1. DL manuals
  2. Majestic
  3. Indoor Fireplace
  4. NVBC36
  5. Installation And Operating Manual

Majestic NVBC36 Installation And Operating Manual

Summary of NVBC36

  • Page 1

    950 nvb cover 2/1/01 decorative gas appliances please read this manual before installing and using appliance. Important: read all instructions and warnings carefully before starting installation. Failure to follow these in- structions may result in a possible fire hazard and will void the warranty. W...

  • Page 2: Table of Contents

    2 nvb series b-vent gas fireplace 7412950 table of contents thank you and congratulations on your purchase of a cfm corporation fireplace. Please read the installation & operating instructions before using the appliance important: read all instructions and warnings carefully before starting installat...

  • Page 3: General Information

    3 nvb series b-vent gas fireplace 7412950 general information this gas appliance should be installed by a qualified installer in accordance with local building codes and with current csa-b149.1 installation codes for gas burning appliances and equipment. For u.S.A installations follow local codes and...

  • Page 4

    4 nvb series b-vent gas fireplace 7412950 fig. 1 nvbr36 series specification and framing dimensions. Nvbr36 series gas appliance fp561 36" (914mm) " (356mm) " (337mm) 40" (1016mm) 36" (914mm) 3" (76mm) " (16mm) 45 " (1162mm) 45 " (1 162mm) " (13mm) " " (822mm) " ...

  • Page 5

    5 nvb series b-vent gas fireplace 7412950 nvbr42 series gas appliance fp563 fig. 3 nvbr42 series specification and framing dimensions. 42" (1067mm) " (356mm) " (337mm) 46" (1168mm) 36" (914mm) 3" (76mm) " (16mm) 49" (1245mm) 49" (1245mm) " (13mm) " " (1765mm) " (502mm)...

  • Page 6

    6 nvb series b-vent gas fireplace 7412950 clearance to combustibles appliances top ..........................................................0” (0 mm) bottom .....................................................0” (0 mm) side .........................................................0” (0 mm) back .....

  • Page 7

    7 nvb series b-vent gas fireplace 7412950 framing and finishing check appliance to make sure it is levelled and properly positioned. The appliance should only be mounted on the following sur- faces: • a flat combustible (burnable) surface. • a raised wooden platform. • a concrete block or other solid...

  • Page 8

    8 nvb series b-vent gas fireplace 7412950 wf597 nvc (from fp528) 12/2/97 parts identification and chase installation fig. 7 parts identification and system installation. (insulation methods shown are optional for cold climate, not a requirement for unit operation.) fp597 *do not install header until u...

  • Page 9

    9 nvb series b-vent gas fireplace 7412950 24 vac hot 24 vac rtn on-off switch nova sit 822 valve honeywell s8600 b ignition module 120 vac rtn 40va transformer 120 vac hot black black black black black black black white white white white white white white white black fp670 nova sit 822 valve wiring ...

  • Page 10

    10 nvb series b-vent gas fireplace 7412950 eb-1 electrical box the fireplace, when installed, must be elec- trically connected and grounded in accor- dance with local codes or, in the absence of local codes, with the current csa c22.1 canadian electrical code. For usa installations, follow local code...

  • Page 11

    11 nvb series b-vent gas fireplace 7412950 fp567 fig. 13 venting configurations. venting runs horizontal run (in feet) vertical run (in feet) a a: vertical installations up...

  • Page 12: Operating Instructions

    12 nvb series b-vent gas fireplace 7412950 operating instructions glass information only glass approved for use in majestic fireplaces products may be used for re- placement. • glass doors are optional. The appliance may be operated safely without glass doors. • the use of any non-approved replaceme...

  • Page 13

    13 nvb series b-vent gas fireplace 7412950 lg148 nvb42 log set 1/30/01 djt left rear log left cross log middle cross log right cross log right rear log ember left log embers grate lava rock ember right fig. 16 nvb42 log placement. Lg148 under no circumstances should lava rock be placed on any part o...

  • Page 14

    14 nvb series b-vent gas fireplace 7412950 lg151 nvb36 log flames 2/2/01 djt red glow embers lg151 fig. 19 nvb36 flame appearance. Lg150 nvb42 log flames 2/1/01 djt lg150 fig. 20 nvb42 flame appearance. F i r e - p a r t s . C o m.

  • Page 15

    15 nvb series b-vent gas fireplace 7412950 a. This heater has a pilot which must be lit manu- ally. When lighting the pilot follow these instructions exactly. B. Before lighting smell all around the heater area for gas. Be sure to smell next to the floor because some gas is heavier than air and will ...

  • Page 16

    16 nvb series b-vent gas fireplace 7412950 1/2" gas supply 1/2" x 3/8" shut-off valve 3/8" union 3/8" nipple 3/8" nipple gf598 nvb gas supply install 12/4/97 lighting and operating instructions for fireplaces equipped with sit822 gas valve (en or ep) a. This fireplace is equipped with an ignition dev...

  • Page 17: Troubleshooting

    17 nvb series b-vent gas fireplace 7412950 troubleshooting fp396 gas supply on • supply line hooked up • shutoff valve open no no no no • lockout has engaged. Wait 60 seconds and try again. • piezo not tight enough for good ground. • for spark at electrode while depressing piezo (red button) 1/8" ga...

  • Page 18: Troubleshooting

    18 nvb series b-vent gas fireplace 7412950 fp649 • turn gas supply off • turn on/off switch to call for heat. No no no no no no no spark across ignitor sensor gap power to module (24v nominal) yes yes yes yes yes yes yes • turn gas on pilot burner lights? Spark stops when pilot is lit? Main burner l...

  • Page 19: Maintenance

    19 nvb series b-vent gas fireplace 7412950 in order to properly clean the burner and pilot assem- bly, turn off the gas to the unit, open the glass door (if used), remove logs exposing the burner and pilot assembly. Clean all foreign materials from the top of the burner. Check to make sure that burn...

  • Page 20: Nvb Series

    20 nvb series b-vent gas fireplace 7412950 nvb series ref. Description nvb36 nvb42 1. Logs - complete set 20003868 20003910 1a. Log - left rear 20003862 20003904 1b. Log - right rear 20003863 20003905 1c. Log - right cross 20003864 20003906 1d. Log - left cross 20003865 20003865 1e. Log - center cro...

  • Page 21: Nvb

    21 nvb series b-vent gas fireplace 7412950 nvb (continued) ref. Description nvb36 nvb42 door track - brass 3067102 3072102 11. Side brick - left 3030104 3030104 12. Back brick 3030102 3032102 13. Side brick - right 3030160 3030160 14. Ceramic panel - left 3043132 3051120 15. Ceramic panel - right 30...

  • Page 22: Optional Accessories

    22 nvb series b-vent gas fireplace 7412950 optional accessories fan kit the fk12 fan kit is available for use on the nvbc36 and nbvc42 model appliances only. Auxiliary fan systems increase the efficiency of the cir- culation of the heating air. The fk12 fan assembly is a fixed speed fan system and doe...

  • Page 23

    23 nvb series b-vent gas fireplace 7412950 basic warranty cfm corporation (hereinafter referred to collectively as the company) warrants that your new vermont castingsor majestic gas fireplace/ stove is free from manufacturing and material defects for a period of one year from the date of purchase, ...

  • Page 24

    410 admiral blvd. • mississauga, ontario, canada l5t 2n6 800-668-5323 • www.Cfmcorp.Com cfm corporation f i r e - p a r t s . C o m.