light, it will take a few minutes to purge the trapped air. Once purging is complete, t...
13 vermont castings majestic products nv360/580 series 20003565 3. Open control access panel. 4. Push in gas control knob slightly and turn clock- wise to "off" position. Do not force. 5. Close control access panel. 1. Stop! Read the safety information above. 2. Turn off all electrical power to the ...
14 vermont castings majestic products nv360/580 series 20003565 vent safety switch this fireplace incorporates the use of a vent safety shut-off switch. The sensor and wiring are factory installed and should not be removed or altered during installation. In the event of total flue blockage the syste...
15 vermont castings majestic products nv360/580 series 20003565 remove glass door before service work start check gas supply on ▼ ▼ ▼ ▼ ▼ pilot lights with piezo ignitor • lockout has engaged. Wait 60 seconds and try again. • for spark at electrode while depressing piezo 1/8" gap to pilot hood neede...
16 vermont castings majestic products nv360/580 series 20003565 warning: before doing any gas control service work, remove glass front. Symptom possible causes corrective action 1. Spark ignitor will not light a. Defective or misaligned using a match, light pilot. If pilot lights, turn off electrode...
17 vermont castings majestic products nv360/580 series 20003565 fuel conversion procedure honeywell valve only this conversion is for the nv360/580 equipped with a honeywell valve only. Before proceeding, turn control knob on valve to “off” and turn gas supply off. Turn off any electricity that may ...
18 vermont castings majestic products nv360/580 series 20003565 13. Remove pilot hood by lifting up. (fig. 26) 14. Remove pilot orifice with allen wrench. (fig. 27) 15. Install lp pilot orifice. 16. Re-install pilot hood and be sure to align with index tab. Installation is complete. Replacement of c...
19 vermont castings majestic products nv360/580 series 20003565 burner and burner compartment it is important to keep the burner and the burner compartment clean. At least once per year the logs and lava rock/ember material should be removed and the burner compartment vacuumed and wiped out. Remove ...
20 vermont castings majestic products nv360/580 series 20003565 1d 1e 1c 1a 1b dv360 1d 1e 1c 1a 1b 1f dv580 5a,b 8a 8b 11 12 21a-d 22 1g 2 3 4 6 9 16 37 36a 7 10a 13 15 14 17 18 pilot on o f f pilot adj lo h i tpth th tp 23 a/b 24 a/b 25 29 34a/b 35 19 20 26 31 27 28 32 33 38 39 40 41 42 10b 36b 47...
21 vermont castings majestic products nv360/580 series 20003565 nv360/580 (continued) ref. Description nv360 nv580 6. Ceramic tile (single) 57803 57803 7. Manifold assembly 10000765 10000765 8a. Ceramic hearth panel (left) 20002274 20002322 8b. Ceramic hearth panel (right) 20002275 20002323 9. Ceram...
22 vermont castings majestic products nv360/580 series 20003565 optional accessories available fan kits fk24 fan assembly fan specifications: 120 volt, 60 hz .75 amp. This fan does not need regular maintenance, however, periodic cleaning is required. Check the area under the control door and in fron...
23 vermont castings majestic products nv360/580 series 20003565 remote controls optional remote control units are available to control different functions of the appliance. Model function/s controlled mrc1 “on/off” mrc2 “on/off” and temperature mrc3 “on/off” and temperature control with a digital an...
24 vermont castings majestic products nv360/580 series 20003565 basic warranty the vermont castings , majestic products company (hereinafter referred to collectively as the company) warrants that your new vermont castings or majestic gas fireplace/stove is free from manufacturing and material defect...
