1. DL manuals
  2. Megamaster
  3. Grill
  4. Blaze-300
  5. Assembly & Operating Instructions

Megamaster Blaze-300 Assembly & Operating Instructions

Summary of Blaze-300

  • Page 1

    80 0 700 600 500 400 300 2 00 100 warning to reduce the risk of fire, burn hazard or other injury, read the manual carefully and completely before using your grill. Warning for outdoor use only. Warning this grill is not intended to be installed in or on recreational vehicles and/or boats. Lpgsasa p...

  • Page 2

    2 safety information ............................................................................................................. 3 package contents list ...................................................................................................... 7 preparation ...............................

  • Page 3

    3 safety information warning – hazards or unsafe practices which could result in severe personal injury or death. Caution – hazards or unsafe practices which could result in minor personal injury. Warning caution warning do not try lighting this appliance without first reading the “lighting instruct...

  • Page 4

    4 before lighting inspect the gas supply hoses prior to turning on the gas. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. . It must be used with a 2, 8 kpa regulator that complies with the requirements of sans1237. Only the pressure regulator and hose assembly su...

  • Page 5

    5 do not use indoors. Safety practices to avoid injury when properly cared for, your grill will provide safe, reliable service for many years. However, extreme care must be used as the grill produces intense heat that can increase accident potential. When using this appliance basic safety practices ...

  • Page 6

    6 warning do not install this unit in combustible enclosures. There should be a minimum clearance of 24 inches from all sides to combustible materials. Exercise caution when cleaning grill. To avoid steam burns, do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produ...

  • Page 7

    7 package contents list a. Firebox assembly -------- 1pc. B. Bottom panel--------1pc. C. Wheel-------------------2pcs. D. Side burner shelf & control panel-------1pc. E. Left side shelf & control panel------1pc. F. Cart leg, front left--------1pc. G. Cart leg, back left-------- 1pc. H. Cart frame --...

  • Page 8

    8 v. 1.5 volt “aa” size alkaline battery----------1pc. W. Grease box ----------1pc. Aa bb cc dd ee before beginning assembly, make sure all parts are present. Compare parts with package contents list and diagram above. If any part is missing or damaged, do not attempt to assemble the product. Contac...

  • Page 9

    9 1. Cart assembly a) place the cart caster inset (k) into the cart leg, front left (f) and cart leg, back left (g). As shown in fig. 1. B) loosen, but do not remove the screws that are pre-assembled on the cart leg, front left (f) and cart leg, back left (g). Attach cart leg, front left (f) and car...

  • Page 10

    10 2. Bottom panel assembly a) loosen, but do not remove the screws that are pre-assembled on the side of the bottom panel (b), align the holes on the cart leg, front left (f) and cart leg, back left (g), then place the cart legs onto the screws that were loosened in the bottom panel (b). As shown i...

  • Page 11

    11 5. Wheel assembly a) remove the nuts and washers which are pre-assembled on the short axle, place the wheels (c) on the axle attached to cart leg, front right (i) and cart leg, back right (j). As show in fig. 7. B) place washers closest to the wheel and then place and tighten the nuts on the axle...

  • Page 12

    12 g j a c) remove the firebox assembly (a) from the carton and carefully place onto the grill cart. Lid handle will face front and be above front panel. As shown in fig. 9. D) once the firebox is in place, secure the firebox assembly (a) to cart leg back right (j) and cart leg back left (g) using t...

  • Page 13

    13 8. Side burner shelf assembly a) loosen but do not remove the screw which is pre-assembled on the cart leg. Remove the two screws that are attached to the side burner shelf (d) frame and the two screws that are attached to the main control panel. B) align the holes on side burner shelf (d) with t...

  • Page 14

    14 a b) insert side burner control knob (m) onto the valve stem and tighten it. As shown in fig. 14. 11. Side burner installation a) from underneath the side burner remove two screws which are assembled on the bottom of the side burner shelf (d). Open side burner lid and place the side tube burner (...

  • Page 15

    15 12. Electronic igniter battery installation unscrew the electronic igniter button and place the battery (v) into the housing with the positive terminal (+) facing outward. Replace the ignition button after the battery has been installed as shown in fig. 17. 13. Install the grease tray install the...

  • Page 16

    16 b 15. Liquid propane tank installation from rear of grill place the lp gas cylinder into the bottom panel (b) hole as shown in fig. 20. 16. Liquid propane hook-up attach the regulator to the propane cylinder by turning the regulator handle clockwise as shown in fig. 21. If the outdoor cooking app...

  • Page 17

    17 installation instructions gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This grill is configured for lp gas. Do not use a natural gas supply. Total...

  • Page 18

    18 disconnecting the liquid propane cylinder 1. Turn the grill burner valves “off” and make sure the grill is cool. 2. Turn the lp gas cylinder valve “off” by turning clockwise until it stops. 3. Detach the regulator assembly from the cylinder valve by turning the wheel nut clockwise. 4. Place dust ...

  • Page 19

    19 it is very important to keep your appliances clear and away from any combustible materials. Maintain at least 24 inches of clearance from sides and back and do not use under overhead combustible construction. Warning 1. Do not store spare lp gas cylinders under or near this appliance. 2. Never fi...

  • Page 20

    20 operating instructions general use of the grill each main burner is rated at 13,500 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are flame tamers. The igniter knobs are located on the ce...

  • Page 21

    21 warning when lighting, keep your face and hands as far away from the grill as possible. Caution when using a match to light the grill make sure to use the attached lighting rod. To light the side burner 1. Push and turn side burner control knob to ignite/hi, at the same time, press and hold elect...

  • Page 22

    22 care and maintenance stainless steel there are many stainless steel cleaners available. Always use the mildest cleaning process first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. To touch up noticeable scratches in the stainless steel, sand very ...

  • Page 23

    23 to clean the grill burners: 1. Clean the exterior of the burner with a wire brush. Use a metal scraper for stubborn stains or debris. 2. Clear clogged ports with a straightened paper clip. Never use a wooden toothpick as it may break off and clog the port. 3. Check and clean burners / venture tub...

  • Page 24

    24 troubleshooting problems possible solutions grill will not light. 1. Push and turn the knob and check for sparks. 2. If there is a spark, check to make sure gas is supplied to the burner. A. Purge the line of any trapped air. B. Check to see if you can match-light the burner. C. Check to see that...

  • Page 25

    25 problems possible solutions burner blows out. 1. Check for any burner defects. 2. Check for proper burner installation. 3. Make certain the fuel mixture is not too lean. 4. Make sure the gas supply is sufficient. 5. See if the lp tank is empty. Low heat, lp gas. Rapid changes in pressure can trig...

  • Page 26

    26 warranty this grill has a one (1) year limited warranty. The warranty period is valid from the date of purchase. This is subject to correct assembly, use, storage and regular maintenance of the product. Please refer to page 10 of this manual for list of replacement parts. Please note: the main bu...

  • Page 27

    27 replacement parts list ref# description warranty coverage qty ref# description warranty coverage qty 01 main lid 1yr 1pc 29 cart leg front, left 1yr 1pc 02 hood buffer b 1yr 2pcs 30 cart leg rear, left 1yr 1pc 03 main lid screw 1yr 2pcs 31 lighting rod 1yr 1pc 04 main lid screw cover 1yr 2pcs 32 ...

  • Page 28

    28 52 50 38 02 80 0 700 600 500 40 0 300 20 0 100 01 05 03 07 12 13 14 15 17 22 24 26 29 31 32 36 33 32 16 45 23 03 11 55 54 53 49 48 46 44 43 42 41 35 30 27 28 37 37 34 25 20 21 19 18 34 40 39 12 51 47 04 04 02 06 10 09 08.

  • Page 29

    29 recipe list food weight or thickness temperature time special instructions and tips vegetables n/a medium 8 to 20 minutes slice or chop vegetables and dot with butter or margarine. Wrap tightly in heavy duty foil. Turn occasionally potatoes whole medium 40 to 60 minutes wrap individually in heavy...

  • Page 30: Blaze 300 Bl

    30 blaze 300 bl patio gas braai for outdoor use only this appliance complies with the requirements of sans 1539 www.Megamaster.Co.Za manufactured in china· distributed by mega group · po box 15, woodlands, 0027, south africa· tel: +27(0)12 802 1515 warning read and follow all safety, assembly, and u...