1. DL manuals
  2. NAD
  3. Receiver
  4. C 315BEE
  5. Service Manual

NAD C 315BEE Service Manual

Other manuals for C 315BEE: Catalog, Owner's Manual, Datasheet
Manual is about: nad owner manual amplifier C315BEE

Summary of C 315BEE

  • Page 1

    Nad ser vice manual c 315bee stereo amplifier c 315bee stereo amplifier.

  • Page 2: Table of Contents

    Table of contents description p a g e service caution…………………………………………………………......3-4 rear panel/front panel view………………………………………...5 specifications…………………………………………………………....6 wiring diagram………………………………………………………………7 block diagram……………………………………………………. …….......8-12 alignment procedure……………………………………………....

  • Page 3

    Product safety servicing guidelines caution : do not attempt to modify this product in any way. Never perform customized installations without manufacturer’s approval. Unauthorized modifications will not only void the warranty, but may lead to your being liable for any resulting property damage or u...

  • Page 4: Servicing Precautions

    Servicing precautions caution : before servicing the a/v receiver covered by this service data and its supplements and addends, read and follow the safety precautions. Note : if unforeseen circumstances create conflict between the following servicing precautions and any of the safety precautions in ...

  • Page 5

    '30/51"/&-$0/530-4'*(63& 3&"31"/&-$0//&$5*0/4'*(63& volume treble balance bass 5 n ©d ac e e b 5 1 3 4 6 8 9 7 3 1 2 tone defeat phones tape video tuner cd aux mp disc stereo integrated amplifier c 315bee " ± / " 3 ' 1. Disc input 2. Cd input 3. Video input 4. Aux input 5. Tuner input 6. Tape in/out...

  • Page 6: Specifications

    Specifications preamp in , speakers out continuous average power 40 w (16 dbw) output into 8 ohms or 4 ohms (min. Power per channel, 20 hz – 20 khz, with no more than rated distortion) thd + noise clipping power 45 w (maximum continuous power per channel 4 and 8). Ihf dynamic headroom: at 8 ohms + 3...

  • Page 8

    Tape out l dis c l dis c r cd r video r au x r tape1 i n r t ape1 i n l au x l video l cd l preapm amp circuit bass rt31 rt32 rt34 tr ebl e bal an c e sw3 1 tone de fe a t rt33 vol u m e pre-out l pre-out r ma in in r ma in in l power am p circuit l circuit r power am p protection circuit rl301 mcu(...

  • Page 9

    +5v sandby control line 18v power supply control circuit +5v input selection keys and leds +5v main mute mute circuit record out circuit ic503 v s g ir receiver d501 red blue standby led microprocessor connection diagram amber volume circuit nc 1 nc 2 nc 3 vss 4 sda 5 scl 6 nc 7 vcc 8 ic502 24c01 c5...

  • Page 10

    24c01 key board ic502 3,1&21),*85$7,21 ! &21752/ /2*,& ; '(&2'(5 6/$9($''5(66 5(*,67(5 &203$5$725 :25'$''5(66 &2817(5 +,*+92/7$*( *(1(5$725 7,0,1*&21752/ ((3520 $55$ '(&2'(5 '$7$ 5(*,67(5 &orfn ',2 $&. *1' :3 6&/ 6'$ 9ff q026 )81&7,21$/%/2&.',$*5$0 1 2 3 4 5 6 7 8 nc nc nc vss vcc nc scl sda.

  • Page 11

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 vcc p0.0(ad0) p0.1(ad1) p0.2(ad2) p0.3(ad3) p0.4(ad4) p0.5(ad5) p0.6(ad6) p0.7(ad7) p2.0(a8) p2.1(a9) p2.2(a10) p2.3(a11) p2.4(a12) p2.5(a13) p2.6(a14) p2.7(a15) psen ale/pro g ea/vpp (t2)p...

  • Page 12

    L-s1 2 l-s2 3 l-s3 4 l-s4 5 l-s5 7 l-s6 8 l-s7 10 l-s8 11 l-co m 1 6 l-co m 2 9 l-co m 3 12 stb 13 gnd 14 r- s 1 27 r- s 2 26 r- s 3 25 r- s 4 24 r- s 5 22 r- s 6 21 r- s 7 19 r- s 8 18 r- co m 1 23 r- co m 2 20 r- co m 3 17 data 16 clk 15 vss 1 vdd 28 main board:u301 tc9164cng pin configuration.

  • Page 13

    A. Low e s t v olume adj us t me nt 3. C onnect a os cillos cope to left channel binding pos ts . 1. T urn down the volume potentiometer to the lowes t s etting. 2. Input a high voltage s ignal s uch as 5v from c d input. 4. Obs erving the os cillos cope, adjus t vr 102, to ma ke the output of s pea...

  • Page 14

    Rca31a l rca31c l rca32a l rca32c l rca33a l rca33c l rca33e l r101 470 r103 470 r105 470 c101 100p c102 100p c103 100p r107 470 r109 470 r111 470 c104 100p c105 100p c106 100p r113 470 c107 100p rca31b r rca31d r rca32b r rca32d r rca33b r rca33d r rca33f r r201 470 r203 470 r205 470 c201 100p c202...

  • Page 15

    Hs4_c315bee_b007_vm1.0_key.Sch c315bee 3 / 3 vm description date appro nad the information contained in this drawing is the sole property of nad electronics intl.. Any reproduction in part of whole without the written permission of nad electronics intl. Is prohibited document number: sheet: state: p...

  • Page 16

    Phone5 mp in c508 100pf c509 100pf 1 2 3 cz54 mp input s502 s503 s505 s501 s506 s504 d504 d505 d507 d503 d506 d508 r509 10k r510 10k disc tape aux cd video tuner d502 mp +5v tape video aux tuner cd disc/mp 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 cz53 +5v r519 510 c502 0.1uf +5v ic503 hs0038b...

  • Page 17

    C402 10nf 250v d402 kbu8d c401 10nf 250v d403 kbu8d f41 t3.15al/250v for ah version 1 2 3 4 5 6 7 cb41 transformer ds401 lamp ds402 lamp +45v -45v 1 2 3 4 5 cb43 +/-45v supply 1 2 3 cb42 + /- 17v and 5v suppl y 8v 0v 34.6v 34.6v 0v 25.2v 25.2v 1 2 3 cb45 1 3 cb44 c403 4.7nf/400v c404 0.22uf ac power...

  • Page 18: Nad

    Rt33 na d c315 be e po we r v m 2 .0 pcb-3: pot board vm1.0 cop y right c 2007 pcb-2: power board vm2.0 to switch t3 .1 5 a l 2 50 v f o r 12 0 v m a in s t 1 .6 al 25 0 v f o r 2 3 0v m a in s jk31 cz31 cop y right c 20 07 c 3 1 5 be e po t bo ar d vm 1. 0 nad j31 na d e l e c t r on ics pcb-5: hea...

  • Page 19

    Spkout pcb-1: main board vm1.0 (- 45v) j15 3 c233 c131 spk out l rl301 j81 d310 d311 r339 c333 q 315 r3 2 9 j17 6 r33 0 q 222 q217 r2 9 6 r27 9 j1 8 1 r273 tp2 j141 r342 d21 2 r27 8 c24 0 j1 5 2 j1 4 2 tp1 (+4 5 v ) j14 4 q2 1 8 r28 0 c231 q215 r274 r277 j139 j138 spk out r j140 r281 c23 8 c1 4 1 c2...

  • Page 20

    (bottom view) pcb-6: key board vm1.0 cz5 3 s504 s502 nad c315bee key vm1.0 copyright c 2007 nad electronics s501 s503 d5 0 4 d5 0 5 d 503 (top view) pcb-6: key board vm1.0 s v g s506 d502 r5 1 0 r509 s505 phone5 c502 ic 503 cz54 d 508 c509 c508 tp501 c510 d5 0 6 r5 1 9 d5 0 7.

  • Page 21

    Troubleshooting guide push the power supply is the amber led amber yes no can pressing any key make ok is it red? Yes check the protect ciruit no check the 5v supply circuit (on main board) no no is the standby singal low level? Check the standby control circuit is the abmer led green? Yes no check ...

  • Page 22

    Circuit no. Part no. Description ics ic11, ic21 03-00082-00 tl082cp/cn/d ic31 03-01117-01 ams1117-5.0/ lm1117mpx-5.0 ic502 03-02402-00 24c01a/24c02(a)/24c04(a) u301 03-09164-00 tc9164cng ic501 03-08951-13 at89s51-24pi/ w78e052c40dl programmed ic501 03-08951-03 at89s51-24pi/ w78e052c40dl unprogrammed...

  • Page 23

    C134, c135, c234, c235, c325, c326, c328, c506, c507, c511, c512 24-10461-00 0.1uf, 63v, ±20% c327, c338 24-22461-00 0.22uf, 63v, ±20% c117, c142, c145, c217, c242, c245 25-22361-05 22n, 63v, ±5% c130, c230 25-47361-01 47n, 63v, ±5% c111, c114, c116, c118, c122, c127, c138, c139, c141, c211, c214, c...

  • Page 24

    R150, r151, r184, r185, r250, r251, r284, r285, r301, r303, r501, r502, r503, r504, r505, r507, r508, r513, r514, r515, r516 07-10103-50 10kΩ, 1/6w, ±5% r192, r292 07-10153-50 15kΩ, 1/6w, ±5% r139, r239 07-10203-50 20kΩ, 1/6w, ±5% r141, r142, r180, r241, r242, r280, r320 07-10223-50 22kΩ, 1/6w, ±5% ...

  • Page 25

    Relays rl301 12-03102-00 jqx-115f/024-2hs4af connecters cb54 13-22503-00 xhb2.5a-3a cb31, cb32 13-22505-00 xhb2.5a-5a cb34 13-22509-00 xhb2.5a-9a cb53 13-21219-00 fpc1.25 19pin 4rca 17-01004-00 av4-8.4-13 6rca 17-01006-00 av6-8.4-13 binding post(red) 73-001003-0 hs4-c320-b009v1-p003 bdp cap(red) 73-...

  • Page 26

    Q117, q217 31-05200-00 2sc5200 heat conductive pad 78-001004-0 berquist sil-pad k06-122 plastic plug 75-076002-0 hs4-c315bee-b009v1-p007 circuit no. Part no. Description diodes d501 33-50525-00 ž5 dual color switchs s507 11-04101-00 it-1102d-1160 connecter cz52 13-22504-00 xhb2.5a-4a circuit no. Par...

  • Page 27

    Tp501-----classis 14-32501-12 1007#, 24awg,35mm cz54——cb54 14-31503-01 scn 2.5a-3d,xhb 2.5a-3y DŽ ul1691, 24awg/26awg, 500mm cb52-------cz52 14-31504-00 xhb 2.54a-4y ˈld2.5a-4dw ˄jc˅ˈ 26awg ul2468# ˈ 62mm circuit no. Part no. Description pot rt33 09-01203-01 rk16812mg 20kbx2 connecter cz34 13-22509-0...

  • Page 28

    Batteries 30-28601-00 cr2025 fasteners self taping screw 61-023106-0 stb3×6 self taping screw 61-084108-0 stpw4×8 self taping screw 61-023208-0 btb3×8 self taping screw 61-023206-0 btb3×6 self taping screw 61-023204-0 btb3×4 self taping screw 61-063108-0 stf3×8 self taping screw 61-022208-6 btb2.6×8...

  • Page 29

    F001 f004 f006 f008 f002 f010 f009 f007 f003 f005 f011 c001 c002 c003 c004 c005 c006 c008 c009 c010 c011 c012 c013 c015 c016 c017 t001 r001 r002 r003 r004 s001 s002 s003 s004 s005 s007 s007 s004 s006 s008 s004 s009 s010 s011 s016 s013 s014 s015 s004 s012 c007 01-31500-00 : heatsink assembly with tr ...

  • Page 30

    Ref.No part no. Description qty. Ref.No part no. Description qty. C001 66-076001-1 chassis 1 r001 80-076002-1 rear panel 1 c002 66-076004-1 service cover 1 r002 11-01101-03 rocker switch 1 c003 75-076001-1 foot pad 4 r003 85-070001-0 cable tie 1 c004 78-076001-0 foot pad 4 r004 15-02250-00 ac cord ˄...

  • Page 31

    P roprie ta ry informa tion for s e rvic ing purpos e s only. T he informa tion he re in ma y not be us e d c omme rc ia lly without the prior writte n a gre e me nt of n a d inte rna tiona l, toronto, c a na da . 01 90-009002-1 non woven cloth 1 02 90-001013-0 ac c ord p olybag 1 03 90-027001-0 p o...

  • Page 32: Memo

    Memo.

  • Page 33: Ser

    Ser vice manual © nad 2008 c 315bee stereo amplifier nad electronics ltd toronto.